2004 Ford Transit

Front Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

General corrosion under vehicle

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Reverse lamps not working - (pre 2009)

Tipper body / bed heavily corroded

Nearside Front Headlamp aim too low (4.1.2 (a))

Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Nearside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a))

Nearside Rear Seat belt not functioning as intended (7.1.2 (c))

Offside Front Body panel corroded and likely to cause injury Wing / wheel arch corroded leaving sharp edges (6.2.1 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Brake pedal wearing smooth (1.1.2 (c))

Central Exhaust mounting defective Clamploose / slight leak from joint (6.1.2 (a))

Front Bumper mountings corroded but not likely to become detached (6.1.4 (a) (i))

Front Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

General corrosion under vehicle

Nearside Front Floor / step corroded - non structural

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Rear Lower Anti-roll bar ball joint has slight play Fixing is loose (5.3.4 (a) (i))

Nearside Rear c pillar corroded / holed at base

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement Lower arm , rear bush deteriorated (5.3.4 (a) (i))

Offside Rear Body component slightly loose Wheel arch poorly supported (6.2.1 (a) (i))

Offside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Play in steering rack inner joint(s) ()

Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Play in stabiliser 'd' bushes (5.3.4 (a) (i))

Reverse lamps not working - (pre 2009)

Tipper body / bed heavily corroded

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Front Bumper mountings corroded but not likely to become detached (6.1.4 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Play in steering rack inner joint(s) ()

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

\tipper support member corroded but secure

non structural corrosion at near side front wheel arch

Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f))

Headlamp levelling device inoperative (4.1.5 (a))

Nearside Front Headlamp aim too low (4.1.2 (a))

Nearside Front Position lamp not working (4.2.1 (a) (ii))

Nearside Rear Position lamp not working (4.2.1 (a) (ii))

Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Rear Position lamp not working (4.2.1 (a) (ii))

Rear Prop shaft bearing excessively worn (6.1.7 (b) (i))

Nearside Rear Body component likely to become detached Mud flap mountings corroded & loose (6.2.1 (a) (ii)) DANGEROUS

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Central Exhaust has a minor leak of exhaust gases Exhaust clamp loose & slight leak (6.1.2 (a))

Corrosion at near side front wheel arch - non structural

Front Bumper mountings corroded but not likely to become detached (6.1.4 (a) (i))

Front Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Play in steering rack inner joint(s) ()

Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Tipper body heavily corroded & holed

Exhaust has a minor leak of exhaust gases Front to centre silencer joint has slight leak of gases (6.1.2 (a))

Nearside Front Brake pipe corroded, covered in grease or other material Covered in under seal (1.1.11 (c))

Nearside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement lower fixings not fully tightened (5.3.4 (a) (i))

Offside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Rear stabiliser d bushes have slight play (5.3.4 (a) (i))

Rear prop shaft mounting deteriorated

Tipper body / attachments in poor condition / corroded

Exhaust has a minor leak of exhaust gases Front to centre silencer joint has slight leak of gases (6.1.2 (a))

Nearside Front Brake pipe corroded, covered in grease or other material Covered in under seal (1.1.11 (c))

Nearside Front Headlamp aim too low (4.1.2 (a))

Nearside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement lower fixings not fully tightened (5.3.4 (a) (i))

Offside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Rear stabiliser d bushes have slight play (5.3.4 (a) (i))

Rear prop shaft mounting deteriorated

Tipper body / attachments in poor condition / corroded

Brake pipe excessively corroded Front to rear brake pipes corroded at rear flexis (1.1.11 (c))

Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt Both lower ball joint dust covers no longer prevent the ingress of dirt (5.3.4 (b) (ii))

Nearside Front Brake pipe excessively corroded Brake pipe to near side front flexi corroded (1.1.11 (c))

Nearside Front Headlamp aim too low (4.1.2 (a))

Nearside Front Headlamp levelling device inoperative (4.1.5 (a))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength corrosion within 30cm of suspension mounting (5.3.6 (a) (i))

Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis member corroded at inner wheel arch (6.1.1 (c) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Corrosion within 30cm of suspension mounting (5.3.6 (a) (i))

Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Lower fixing not fully tightened (5.3.4 (a) (i))

Front Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Inner and outer sills corroded and holed (o/s & n/s)

Nearside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Outer Tyre worn close to legal limit/worn on edge Tyre worn close to limit (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Slight movement in stabiliser mounting bushes (5.3.4 (a) (i))

Rear tipper body and structure corroded and weak

Brake pipe corroded, covered in grease or other material both front to rears Corroded (1.1.11 (c))

Nearside Dropside slightly loose (6.2.1 (a) (i))

Nearside Front Brake pipe corroded, covered in grease or other material Corroded (1.1.11 (c))

Offside Dropside slightly loose (6.2.1 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Tailgate slightly loose (6.2.1 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

body dropside and tail gate moutings Corroded and holed

both rear wings moutings weak Corroded

Offside Rear Anti-roll bar linkage damaged and seriously weakened (5.3.3 (b) (i))

Brake pipe corroded, covered in grease or other material both front to rears Corroded (1.1.11 (c))

Nearside Dropside slightly loose (6.2.1 (a) (i))

Nearside Front Brake pipe corroded, covered in grease or other material Corroded (1.1.11 (c))

Offside Dropside slightly loose (6.2.1 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Tailgate slightly loose (6.2.1 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

body dropside and tail gate moutings Corroded and holed

both rear wings moutings weak Corroded

Nearside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Rear hand brake cable fouling tyre . tyre and cable damaged.

Offside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Prop shaft bearing has slight play (6.1.7 (b) (i))

Rear body holed

water leak

Exhaust has a major leak of exhaust gases (6.1.2 (a))

Offside Rear Brake pipe excessively corroded (1.1.11 (c))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Rear hand brake cable fouling tyre . tyre and cable damaged.

Offside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Prop shaft bearing has slight play (6.1.7 (b) (i))

Rear body holed

water leak

All position lamps not working (4.2.1 (a))

Central Rear Seat belt insecurely fixed to the vehicles structure (5.2.1a)

Nearside Rear Seat belt insecurely fixed to the vehicles structure (5.2.1a)

Offside Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Rear Seat belt insecurely fixed to the vehicles structure (5.2.1a)

Offside Stop lamp not working (1.2.1b)

Offside Rear spring leaf twisted

Rear Passenger seat(s) missing at time of test ()

Horn not working (1.6.2a)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Rear Passenger seat(s) missing at time of test ()

Centre Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

offside front sill is corroded thow

Centre Rear Seat belt damaged sufficient to obstruct correct operation of the belt (5.2.2a)

Centre Rear Seat belt insecurely fixed to the vehicles structure (5.2.1a)

Horn not working (1.6.2a)

Nearside Front Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside Front Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside Headlamp aim too low (1.8)

Nearside Headlamp not working on main beam (1.7.5a)

Nearside Rear Seat belt insecurely fixed to the vehicles structure (5.2.1a)

Nearside Rear Seat belt insecurely fixed to the vehicles structure (5.2.1a)

Nearside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside Steering rack gaiter split (2.2.D.2d)

Offside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Track rod end ball joint has excessive play (2.2.B.1f)

Offside Headlamp not working on main beam (1.7.5a)

Offside Rear Seat belt insecurely fixed to the vehicles structure (5.2.1a)

Offside Rear Seat belt insecurely fixed to the vehicles structure (5.2.1a)

Offside Rear fog lamp not working (1.3.2b)

Offside Stop lamp not working (1.2.1b)

Rear Passenger's seat insecure (6.2.A.1)

Centre Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Coolant leak

Front bumper insecure

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Inner Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Seat belt damaged but webbing not significantly weakened (5.2.2a)

offside fdront sill is corroded thow

Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

front brakes fluctuate slightly

Nearside Front Lower Front suspension has slight movement at a wishbone pin or bush (2.5.A.1c)

Offside Front Lower Front suspension has slight movement at a wishbone pin or bush (2.5.A.1c)

Nearside Inner Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Nearside Outer Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Offside Inner Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Rear Brakes imbalanced across an axle (3.7.B.5b)

Nearside Front Lower Front suspension has slight movement at a wishbone pin or bush (2.5.A.1c)

Offside Front Lower Front suspension has slight movement at a wishbone pin or bush (2.5.A.1c)

Power steering fluid level low, but not below minimum (2.3.1)

offside rear side marker lamp not working

rear differential bearings noisey

Brakes imbalanced across an axle (3.7.B.5b)

Front Windscreen washer provides insufficient washer liquid (8.2.3)

Nearside Rear rear parking brake recording little or no effort (3.7.B.6a)

Offside Rear Anti-roll bar linkage has excessive play in a pin/bush (2.4.G.2)

Offside Rear position lamp(s) not working (1.1.A.3b)

Offside rear parking (secondary) brake grabbing severely (3.7.B.6b)

Parking brake: efficiency below requirements (3.7.B.7)

Rear Shock absorber casing damaged externally so the unit does not function (2.7.2a)

Windscreen has damage to the swept area in excess of a 40mm circle outside zone 'A' (8.3.1d)

rear parking (secondary) brakes imbalanced (3.7.B.6b)

Rear Brake pipe slightly corroded (3.6.B.2c)

coolant low

rear differential bearings noisey

screenwash bottle insecure

Nearside Front Lower Front suspension has slight movement at a wishbone pin or bush (2.5.A.1c)

rear differential noisey

Nearside Front Headlamp aim too high (1.8)

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Rear fog lamp not working (1.3.2b)

Parking brake: efficiency below requirements (3.7.B.7)

Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Rear Lower Anti-roll bar linkage has excessive play in a pin/bush (2.4.G.2)

Nearside Front Lower Front suspension has slight movement at a wishbone pin or bush (2.5.A.1c)

Rear wheel bearing has slight play (2.6.2)

nail in nearside rear inner tyre

offside rear hub oil seal leaking slightly

rear differential noisey

Front Brake pad(s) wearing thin (3.5.1g)

Rear Anti-roll bar has slight play in a pin/bush (2.4.G.2)

Rear wheel bearing has slight play (2.6.2)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

front brake discs worn

Offside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

front brake discs getting worn

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Front registration plate missing (6.3.1a)

Horn not working (1.6.2a)

Nearside Side repeater not working (1.4.A.2c)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Parking brake: efficiency below requirements (3.7.B.7)

Registration plate lamp not working (1.1.5c)

Track rod end loose (2.2.B.1d)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

o/s rear marker cover missing

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Outer Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)