2005 Volvo S40

Front Inner Brake disc worn, pitted or scored, but not seriously weakened both inner (1.1.14 (a) (ii))

Front Service brake binding but not excessively both front (1.2.1 (f))

Rear Shock absorbers has light misting of oil both rear (5.3.2 (b))

Front Inner Brake disc worn, pitted or scored, but not seriously weakened both inner (1.1.14 (a) (ii))

Front Service brake binding but not excessively both front (1.2.1 (f))

Nearside Front Position lamp not working (4.2.1 (a) (ii))

Rear Shock absorbers has light misting of oil both rear (5.3.2 (b))

Front Brake disc worn, pitted or scored, but not seriously weakened inner surfaces (1.1.14 (a) (ii))

Nearside Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Front Tyre has ply or cords exposed 205/50/17 (5.2.3 (d) (ii)) DANGEROUS

Front Brake disc worn, pitted or scored, but not seriously weakened inner surfaces (1.1.14 (a) (ii))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Nearside Front Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Nearside Rear Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Offside Front Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Nearside Front Coil spring fractured or broken (5.3.1 (b) (i))

Nearside Front Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Nearside Rear Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Offside Front Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

offside front and nearside rear tyres worn on inner edges

Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Rear Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Offside Rear Coil spring corroded (5.3.1 (b) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

offside front and nearside rear tyres worn on inner edges

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Nearside Front Lower Suspension arm rubber mounting deteriorated but not resulting in excessive movement rear most mounting bush (2.4.G.2)

Nearside Front Tyre worn close to the legal limit wearing on the inner tread section more (4.1.E.1)

Offside Front Lower Suspension arm rubber mounting deteriorated but not resulting in excessive movement rear most mounting bush (2.4.G.2)

Offside Front Tyre worn close to the legal limit wearing on the inner tread section more (4.1.E.1)

Offside Rear Tyre worn close to the legal limit wearing on the inner tread section more (4.1.E.1)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

rear exhaust system support detached but exhaust system at the time of test still adequately supported

Child seat fitted not allowing full inspection of adult belt

Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush both sides (2.4.G.2)

Front brake pads getting low

Nearside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Oil leak

Rear Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement both arms both sides (2.4.G.2)

Slight play in steering rack inner joints

Vehicle has engine covers and under-trays fitted making it difficult to inspect

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Headlamp excessively deteriorated so that the light output is severely reduced (1.7.5a)

Offside Headlamp aim too low (1.8)

Offside Rear Mechanical brake component has restricted free movement (3.5.1k)

Brake hydraulic reservoir fluid close to minimum level (3.6.G.1b)

Child seat fitted not allowing full inspection of adult belt

Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush both sides (2.4.G.2)

Front brake pads getting low

Nearside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Oil leak

Rear Brake pad(s) wearing thin (3.5.1g)

Rear Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement both arms both sides (2.4.G.2)

Slight play in steering rack inner joints

Vehicle has engine covers and under-trays fitted making it difficult to inspect

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Engine covers fitted obscuring some components in the engine bay

Front Anti-roll bar corroded but not seriously weakened (2.4.G.1)

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak

Rear Anti-roll bar corroded but not seriously weakened (2.4.G.1)

Under-trays fitted obscuring some underside components

Nearside Windscreen washer provides insufficient washer liquid (8.2.3)

Offside Front wheel bearing rough when rotated (2.5.A.2)

Offside Windscreen washer provides insufficient washer liquid (8.2.3)

Engine covers fitted obscuring some components in the engine bay

Front Anti-roll bar corroded but not seriously weakened (2.4.G.1)

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak

Rear Anti-roll bar corroded but not seriously weakened (2.4.G.1)

Under-trays fitted obscuring some underside components

Engine covers fitted obscuring some components in the engine bay

Front Anti-roll bar corroded but not seriously weakened (2.4.G.1)

Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Headlamp washers not working at time of test but vehicle not fitted with HID or xenon headlamps

Nearside Front Macpherson strut has slight movement in the upper support bearing assembly (2.5.B.1b)

Nearside Front coil spring corroded (2.4.C.1b)

Nearside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Nearside Rear Seat belt damaged but webbing not significantly weakened (5.2.2a)

Play in steering rack inner joint(s)

Rear Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear Trailing arm has slight play in a pin/bush (2.4.G.2)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Under-trays fitted obscuring some underside components

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Headlamp aim too low (1.8)

Offside Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Nearside Rear Tyre has ply or cords exposed (4.1.D.1b) DANGEROUS

Engine covers fitted obscuring some components in the engine bay

Front Anti-roll bar corroded but not seriously weakened (2.4.G.1)

Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Headlamp washers not working at time of test but vehicle not fitted with HID or xenon headlamps

Nearside Front Macpherson strut has slight movement in the upper support bearing assembly (2.5.B.1b)

Nearside Front coil spring corroded (2.4.C.1b)

Nearside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Nearside Rear Seat belt damaged but webbing not significantly weakened (5.2.2a)

Oil leak

Play in steering rack inner joint(s)

Rear Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear Trailing arm has slight play in a pin/bush (2.4.G.2)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Under-trays fitted obscuring some underside components

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Both rear tyres are worn slightly on inner edges

Engine covers fitted obscuring some components in the engine bay

Fuel cap damaged but maintains a seal

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Offside Front Lower Suspension arm has slight play in a pin/bush (2.4.G.2)

Offside front tyre is worn slightly on inner edge

Oil leak

Rear Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear brake discs slightly worn

Under-trays fitted obscuring some underside components

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Nearside Headlamp excessively deteriorated so that the light output is severely reduced (1.7.5a)

Offside Headlamp aim too low (1.8)

Both rear tyres are worn slightly on inner edges

Engine covers fitted obscuring some components in the engine bay

Fuel cap damaged but maintains a seal

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Offside Front Lower Suspension arm has slight play in a pin/bush (2.4.G.2)

Offside front tyre is worn slightly on inner edge

Oil leak

Rear Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear brake discs slightly worn

Under-trays fitted obscuring some underside components

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Both front tyres are worn on inner edges and nearside also on 3mm of tread

Engine covers fitted obscuring some components in the engine bay

Front Anti-roll bar corroded but not seriously weakened (2.4.G.1)

Front exhaust flange corroded

Front wipers are starting to smear

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Offside Front Lower Suspension arm has slight play in a pin/bush (2.4.G.2)

Offside Front wheel bearing has slight play (2.5.A.3c)

Oil leak

Parking brake lever has little reserve travel (3.1.6b)

Rear Trailing arm has slight play in a pin/bush (2.4.G.2)

Rear brake discs slightly worn

Under-trays fitted obscuring some underside components

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Offside Front wheel bearing rough when rotated (2.5.A.2)

Rear coil spring cracked (2.4.C.1a)

Both front tyres are worn on inner edges and nearside also on 3mm of tread

Engine covers fitted obscuring some components in the engine bay

Front Anti-roll bar corroded but not seriously weakened (2.4.G.1)

Front exhaust flange corroded

Front wipers are starting to smear

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Offside Front Lower Suspension arm has slight play in a pin/bush (2.4.G.2)

Offside Front wheel bearing has slight play (2.5.A.3c)

Offside Headlamp not working on dipped beam (1.7.5a)

Oil leak

Parking brake lever has little reserve travel (3.1.6b)

Rear Trailing arm has slight play in a pin/bush (2.4.G.2)

Rear brake discs slightly worn

Under-trays fitted obscuring some underside components

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Front brake discs slightly scored

Nearside Front Suspension arm has slight play in a pin/bush (2.4.G.2)

Offside Front Suspension arm has slight play in a pin/bush (2.4.G.2)

front tyres wearing on inner edges

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Front coil spring fractured (2.4.C.1a)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)