2002 Isuzu Trucks Nkr 77 Turbo Electric Di

Cab insecure (6.2.2 (a) (i))

Cab obviously not squarely located on chassis (6.2.2 (b))

Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f))

Fuel tank insecure (6.1.3 (a) (i))

Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i))

Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i))

Nearside Front Shock absorbers has an excessively worn bush (5.3.2 (c))

Nearside Front Suspension arm attachment bracket/mounting corroded and seriously weakened rear most mount (5.3.3 (b) (i))

Nearside Rear Service brake lagging in operation (1.2.1 (d))

Nearside Stop lamp(s) not working (4.3.1 (a) (ii))

Offside Front Brake modification unsafe compression fittings used as joiners on both front to rear brake pipes (1.1.21 (d) (i))

Offside Front Brake pipe excessively corroded (1.1.11 (c))

Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i))

Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i))

Offside Front Steering arm deformed steering idler excessive play (2.1.3 (c) (i))

Offside Front Suspension arm attachment bracket/mounting corroded and seriously weakened rear most mount (5.3.3 (b) (i))

Offside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Rear Service brake effort inadequate at a wheel (1.2.1 (a) (i))

Offside Rear Service brake lagging in operation (1.2.1 (d))

Offside Rear Shock absorbers has a serious fluid leak (5.3.2 (b))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Service brake efficiency below requirements (1.2.2 (a) (i))

Front Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Front Suspension spring mounting prescribed area is corroded but not considered excessive torsion bar mounts (5.3.6 (a) (i))

Nearside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Nearside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Nearside Registration plate lamp throwing direct white light to the rear (4.7.1 (a))

Offside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Steering box has slight free play detected at steering wheel (2.3 (a) (i))

Suspension arm corroded but not seriously weakened All front (5.3.3 (b) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Front Welding not very tidy but has penetrated and is covered in Undereal

Nearside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Offside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Offside Front Windscreen wiper blade defective (3.4 (b) (i))

exhaust system cut short

front cross member corroded and covered in underseal

Headlamp levelling device inoperative (4.1.5 (a))

Nearside Body component corroded and likely to cause injury front corner of tipper body (6.2.1 (a) (i))

Offside Body component corroded and likely to cause injury front corner of tipper body (6.2.1 (a) (i))

Nearside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Offside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Offside Front Windscreen wiper blade defective (3.4 (b) (i))

exhaust system cut short

front cross member corroded and covered in underseal

Emissions not tested due excessive condition of exhaust system (8.2.2.2 (e))

Offside Front Headlamp insecure (4.1.1 (c))

Offside Rear Exhaust has a major leak of exhaust gases (6.1.2 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Front Vehicle structure has excessive corrosion which adversely affects braking or steering area above torsion bars (6.1.1 (c) (ii)) DANGEROUS

Offside Front drivers seat base deteriorated

Rear Brake pipe corroded, covered in grease or other material from brake valve to hose (1.1.11 (c))

Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

unable to read oil temperature due to cab holdind catch fault

Offside Rear Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Offside exhaust mount broken, system adequately supported

Offside fuel tank supporting brackets corroded

Rear Shock absorbers has slight external damage to the casing both shock absorbers corroded (5.3.2 (b))

exhaust corroded

minor leak of exhaust gas

Front Brake pipe excessively corroded 3 pipes behind cab grill (1.1.11 (c))

Fuel cap/sealing device ineffective unable to remove fuel cap from tank (6.1.3 (b) (i))

Nearside Battery insecure and likely to cause a short circuit (4.13 (a) (ii))

Nearside Front Brake pipe excessively corroded (1.1.11 (c))

Nearside Rear Brake pipe excessively corroded 2 pipes (1.1.11 (c))

Nearside Rear Direction indicator incorrect colour showing white light (4.4.3 (a))

Offside Front Brake hydraulic reservoir fluid level significantly below minimum level (1.1.10 (d) (ii))

Offside Front Brake pipe excessively corroded (1.1.11 (c))

Offside Rear Brake pipe excessively corroded (1.1.11 (c))

Offside Rear Direction indicator not working (4.4.1 (a) (ii))

Offside Rear Rear fog lamp not working (4.5.1 (a) (ii))

Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Front Brake pipe leaking on a hydraulic braking system causing loss of braking effort (1.1.11 (b) (ii)) DANGEROUS

Nearside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) DANGEROUS

Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) DANGEROUS

Offside Front Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) DANGEROUS

Offside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) DANGEROUS

Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) DANGEROUS

Brake pipe corroded, covered in grease or other material all brake pipes covered with underseal (1.1.11 (c))

Exhaust mounting defective mounting strap fractured, system adequately supported (6.1.2 (a))

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Position lamp insecure light broken and ibsecure (4.2.1 (c) (i))

Nearside Rear Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Service brake binding but not excessively (1.2.1 (f))

Offside Rear minor leak of exhaust gas

Offside fuel tank mounting brackets corroded

Rear Shock absorbers has slight external damage to the casing both rear shock absorbers corroded (5.3.2 (b))

exhaust system corroded

Nearside Front Lower Suspension arm ball joint has slight play (5.3.4 (a) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge 2mm (5.2.3 (e))

Offside Front Lower Suspension arm ball joint has slight play (5.3.4 (a) (i))

Offside Rear Tyre worn close to legal limit/worn on edge and cracking in tread (5.2.3 (e))

Nearside Rear Tyre worn close to legal limit/worn on edge 3mm, legal limit 1.6mm. 205/75r16c. 110/108r 8pr (5.2.3 (e))

Offside Rear Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Rear both rear tyres cracking in tread area

All Brake Pipe covered in Paint or Waxoil

Front Both front Brake grabbing slightly

Nearside Rear Tyre worn close to the legal limit 205 75 16 110/108 (4.1.E.1)

Ball joint has slight play (2.2.B.1f)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Front Shock absorber has a slightly worn bush (2.7.4)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

all metal brake pipes slightly corroded

Exhaust has a major leak of exhaust gases (7.1.2)

Exhaust tailpipe not capable of allowing the emission probe to be inserted (7.4.B.1)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Rear position lamp(s) not working (1.1.A.3b)

Offside Stop lamp not working (1.2.1b)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Windscreen has damage to an area in excess of a 10mm circle within zone 'A' (8.3.1a)

Windscreen washer provides insufficient washer liquid (8.2.3)

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Oil leak

all metal brake pipes starting to corrode

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Brakes imbalanced across an axle (3.7.B.5b)

Nearside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2)

Nearside Rear Direction indicator insecure (1.4.A.2b)

Nearside Rear Stop lamp not working (1.2.1b)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Steering pivot point has slight play (2.2.B.1g)

Oil leak

Service brake: service brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Suspension joint nearside lower dust cover split/missing

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

battery tray has some corrosion to it tested with corrosion tool

Exhaust has part of the system slightly deteriorated (7.1.1a)

Nail in nearside front tyre

Nail in nearside rear tyre

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Steering system has slight free play detected at steering wheel (2.2.A.1a)

Suspension joint nearside lower dust cover split/missing

Vehicle structure has slight corrosion (6.1.A.1)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

cut in o/s/f tyre no cords exposed

n/s/r tyre has cut in sidewall,no cords exposed

An item not tested (Manual)

Exhaust system not adequately supported (7.1.1)

Nearside Headlamp aim too far to the right (1.8)

Offside Headlamp aim too low (1.8)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Nail in nearside front tyre

Nail in nearside rear tyre

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Steering system has slight free play detected at steering wheel (2.2.A.1a)

Suspension joint nearside lower dust cover split/missing

Vehicle structure has slight corrosion (6.1.A.1)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

cut in o/s/f tyre no cords exposed

n/s/r tyre has cut in sidewall,no cords exposed

Hinged tailboard cannot be secured in the closed position (6.4.1)

Nearside Statutory seat belt missing (5.1.1)

Offside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Registration plate lamp not working (1.1.5c)

Stop lamp not working (1.2.1b)

Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside Front Upper Suspension arm has slight play in a pin/bush (2.4.G.2)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Front Upper Suspension arm has slight play in a pin/bush (2.4.G.2)

power sterring belt loose

Nearside Rear Tyre has ply or cords exposed (4.1.D.1b)

Nearside Front brake disc slightly pitted (3.5.1h)

Offside Front brake disc slightly pitted (3.5.1h)

Oil leak

tyre sizes 205/75R16C

Front Windscreen washer provides insufficient washer liquid (8.2.3)

Nearside Front Headlamp aim too low when the centre of the headlamp is below 850mm from the ground (1.6.B2)

Offside Front Headlamp aim too low when the centre of the headlamp is below 850mm from the ground (1.6.B2)

Parking brake lever has no reserve travel (3.1.6b)