2004 Ford Transit

Brake pedal has insufficient reserve travel (1.1.2 (a))

Front Brakes imbalanced across an axle (1.2.1 (b) (i))

Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i))

Nearside Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Nearside Outer Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced above axle (6.1.1 (c) (i))

Offside Front Inner Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced wing (6.1.1 (c) (i))

Offside Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Offside Outer Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced above axle (6.1.1 (c) (i))

Rear Brakes imbalanced across an axle (1.2.1 (b) (i))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting crossmember (6.2.2 (d) (i))

Service brake efficiency below requirements (1.2.2 (a) (i))

Vehicle structure inadequately repaired such that structural rigidity is significantly reduced all patches that have been put on (6.1.1 (d) (i))

Front Brakes imbalanced across an axle by more than 50% Axle 1 (1.2.1 (b) (ii)) DANGEROUS

Oil leaking continuously from engine posing a serious risk to road safety (8.4.1 (a) (ii)) DANGEROUS

Nearside Play in steering rack inner joint(s) ()

Both rear suspension bump stops corroded and loose

Both wipers juddering

Brake pedal wearing smooth (1.1.2 (c))

Brake pipe corroded, covered in grease or other material Front to rear (1.1.11 (c))

Exhaust system corroded

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Front Sub-frame is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Front Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Coil spring corroded (5.3.1 (b) (i))

Offside Drivers door handle faulty

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Coil spring corroded (5.3.1 (b) (i))

Offside Inner and outer sill heavily corroded

Offside Rear Number plate light dim

Oil leak, but not excessive Engine (8.4.1 (a) (i))

Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Front Prop shaft bearing housing likely to fail (6.1.7 (f) (ii)) DANGEROUS

Rear Prop shaft bearing housing likely to fail (6.1.7 (f) (ii)) DANGEROUS

Both rear suspension bump stops corroded and loose

Both wipers juddering

Brake pedal wearing smooth (1.1.2 (c))

Brake pipe corroded, covered in grease or other material Front to rear (1.1.11 (c))

Exhaust system corroded

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Front Sub-frame is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Front Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Coil spring corroded (5.3.1 (b) (i))

Offside Drivers door handle faulty

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Coil spring corroded (5.3.1 (b) (i))

Offside Inner and outer sill heavily corroded

Offside Rear Number plate light dim

Oil leak, but not excessive Engine (8.4.1 (a) (i))

Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Both rear bump stops heavily corroded and loose

Brake pedal wearing smooth (1.1.2 (c))

Central propshaft mounting worn

Corrosion to both front chassis rails

Imbalance front brakes

Nearside Front Coil spring corroded (5.3.1 (b) (i))

Nearside Rear Chassis corroded

Offside Front Coil spring corroded (5.3.1 (b) (i))

Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c))

Nearside Rear Service brake excessively binding (1.2.1 (f))

Nearside Rear Stop lamp(s) adversely affected by the operation of another lamp (4.3.3 (b))

Offside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii))

Offside Rear Rear fog lamp not working (4.5.1 (a) (ii))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis within 30cm of shock mount (5.3.6 (a) (i))

Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c))

Offside Front Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Imbalance front brakes

Both front tyres different profile to rear

Both rear bump stops heavily corroded and loose

Brake pedal wearing smooth (1.1.2 (c))

Central propshaft mounting worn

Corrosion to both front chassis rails

Nearside Front Coil spring corroded (5.3.1 (b) (i))

Nearside Rear Chassis corroded

Offside Front Coil spring corroded (5.3.1 (b) (i))

Offside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement rear bush (5.3.4 (a) (i))

exccesive end float on nearside and offside rear axle shafts

Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement rear bush (5.3.4 (a) (i))

exccesive end float on nearside and offside rear axle shafts

Brake pedal wearing smooth (1.1.2 (c))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Oil leak, but not excessive (8.4.1 (a) (i))

corrosion to outer sills

Driver's door cannot be opened from outside the vehicle (6.2.3 (a))

Front Sub-frame corroded and seriously weakened (5.3.3 (b) (i))

Nearside Front Brake pipe excessively corroded (1.1.11 (c))

Nearside Rear Brake pipe excessively corroded (1.1.11 (c))

Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i))

Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i))

Nearside Rear Service brake excessively binding (1.2.1 (f))

Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i))

Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i))

Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i))

Offside Rear Service brake excessively binding (1.2.1 (f))

Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis behind crossmember (5.3.6 (a) (i))

Brake pedal wearing smooth (1.1.2 (c))

Oil leak, but not excessive (8.4.1 (a) (i))

corrosion to outer sills

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside headlamp pattern poor

Oil leak ()

corrosion to underside of vehicle

Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Front Inner Suspension spring mounting prescribed area is excessively corroded wheel arch (2.4.A.3)

Nearside Headlamp not working on main beam (1.7.5a)

Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded sill (2.4.A.3)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded bumper mount (2.4.A.3)

Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement rear bush (2.4.G.2)

Offside Rear Inner Suspension component mounting prescribed area is excessively corroded sill (2.4.A.3)

Offside Rear Inner Suspension spring mounting prescribed area is excessively corroded sill by leaf spring mount (2.4.A.3)

Offside Rear Suspension spring mounting prescribed area is excessively corroded bumper mount (2.4.A.3)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside headlamp pattern poor

Oil leak ()

corrosion to underside of vehicle

Coolant leak ()

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Offside door handle stiff

Oil leak ()

corrosion to underside of vehicle & outer sills

Nearside Front position lamp(s) not working (1.1.A.3b)

Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded sill (2.4.A.3)

Nearside Rear Inner Suspension component mounting prescribed area is excessively corroded wheel arch (2.4.A.3)

Nearside rear brake binding (3.7.B.1)

Offside Front Inner Seat belt anchorage prescribed area is excessively corroded sill (5.2.6)

Offside Rear Inner Suspension component mounting prescribed area is excessively corroded wheel arch x2 (2.4.A.3)

Coolant leak ()

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Offside door handle stiff

Oil leak ()

corrosion to underside of vehicle & outer sills

Brake pedal rubber worn

Nearside Front metal brake pipe corroding

Nearside Outer sill holed but not prescribed area

Offside Front tyre worn on edges

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Registration plate lamp not working (1.1.C.1d)

Offside Stop lamp adversely affected by the operation of another lamp (1.2.1f)

Brake pedal rubber worn

Nearside Front metal brake pipe corroding

Nearside Outer sill holed but not prescribed area

Offside Front tyre worn on edges

Nearside Rear Outer Suspension component mounting prescribed area is excessively corroded sill (2.4.A.3)

Nearside Rear Suspension component mounting prescribed area is excessively corroded chassis (2.4.A.3)

Nearside Rear position lamp(s) adversely affected by the operation of another lamp (1.1.A.3f)

Nearside Registration plate lamp not working (1.1.C.1d)

Nearside Stop lamp not working (1.2.1b)

Offside Rear Inner Suspension component mounting prescribed area is excessively corroded sill (2.4.A.3)

Offside Rear Inner Suspension component mounting prescribed area is excessively corroded wheelarch X2 (2.4.A.3)

Offside Rear Outer Suspension component mounting prescribed area is excessively corroded sill (2.4.A.3)

Offside Rear Suspension component mounting prescribed area is excessively corroded chassis (2.4.A.3)

Offside Rear rear brake binding (3.7.B.1)

Offside Registration plate lamp not working (1.1.C.1d)

Windscreen washer provides insufficient washer liquid (8.2.3)

Brake pedal rubber worn.

Nearside Front metal brake pipe corroding.

Nearside Outer holed but not prescribed area.

Offside Front tyre worn on edges.

Nearside Front Anti-roll bar rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Front Anti-roll bar rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak

Play in prop-shaft centre bearing

both sills corroded not within prescribed areas at time of test

rear exhaust rubber broken

rear step excessively corroded

wiper blades in poor condition

Nearside Headlamp aim too high (1.8)

Nearside Outer Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Headlamp aim too low (1.8)

Offside Outer Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Outer Rear Suspension spring mounting prescribed area is inadequately repaired (2.4.A.3)

Offside Rear fog lamp not working (1.3.2b)

Offside Rear position lamp(s) adversely affected by the operation of another lamp (1.1.A.3f)

Windscreen has a sticker or other obstruction encroaching into the swept area by more than 40mm outside zone 'A' (8.3.1e)

Play in prop-shaft centre bearing

Nearside Front Anti-roll bar rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Front Anti-roll bar rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak

both sills corroded not within prescribed areas at time of test

rear exhaust rubber broken

rear step excessively corroded

wiper blades in poor condition

Front Suspension component mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Front bumper insecure

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Inner Front Road wheel slightly damaged (4.2.A.1a)

Offside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Seat belt stitching slightly frayed (5.2.2b)

Rear Suspension component mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Inner Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Outer Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Headlamp aim too low (1.8)

Offside Inner Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Outer Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear Brake pipe excessively corroded (3.6.B.2c)

Offside Rear fog lamp not working (1.3.2b)

Offside Registration plate lamp not working (1.1.C.1d)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Front Suspension component mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Front bumper insecure

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Inner Front Road wheel slightly damaged (4.2.A.1a)

Offside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Seat belt stitching slightly frayed (5.2.2b)

Rear Suspension component mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Front coil springs are corroded.

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Stop lamp not working (1.2.1b)

Offside Track rod end ball joint has excessive play (2.2.B.1f)

Front coil springs are corroded.

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Rear An item not tested (Manual)

Nearside Track rod end ball joint has excessive play (2.2.B.1f)

Nearside rear brake binding (3.7.B.1)

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

n/s rear tyre slow punture

Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Front Windscreen has damage to the swept area in excess of a 40mm circle outside zone 'A' (8.3.1d)

Nearside Rear Stop lamp not working (1.2.1b)

n/s rear tyre slow punture