2005 Ford Transit

Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i))

Nearside Rear Anti-roll bar attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i))

Offside Front Coil spring fractured or broken (5.3.1 (b) (i))

Offside Rear Anti-roll bar attachment bracket/mounting corroded and seriously weakened (5.3.3 (b) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Front Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Front passenger door cannot be opened from outside the vehicle (6.2.3 (a))

Nearside Front Body panel corroded and likely to cause injury (6.2.1 (a) (i))

Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a))

Offside Track rod end ball joint has excessive play (2.1.3 (b) (i))

Offside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

drivers seat worn

Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i))

Nearside Rear Anti-roll bar linkage pin or bush excessively worn (5.3.4 (a) (i))

Nearside Rear Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i))

Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

drivers seat worn

Nearside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Rear Outer Nail in tyre ()

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Play in steering rack inner joint(s) ()

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement both d-bushes (5.3.4 (a) (i))

drivers seat cushion badly deteriorated

underside of vehicle very dirty

Brake pipe excessively corroded both front to rear (1.1.11 (c))

Central Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member (6.1.1 (c) (i))

Exhaust emissions exceed manufacturer's specified limit (8.2.2.2 (a))

Nearside Body component damaged and likely to cause injury mirror backing (6.2.1 (a) (i))

Nearside Front Body component corroded and likely to cause injury wing (6.2.1 (a) (i))

Nearside Front Brake pipe excessively corroded (1.1.11 (c))

Nearside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c))

Offside Front Brake pipe excessively corroded (1.1.11 (c))

Offside Rear Brake pipe excessively corroded (1.1.11 (c))

Offside Rear Position lamp adversely affected by the operation of another lamp (4.2.3 (c))

Offside Rear Position lamp lens seriously defective insecure (4.2.1 (b))

Oil leaking excessively from engine (8.4.1 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c))

Tailgate corroded and likely to cause injury (6.2.1 (a) (i))

Tailgate likely to become detached (6.2.1 (a) (ii)) DANGEROUS

Nearside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Rear Outer Nail in tyre ()

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Play in steering rack inner joint(s) ()

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement both d-bushes (5.3.4 (a) (i))

drivers seat cushion badly deteriorated

underside of vehicle very dirty

Brake pipe corroded, covered in grease or other material all brake pipes are corroded or coved in mud (1.1.11 (c))

Front Brake disc worn, pitted or scored, but not seriously weakened both front disc worn (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Front Play in steering rack inner joint(s) ()

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Front inner step corroded and holed

Nearside inner and outer sills excessively corroded but not within a prescribed area

Offside Front Wheel bearing has slight play (5.1.3 (a) (i))

Offside Front inner step corroded and holed

Offside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside inner and outer sills excessively corroded but not within a prescribed area

Oil leak, but not excessive leaking but not enough to fail (8.4.1 (a) (i))

Prop shaft bearing has slight play both bearing (6.1.7 (b) (i))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement both rear anti roll bar bushes and "D" bushes worn (5.3.4 (a) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

fuel tank hose (vent hose) perished/cracked

Brake pipe corroded, covered in grease or other material all brake pies cover in mud or corroded (1.1.11 (c))

Nearside Front inner and outer sills corroded/holed

Nearside Rear Inner Tyre worn close to legal limit/worn on edge on 2mm (5.2.3 (e))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Front inner and outer sills corroded/holed

Offside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Power steering pump has slight seepage (2.1.5 (a))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement both rear "D" bushes worn (5.3.4 (a) (i))

fuel hose perished and deteriorated (vent hose)

slight under body corrosion

Brake pipe corroded, covered in grease or other material all brake pipes corroded (1.1.11 (c))

Cab or chassis corroded within 30cm of a mounting, but not seriously affecting overall security both rear inner and outer sills corroded and holed (6.2.2 (d) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement arm rear bush (5.3.4 (a) (i))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear arm rear bush (5.3.4 (a) (i))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

fuel tank breather hose deteriorated

Anti-lock braking system warning lamp indicates an ABS fault (1.6 (b))

Offside Rear Direction indicator not working (4.4.1 (a) (ii))

Offside Rear Rear fog lamp not working (4.5.1 (a) (ii))

Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c))

Prop shaft bearing excessively worn (6.1.7 (b) (i))

Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rear cross member (5.3.6 (a) (i))

Nearside Rear Anti-roll bar linkage insecure and impairing directional stability (5.3.3 (a) (ii)) DANGEROUS

Brake pipe corroded, covered in grease or other material all brake pipes corroded (1.1.11 (c))

Cab or chassis corroded within 30cm of a mounting, but not seriously affecting overall security both rear inner and outer sills corroded and holed (6.2.2 (d) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement arm rear bush (5.3.4 (a) (i))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear arm rear bush (5.3.4 (a) (i))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

fuel tank breather hose deteriorated

Brake pipe corroded, covered in grease or other material all brake pipes corroead (1.1.11 (c))

Central Prop shaft bearing has slight play (6.1.7 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

both passenger and driver inner sills corroead

under body corrosion

All direction indicators not working (4.4.1 (a) (ii))

Hazard warning switch inoperative (4.4.2 (a) (ii))

Offside Rear Rear fog lamp not working (4.5.1 (a) (ii))

Offside Rear Stop lamp(s) light intensity significantly reduced (4.3.3 (a) (ii))

Nearside Front Tyre tread pattern not visible over the whole tread area when minimum depth required is 1.0mm (5.2.3 (e)) DANGEROUS

Offside Front Tyre tread pattern not visible over the whole tread area when minimum depth required is 1.0mm (5.2.3 (e)) DANGEROUS

Offside Rear Outer Tyre tread pattern not visible over the whole tread area when minimum depth required is 1.0mm (5.2.3 (e)) DANGEROUS

Brake pipe corroded, covered in grease or other material all brake pipes corroead (1.1.11 (c))

Central Prop shaft bearing has slight play (6.1.7 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

both passenger and driver inner sills corroead

under body corrosion

Nearside Body has slight corrosion outer sill (6.1.B.2)

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

Offside Body has slight corrosion outer sill (6.1.B.2)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Outer Tyre worn close to the legal limit 3mm (4.1.E.1)

Oil leak ()

Power steering fluid level low, but not below minimum (2.3.1)

Vehicle structure has slight corrosion (6.1.B.2)

fuel tank breather hose split but not leaking at time of test

windscreen damaged outside zone A bigger than 40mm but not seriously affecting drivers view of the road

Fuel tank insecure (7.2.1)

Nearside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Nearside rear brake recording little or no effort (3.7.B.5a)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Offside Rear Direction indicator not working (1.4.A.2c)

Offside Rear fog lamp not working (1.3.2b)

Parking brake: efficiency below requirements (3.7.B.7)

Rear Brakes imbalanced across an axle Axle 2 (3.7.B.5b)

rear brake application uneven (3.7.B.2)

Nearside Body has slight corrosion outer sill (6.1.B.2)

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

Offside Body has slight corrosion outer sill (6.1.B.2)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Outer Tyre worn close to the legal limit 3mm (4.1.E.1)

Oil leak ()

Power steering fluid level low, but not below minimum (2.3.1)

Vehicle structure has slight corrosion (6.1.B.2)

fuel tank breather hose split but not leaking at time of test

windscreen damaged outside zone A bigger than 40mm but not seriously affecting drivers view of the road

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Inner Nail in tyre x2 ()

Nearside Rear Inner Tyre worn close to the legal limit 2mm (4.1.E.1)

Nearside Rear Outer Tyre worn close to the legal limit 3mm (4.1.E.1)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Direction indicator slightly discoloured lens broken (1.4.A.2f)

Offside rear brake fluctuating, but not excessively (3.7.B.3)

Oil leak ()

both rear light lens broken

fuel tank breather hose split but not leaking

Nearside Stop lamp not working (1.2.1b)

Parking brake: efficiency below requirements (3.7.B.7)

Power steering fluid level below minimum (2.3.1)

Registration plate lamp not working (1.1.C.1d)

Nearside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Inner Nail in tyre x2 ()

Nearside Rear Inner Tyre worn close to the legal limit 2mm (4.1.E.1)

Nearside Rear Outer Tyre worn close to the legal limit 3mm (4.1.E.1)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Direction indicator slightly discoloured lens broken (1.4.A.2f)

Offside rear brake fluctuating, but not excessively (3.7.B.3)

Oil leak ()

both rear light lens broken

fuel tank breather hose split but not leaking

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside rear brake fluctuating, but not excessively (3.7.B.3)

Offside Front Lower Front suspension ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

brake disc worn, pitted or scored, but not seriously weakened both front (3.5.1i)

fuel tank breather hose split but not leaking

oil leak

Offside Stop lamp not working (1.2.1b)

Parking brake: efficiency below requirements (3.7.B.7)

Nearside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a) DANGEROUS

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside rear brake fluctuating, but not excessively (3.7.B.3)

Offside Front Lower Front suspension ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

brake disc worn, pitted or scored, but not seriously weakened both front (3.5.1i)

fuel tank breather hose split but not leaking

oil leak

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Oil leak

Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Hazard warning lamps inoperative (1.4.B.1b)

Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Rear fog lamp not working (1.3.2b)

Rear fog lamp tell tale not working (1.3.1b)

Nearside Stop lamp not working (1.2.1b) DANGEROUS

Offside Stop lamp not working (1.2.1b) DANGEROUS

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Rear Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Track rod end ball joint has slight play (2.2.B.1f)

Oil leak

Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

unable to open bonnet to check under bonnet components

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

An item not tested (Manual)

Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Headlamp aim too low (1.8)

Offside Front Lower Suspension arm ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2)

Offside Headlamp aim too low (1.8)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

cut in nearside tyre outer wall but not down to cords

Offside Outer Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Offside Outer Rear Tyre worn close to the legal limit (4.1.E.1)