2003 Volvo S40

Headlamps set to lowest position on test

Nearside Rear reflector defective or damaged by up to 50% of the reflecting surface (4.8.1 (a) (i))

Offside Front Tyre worn close to legal limit/worn on edge Bald on inner edge (5.2.3 (e))

Offside Rear Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Nearside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Offside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Towbar attachment insecure Tow bar is mounted/bolted to spare wheel well, not correct mounting points (6.1.6 (c) (i))

Headlamps set to lowest position on test

Nearside Front Tyre obviously under inflated (5.2.3 (l))

Nearside Rear reflector defective or damaged by up to 50% of the reflecting surface (4.8.1 (a) (i))

Offside Front Tyre worn close to legal limit/worn on edge Bald on inner edge (5.2.3 (e))

Offside Rear Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Lower Suspension arm pin or bush worn but not resulting in excessive movement outer bush (5.3.4 (a) (i))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

fuel cap seal perished

little reserve travel on handbrake

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Lower Suspension arm pin or bush worn but not resulting in excessive movement outer bush (5.3.4 (a) (i))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

fuel cap seal perished

little reserve travel on handbrake

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Central Rear Suspension rod pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Lower Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Nearside Front Suspension rod pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Rear Brake disc worn, but not excessively both sides (1.1.14 (a) (i))

Rear both sides brake back plates corroded

fuel cap sealing washer poor

hand brake travel

slight rust various areas underside vehicle

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement all arms (5.3.4 (a) (i))

exhaust system corroded

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Supplementary restraint system warning lamp indicates a fault (7.1.6 (a))

Offside Rear Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Offside Rear Position lamp with a multiple light source up to 1/2 not functioning (4.2.1 (a) (i))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement all arms (5.3.4 (a) (i))

exhaust system corroded

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Oil leak, but not excessive (8.4.1 (a) (i))

Suspension arm pin or bush worn but not resulting in excessive movement all rear arm bushes (5.3.4 (a) (i))

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Nearside Rear Hydraulic brake calliper leaking (1.1.16 (b) (i))

Nearside Rear Service brake excessively binding (1.2.1 (f))

Offside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Oil leak, but not excessive (8.4.1 (a) (i))

Suspension arm pin or bush worn but not resulting in excessive movement all rear arm bushes (5.3.4 (a) (i))

Nearside Rear Upper Suspension arm pin or bush worn but not resulting in excessive movement lateral arm inner bush (5.3.4 (a) (i))

Offside Rear Upper Suspension arm pin or bush worn but not resulting in excessive movement lateral arm inner bush (5.3.4 (a) (i))

Nearside Front Upper Macpherson strut pin or bush excessively worn strut top mount (5.3.4 (a) (i))

Offside Front Upper Macpherson strut pin or bush excessively worn strut top mount (5.3.4 (a) (i))

Nearside Rear Upper Suspension arm pin or bush worn but not resulting in excessive movement lateral arm inner bush (5.3.4 (a) (i))

Offside Rear Upper Suspension arm pin or bush worn but not resulting in excessive movement lateral arm inner bush (5.3.4 (a) (i))

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Rear Tyre worn close to the legal limit 3mm (4.1.E.1)

Offside Front Anti-roll bar has slight play in a ball joint (2.4.G.2)

Offside Front Tyre worn close to the legal limit 3mm (4.1.E.1)

Offside Rear Tyre worn close to the legal limit 3mm (4.1.E.1)

Offside Wiper starting to smear the screen

Parking brake lever has little reserve travel (3.1.6b)

nearside mirror missing

Battery insecure (1.9.1)

Nearside Front Brake hose excessively deteriorated (3.6.B.4d)

Offside Front Brake hose excessively deteriorated (3.6.B.4d)

Parking brake lever has little reserve travel (3.1.6b)

nearside mirror missing

Nearside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Rear position lamp(s) has light sources not illuminating, but not more than 50% (1.1.A.3b)

Offside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak

Under-trays fitted obscuring some underside components

exhaust system light corrosion

Nail in nearside rear tyre

Centre Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

Oil leak

front brake discs pads slight wear

nearside front wiper blade torn

offside front fog lamp detached

Centre Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

nearside rear tyre perished & offside rear tyre badly stepped on inner tread

Nearside Rear Rear position lamp(s) excessively deteriorated so that it is not visible from a reasonable distance (1.1.A.3d)

Offside Rear position lamp(s) excessively deteriorated so that it is not visible from a reasonable distance (1.1.A.3d)

Rear Brake pad(s) wearing thin (3.5.1g)

Offside Windscreen wiper blade deteriorated (8.2.2)