2004 Ford Transit

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Integral body structure is corroded but structural rigidity is not significantly reduced both inner and outer sills outside prescribed areas [ attention soon ] (6.1.1 (c) (i))

Nearside Non obligatory mirror damaged small lower mirror ()

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Lower Suspension component ball joint has slight play (5.3.4 (a) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive outer chassis behind rear wheel (5.3.6 (a) (i))

Offside Seat belt anchorage prescribed area is corroded but not considered excessive (7.1.1 (a) (i))

Offside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Oil leak, but not excessive close to fail criteria (8.4.1 (a) (i))

Power steering pump has slight seepage attention soon (2.1.5 (a))

Power steering pump has slight seepage steering rack (2.1.5 (a))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Rear Suspension component mounting prescribed area is corroded but not considered excessive inner chassis both sides above axle (5.3.6 (a) (i))

Suspension arm pin or bush worn but not resulting in excessive movement both lower arms rear inner bushes worn [ may need attention soon ] (5.3.4 (a) (i))

Suspension component mounting repair covered in underseal front and rear (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength OUTER chassis 30cm shock absorber mount (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch areas (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength upper inner wing (5.3.6 (a) (i))

Offside Headlamp levelling device inoperative (4.1.5 (a))

Offside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Power steering component leaking steering rack [ very noisy ] (2.1.5 (a))

Rear Service brake excessively fluctuating both sides (1.2.1 (e))

Windscreen washer provides insufficient washer liquid no fluid to windscreen (3.5 (a))

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement both sides rear inner bushes worn (5.3.4 (a) (i))

Gearbox mounting defective nut missing from mount ()

Integral body structure is corroded but structural rigidity is not significantly reduced both inner /outer sills just outside prescribed areas (6.1.1 (c) (i))

Integral body structure is corroded but structural rigidity is not significantly reduced both rear chassis inner side corroded (6.1.1 (c) (i))

Nearside Front Direction indicator lens defective which has no effect on emitted light (4.4.1 (b) (i))

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive upper inner wing / lower inner wing (5.3.6 (a) (i))

Nearside Non obligatory mirror damaged small lower ()

Nearside Rear Suspension component mounting repair covered in underseal (5.3.6 (a) (i))

Offside Front Lower Suspension component ball joint has slight play may need attention soon (5.3.4 (a) (i))

Offside Front Seat belt anchorage prescribed area is corroded but not considered excessive (7.1.1 (a) (i))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive chassis near engine mount (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive outer chassis near shock mount [ ATTENTION SOON ] (5.3.6 (a) (i))

Offside Rear Suspension component mounting repair covered in underseal (5.3.6 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing cord not exposed at test (5.2.3 (d) (ii))

Offside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Oil leak, but not excessive close to fail criteria will need attention soon (8.4.1 (a) (i))

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear inner bush both sides (5.3.4 (a) (i))

Integral body structure is corroded but structural rigidity is not significantly reduced front and centre inner sills outside prescribed areas/o/s upper and n/s upper inner wings (6.1.1 (c) (i))

Nearside Front Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Nearside Non obligatory mirror damaged small lower mirror ()

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Oil leak, but not excessive close to fail criteria (8.4.1 (a) (i))

Rear Service brake fluctuating, but not excessively noisy in operation in brake roller test (1.2.1 (e))

Vehicle structure is corroded but structural rigidity is not significantly reduced both sides behind rear wheels (6.1.1 (c) (i))

Fuel cap/sealing device ineffective not maintaining a positive seal (6.1.3 (b) (i))

Hydraulic brake calliper leaking where hose mounts to calliper [ copper washer ] (1.1.16 (b) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength front end of rear spring inner/outer sill (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear end of spring mount (5.3.6 (a) (i))

Nearside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Offside Headlamp levelling device inoperative (4.1.5 (a))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength front end of rear spring inner/outer sill (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear end of spring mount (5.3.6 (a) (i))

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear inner bush both sides (5.3.4 (a) (i))

Integral body structure is corroded but structural rigidity is not significantly reduced front and centre inner sills outside prescribed areas/o/s upper and n/s upper inner wings (6.1.1 (c) (i))

Nearside Front Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Nearside Non obligatory mirror damaged small lower mirror ()

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Oil leak, but not excessive close to fail criteria (8.4.1 (a) (i))

Rear Service brake fluctuating, but not excessively noisy in operation in brake roller test (1.2.1 (e))

Vehicle structure is corroded but structural rigidity is not significantly reduced both sides behind rear wheels (6.1.1 (c) (i))

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear inner bushes both sides (5.3.4 (a) (i))

Nearside Front Tyre worn close to legal limit/worn on edge below wear bands [ attention soon ] (5.2.3 (e))

Nearside Integral body structure is corroded but structural rigidity is not significantly reduced outer sill several places (6.1.1 (c) (i))

Offside Front Integral body structure is corroded but structural rigidity is not significantly reduced inner / outer sill outside prescribed area (6.1.1 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Emissions not tested coolant leak (8.2.2.2 (e))

Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b))

Nearside Rear Direction indicator not working (4.4.1 (a) (ii))

Nearside Rear Position lamp not working (4.2.1 (a) (ii))

Nearside Rear Service brake excessively fluctuating (1.2.1 (e))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength front end of rear spring 2 places (5.3.6 (a) (i))

Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Offside Headlamp aim too high (4.1.2 (a))

Offside Headlamp levelling device inoperative (4.1.5 (a))

Offside Rear Service brake lagging in operation (1.2.1 (d))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear end of spring 2 places (5.3.6 (a) (i))

Offside Steering rack gaiter missing or no longer prevents the ingress of dirt gaiter split (2.1.3 (g) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Stop lamp(s) all not working (4.3.1 (a) (iii)) DANGEROUS

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear inner bushes both sides (5.3.4 (a) (i))

Nearside Front Tyre worn close to legal limit/worn on edge below wear bands [ attention soon ] (5.2.3 (e))

Nearside Integral body structure is corroded but structural rigidity is not significantly reduced outer sill several places (6.1.1 (c) (i))

Offside Front Integral body structure is corroded but structural rigidity is not significantly reduced inner / outer sill outside prescribed area (6.1.1 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement both sides rear inner bushes perishing (5.3.4 (a) (i))

Offside Front inner sill below door corroded outside prescribed area

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt play in joint (5.3.4 (b) (ii))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner back panel 30 cm from spring mount (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill front end of rear spring (5.3.6 (a) (i))

Offside Windscreen damaged and affecting the driver's view of the road zone a (3.2 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Parking brake lever has excessive movement indicating incorrect adjustment brake performance n/s157 kg o/s202kg (1.1.6 (c))

Front Brake pad(s) wearing thin 3mm approx (1.1.13 (a) (ii))

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement both sides rear inner bushes perishing (5.3.4 (a) (i))

Offside Front inner sill below door corroded outside prescribed area

Offside Obligatory mirror slightly damaged (3.3 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Oil leak, but not excessive transmission (8.4.1 (a) (i))

Nearside Front Wheel bearing has excessive play noisy (5.1.3 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner floor area/rear outrigger/rear inner sill/ (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength upper inner wing (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner floor area /rear inner wheel arch area /rear inner sill area/ rear outrigger/rear outer sill front end rear spring (5.3.6 (a) (i))

Nearside Rear Tyre has ply or cords exposed cut in tread (5.2.3 (d) (ii)) DANGEROUS

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive upper inner wing (5.3.6 (a) (i))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Nearside Windscreen wiper blade defective slightly split (3.4 (b) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated perishing (6.1.7 (g) (i))

Offside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

both front lower arm rear inner bushes slightly perished

Offside Front inner wing corroded outside prescribed area

Front Anti-roll bar pin or bush excessively worn [D BUSHES] (5.3.4 (a) (i))

Front Exhaust has a major leak of exhaust gases [flexi section poor condition] (6.1.2 (a))

Nearside Direction indicator not working [fog lamp and side light flash instead of indicator] (4.4.1 (a) (ii))

Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt gaiter split (6.1.7 (g) (ii))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength [inner sill rear end of rear spring] (5.3.6 (a) (i))

Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced [inner step corroded] (7.1.1 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength [inner sill front end of rear spring] (5.3.6 (a) (i))

Offside Seat belt anchorage prescribed area strength or continuity significantly reduced [DOOR PILLAR/STRIKER PLATE FRACTURED] (7.1.1 (a) (i))

Registration plate lamp inoperative in the case of a single lamp or all lamps [BOTH] (4.7.1 (b) (ii))

Brake pipe corroded, covered in grease or other material main front to rear slightly corroded (1.1.11 (c))

Nearside centre inner sill corroded outside prescribed area

Offside Front Nail in tyre ()

Offside Front inner wing corroded outside prescribed area

Offside Seat belt slightly damaged (7.1.2 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

both track rod end gaiters slightly deteriorated

Brake pipe slightly corroded front to rear (3.6.B.2c)

Exhaust has a minor leak of exhaust gases (7.1.2)

rear brake fluctuating, but not excessively (3.7.B.3)

Nearside Front Seat belt anchorage prescribed area is excessively corroded behind step (5.2.6)

Nearside Front Suspension spring mounting prescribed area is excessively corroded inner wheel arch (2.4.A.3)

Nearside Rear position lamp(s) adversely affected by the operation of another lamp (1.1.A.3f)

Offside Front Suspension spring mounting prescribed area is excessively corroded inner wheel arch (2.4.A.3)

Registration plate lamp not working both (1.1.C.1d)

Brake pipe slightly corroded front to rear (3.6.B.2c)

Exhaust has a minor leak of exhaust gases (7.1.2)

rear brake fluctuating, but not excessively (3.7.B.3)

Emissions not tested front exhaust blow (7.3.A.1)

Front Exhaust has a major leak of exhaust gases flexi section (7.1.2)

Nearside Front Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside Front Suspension component mounting prescribed area is excessively corroded inner wing (2.4.A.3)

Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc SLIGHT HOLE (2.5.C.1a)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded FRONT AND REAR END OF REAR SPRINGS (2.4.A.3)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded INNER SILL AREAS (2.4.A.3)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Front Suspension component mounting prescribed area is excessively corroded inner wing (2.4.A.3)

Offside Rear Suspension spring mounting prescribed area is excessively corroded FRONT AND REAR END OF REAR SPRINGS (2.4.A.3)

Offside Rear Suspension spring mounting prescribed area is excessively corroded INNER SILL /ARCH AREAS (2.4.A.3)

Offside Registration plate lamp not working (1.1.C.1d)

BOTH REAR CHASSIS AREAS CORRODING BEHIND REAR WHEELS

Brake pipe slightly corroded MAIN FRONT TO REAR (3.6.B.2c)

EXHAUST OUTER CASINGS DETERIORATED

Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement BOTH SIDES (2.4.G.2)

Offside Seat belt damaged but webbing not significantly weakened (5.2.2a)

REAR SHOCKS WEAK

Front Exhaust has a minor leak of exhaust gases flexi pipe (7.1.2)

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

advise nearside front inner wing area slightly corroded

brake pedal rubber worn on edge

offside rear arch area slightly corroded

slightly damp around steering rack

Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Nearside Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Steering rack gaiter split (2.2.D.2d)

Offside Lower Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Offside Lower Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Offside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear wheel bearing rough when rotated (2.6.1)

Nearside Lower Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a) DANGEROUS

Front brake disc worn, pitted or scored, but not seriously weakened pads 5mm approx (3.5.1i)

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Tyre worn close to the legal limit on wear bands (4.1.E.1)

Nearside Outer Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Offside Front Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Oil leak ()

Play in steering rack inner joint(s) ()

nearside front inner wing area corroded outside prescribed area

o/s and n/s rear chassis slightly corroded

rear arch areas slightly corroded

Front Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Lower Anti-roll bar ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Nearside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Play in steering rack inner joint(s)

Offside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Rear Brake pipe excessively corroded (3.6.B.2c)

Front Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Lower Anti-roll bar ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Nearside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Play in steering rack inner joint(s)

NSF tyre inner sidewall worn thin

Anti-lock braking system warning lamp indicates an ABS fault (3.4.1c)

Parking brake: efficiency below requirements (3.7.B.7)

NSF tyre inner sidewall worn thin

brake pipes showing signs of corrosion

seat belts showing signs of fraying to edges

Nearside Seat belt damaged but not affecting the operation of the belt (5.2.2a)