2004 Ford Transit

Manufactures body covers installed underneath vehicle restricting visual inspection.

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement Rear (5.3.4 (a) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement Rear (5.3.4 (a) (i))

Offside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Suspension component mounting repair covered in underseal (5.3.6 (a) (i))

Whole of vehicle has been undersealed hard to inspect for corrosion

Rear Prop shaft bearing excessively worn Rear bush (6.1.7 (b) (i))

Manufactures body covers installed underneath vehicle restricting visual inspection.

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement Rear (5.3.4 (a) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement Rear (5.3.4 (a) (i))

Offside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Whole of vehicle has been undersealed hard to inspect for corrosion

Manufactures engine and body covers fitted restricting full inspection

under body coated in heavy under seal

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced INNER SILL (6.1.1 (c) (i))

Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced INNER SILL (6.1.1 (c) (i))

Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced INNER CHASSIS LEG (6.1.1 (c) (i))

Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced INNER WHEEL ARCH (6.1.1 (c) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Rear Nail in tyre ()

Nearside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Steering linkage ball joint has slight play (2.1.3 (b) (i))

Vehicle structure slightly corroded within 30cm of towbar mounting vehicle shows signs of corrosion underneath but covered in underseal (6.1.6 (i) (i))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement wishbone arm (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Drivers seat base slightly worn.

Nearside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement Rear bush. (2.4.G.2)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Suspension arm synthetic bush deteriorated but not resulting in excessive movement Rear bush. (2.4.G.2)

Power steering pipe(s) or hose(s) slightly corroded From rack. (2.3.2)

Vehicle structure has slight corrosion o/s/r and n/s/r chassis corroded (6.1.B.2)

brake disc worn, pitted or scored, but not seriously weakened Both front inside edges. (3.5.1i)

small cut in o/s/r tyre tread.

Fuel cap/sealing device does not fasten securely by positive means (7.2.4b)

Offside Front Track rod end ball joint has excessive play (2.2.B.1f)

Drivers seat base slightly worn.

Nearside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement Rear bush. (2.4.G.2)

Nearside Headlamp aim too low (1.8)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Suspension arm synthetic bush deteriorated but not resulting in excessive movement Rear bush. (2.4.G.2)

Power steering pipe(s) or hose(s) slightly corroded From rack. (2.3.2)

Vehicle structure has slight corrosion o/s/r and n/s/r chassis corroded (6.1.B.2)

brake disc worn, pitted or scored, but not seriously weakened Both front inside edges. (3.5.1i)

small cut in o/s/r tyre tread.

Nearside Front Outer Seat belt damaged but webbing not significantly weakened (5.2.2a)

Nearside Front Upper Suspension arm rubber bush deteriorated but not resulting in excessive movement Rear bush. (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement Rear bush. (2.4.G.2)

Power steering pipe(s) or hose(s) slightly corroded (2.3.2)

Rear axle has slight end float n/s and o/s

Slight play in drivers seat .

Nearside Front Tyre has ply or cords exposed (4.1.D.1b)

Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Nearside Rear Tyre has ply or cords exposed Worn low and perished. (4.1.D.1b)

Offside Front Front position lamp(s) not working (1.1.A.3b)

Rear Exhaust system not adequately supported (7.1.1)

Nearside Front Outer Seat belt damaged but webbing not significantly weakened (5.2.2a)

Nearside Front Upper Suspension arm rubber bush deteriorated but not resulting in excessive movement Rear bush. (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement Rear bush. (2.4.G.2)

Power steering pipe(s) or hose(s) slightly corroded (2.3.2)

Rear axle has slight end float n/s and o/s

Rear step corroded.

Slight play in drivers seat .

Both front road springs corroded.

Both rear tyres close to TWI's.

Brake pipes corroded, front and rear.

Door trim around side door entrance damaged.

Exhaust corroded.

Internal cabin rubber blanking rubber grommets missing.

Low pressure power steering pipe corroded.

Nearside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Rear offside axle bump stop missing.

Rear offside tyre perished.

Window screen scratched by wipers.

Both front road springs corroded.

Both rear tyres close to TWI's.

Brake pipes corroded, front and rear.

Door trim around side door entrance damaged.

Exhaust corroded.

Internal cabin rubber blanking rubber grommets missing.

Low pressure power steering pipe corroded.

Nearside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Nearside Front position lamp(s) not working (1.1.A.3b)

Nearside Rear Seat belt retracting mechanism defective (5.2.5b)

Offside Headlamp aim too high (1.8)

Rear offside axle bump stop missing.

Rear offside tyre perished.

Registration plate lamp shows direct white light to the rear (1.1.C.1f)

Window screen scratched by wipers.

Both front road springs corroded.

Brake pipes corroded in clips, both front and rear offside.

Engine oil level on bottom mark.

General corrosion to vehicle underside.

Nearside Front Seat belt stitching slightly frayed (5.2.2b)

Offside Front Seat belt retracting mechanism defective (5.2.5b)

Offside Registration plate lamp not working (1.1.C.1d)

Oil leak

Power steering pipe corroded.

Second seat from rear, nearside seal belt post cushion missing.

Slight rear axle end float on both sides.

Slight rear brake judder apperant.

Window sill hole cover grommets missing.

Both front road springs corroded.

Brake pipes corroded in clips, both front and rear offside.

Engine oil level on bottom mark.

General corrosion to vehicle underside.

Nearside Front Seat belt stitching slightly frayed (5.2.2b)

Oil leak

Power steering pipe corroded.

Second seat from rear, nearside seal belt post cushion missing.

Slight rear axle end float on both sides.

Slight rear brake judder apperant.

Window sill hole cover grommets missing.

Brake pipe slightly corroded (3.6.B.2c)

General corrosion to chassis and front sub frame.

Items removed from driver's view prior to test

Nearside Front Upper Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Windscreen wiper blade insecure (8.2.2)

Oil leak

Power steering pipe corroded from rack

Rear seats,row 1 and row 3 ,top seat belt trim missing/damaged .

brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Brake pipe slightly corroded (3.6.B.2c)

General corrosion to chassis and front sub frame.

Items removed from driver's view prior to test

Nearside Front Upper Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak

Power steering pipe corroded from rack

Rear seats,row 1 and row 3 ,top seat belt trim missing/damaged .

brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Brake pipe slightly corroded (3.6.B.2c)

Center exhaust box corroded.

Child seat fitted not allowing full inspection of adult belt

Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

N/S/R center seat .top trim damaged.

Offside Front Front wheel bearing has slight play (2.5.A.3c)

Offside Front Track rod end ball joint dust cover damaged, but preventing the ingress of dirt (2.2.C.1c)

Rubber grommets missing N/S/R inner .under window.

Vehicle structure has slight corrosion (6.1.A.1)

Coolant expansion cap missing.

Front brake discs, pitted on inner faces.

Offside Front Front wheel bearing has slight play (2.5.A.3c)

Service light on.

Side door step trim damaged.

Passenger side door inop.

Rear outer seat belt buckles not attached to seat cushions,trip hazard.

Nearside Front Tyre tread pattern not visible over the whole tread area when minimum depth required is 1.0mm (4.1.E.2a)

Nearside Rear Tyre tread pattern not visible over the whole tread area when minimum depth required is 1.0mm (4.1.E.2a)

Offside Front Tyre tread pattern not visible over the whole tread area when minimum depth required is 1.0mm (4.1.E.2a)

Coolant expansion cap missing.

Front brake discs, pitted on inner faces.

Nail in nearside rear tyre

Offside Front Front wheel bearing has slight play (2.5.A.3c)

Offside Headlamp aim too high and too far to the right. (1.8)

Service light on.

Side door step trim damaged.

Passenger side door inop.

Rear outer seat belt buckles not attached to seat cushions,trip hazard.

Both front tyres worn on inner tread.

Centre nearside seat belt, top guide cover damaged.

Front Brake pad(s) wearing thin (3.5.1g)

Front brake discs pitted.

Long handbrake travel.

Nearside Rear Tyre worn close to the legal limit (4.1.E.2b)

Offside steering rack end slight play.

Plastic trim hole covers missing on nearside window sill.

Power steering pipes corroded.

Rear nearside seat back restraint to bodywork anchor bolt spacer incorrectly fitted.

Brake pipe slightly corroded (3.6.B.2c)

Front brake disc slightly pitted (3.5.1g)

f/n/s power steering pipe corroded

sharp edges/holes below nearside side windows.

trip hazard, rear seat belt stalks insecure

two rear seats have slight damage to trim (top of seat)

Brake pipe slightly corroded (3.6.B.2c)

Front brake disc slightly pitted (3.5.1g)

Nearside Headlamp aim too low (1.6)

f/n/s power steering pipe corroded

sharp edges/holes below nearside side windows.

trip hazard, rear seat belt stalks insecure

two rear seats have slight damage to trim (top of seat)

Front brake disc slightly pitted (3.5.1h)

Centre Passenger door cannot be opened from outside the vehicle (6.5.11a)

Nearside Inner Rear Seat belt retracting mechanism defective (5.1.B.6b)

Nearside Rear Upper Passenger door does not latch securely closed (6.5.11b)

Front Brake pad(s) wearing thin (3.5.1e)

Centre Seat belt retracting mechanism defective (5.1.B.6b)