2004 Volvo S40

Brake pedal anti-slip provision worn smooth (1.1.2 (c))

Front Emissions not tested DUE TO RADIATOR LEAKING WATER OVER HEATING (8.2.1.2 (d))

Front Supplementary restraint system warning lamp indicates a fault (7.1.6 (a))

Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a))

Nearside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Nearside Front Outer Outline marker lamp not working (4.2.1 (a) (ii))

Nearside Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords IN TREAD (5.2.3 (d) (i))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Rear Hydraulic brake cylinder leaking hydraulic fluid BRAKE CALIPER (1.1.16 (b) (i))

Offside Rear Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Brake hydraulic reservoir close to minimum mark (1.1.10 (d) (i))

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened WORN (1.1.14 (a) (ii))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened WORN (1.1.14 (a) (ii))

Offside Front Seat belt webbing slightly damaged or frayed SLIGHTLY FRAYED (7.1.2 (b) (ii))

Brake pedal wearing smooth rubber (1.1.2 (c))

Brake pipe corroded, covered in grease or other material front to back starting to corrode by the brackets holding them to the body (1.1.11 (c))

Nearside Front Brake disc worn, but not excessively (1.1.14 (a) (i))

Nearside Front Seat belt webbing slightly damaged or frayed fraying (7.1.2 (b) (ii))

Nearside Rear Outer Tyre slightly damaged/cracking or perishing wall starting to show signs of cracking (5.2.3 (d) (ii))

Nearside Rear Outer Tyre worn close to legal limit/worn on edge edge (5.2.3 (e))

Offside Front Brake disc worn, but not excessively (1.1.14 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed fraying (7.1.2 (b) (ii))

Rear Exhaust has a minor leak of exhaust gases back box to centre box joining (6.1.2 (a))

coolant header tank in completely empty

engine is excessively noisy

Brake fluid contaminated (1.8 (a))

Nearside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Side repeater incorrect colour (4.4.3 (a))

Nearside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Rear Position lamp not working (4.2.1 (a) (ii))

Offside Front Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Rear Position lamp not working (4.2.1 (a) (ii))

Offside Rear Registration plate lamp does not illuminate simultaneously with the position lamps (4.7.2 (a))

Offside Rear Side repeater incorrect colour (4.4.3 (a))

Brake pedal wearing smooth rubber (1.1.2 (c))

Brake pipe corroded, covered in grease or other material front to back starting to corrode by the brackets holding them to the body (1.1.11 (c))

Nearside Front Brake disc worn, but not excessively (1.1.14 (a) (i))

Nearside Front Seat belt webbing slightly damaged or frayed fraying (7.1.2 (b) (ii))

Nearside Rear Outer Tyre slightly damaged/cracking or perishing wall starting to show signs of cracking (5.2.3 (d) (ii))

Nearside Rear Outer Tyre worn close to legal limit/worn on edge edge (5.2.3 (e))

Offside Front Brake disc worn, but not excessively (1.1.14 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed fraying (7.1.2 (b) (ii))

Rear Exhaust has a minor leak of exhaust gases back box to centre box joining (6.1.2 (a))

coolant header tank in completely empty

engine is excessively noisy

Brake pedal wearing smooth RUBBER (1.1.2 (c))

Lower UNDER TRAYS FITTED

Nearside Front Lower Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed FRAYED (7.1.2 (b) (ii))

Offside Rear Direction indicator slightly discoloured (4.4.3 (a))

Bonnet cannot be secured in the closed position (3.1 (b) (i))

Front Registration plate inscription illegible (0.1 (b))

Nearside Front Headlamp aim too high (4.1.2 (a))

Offside Front Headlamp aim too high (4.1.2 (a))

Offside Front Upper Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i))

Brake pedal wearing smooth RUBBER (1.1.2 (c))

Lower UNDER TRAYS FITTED

Nearside Front Lower Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed FRAYED (7.1.2 (b) (ii))

Offside Rear Direction indicator slightly discoloured (4.4.3 (a))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Brake pedal wearing smooth (1.1.2 (c))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Nearside Front Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Nearside Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Rear Coil spring corroded Slight Corrosion (5.3.1 (b) (i))

Note - Unusual noise from engine bay - RECOMMEND ATTENTION

Offside Front Brake pad(s) wearing thin RECOMMEND ATTENTION (1.1.13 (a) (ii))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Undertrays fitted

Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Supplementary restraint system warning lamp indicates a fault Black Tape covering warning lamp (7.1.6 (a))

Brake pedal wearing smooth (1.1.2 (c))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Nearside Front Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Nearside Headlamp aim projected beam image is obviously incorrect BULB INCORRECTLY FITTED (4.1.2 (c))

Nearside Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Rear Coil spring corroded Slight Corrosion (5.3.1 (b) (i))

Note - Unusual noise from engine bay - RECOMMEND ATTENTION

Offside Front Brake pad(s) wearing thin RECOMMEND ATTENTION (1.1.13 (a) (ii))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Undertrays fitted

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Offside Rear position lamp(s) has light sources not illuminating, but not more than 50% one bulb not working (1.1.A.3b)

drivers door mirror housing damaged

o/s front and n/s rear side marker lights not working

Headlamp not working on main beam both (1.7.5a)

Main beam 'tell-tale' not working (1.7.4c)

Nearside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement bush and washer displaced (2.4.G.2)

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Offside Rear position lamp(s) has light sources not illuminating, but not more than 50% one bulb not working (1.1.A.3b)

drivers door mirror housing damaged

o/s front and n/s rear side marker lights not working

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

brake pedal anti slip pad is worn [rubber]

indicator switch faulty [weak operation]on o/s

Exhaust emissions Lambda reading after 2nd fast idle outside specified limits (7.3.D.3)

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Offside Rear Registration plate lamp not working (1.1.C.1d)

Rear Exhaust has a major leak of exhaust gases silencer corroded/holed (7.1.2)

Central rear exhaust flange heavily corroded

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

brake pedal anti slip pad is worn [rubber]

indicator switch faulty [weak operation]on o/s

Nearside Front Anti-roll bar linkage ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Nearside engine is noisey

Offside Front Front position lamp(s) has light sources not illuminating, but not more than 50% (1.1.A.3b)

Offside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Offside Front bumper damaged

Offside Rear Tyre worn close to the legal limit 2mm (4.1.E.1)

bonnet does not lock down fully

Nearside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Rear Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Front Steering rack gaiter split (2.2.D.2d)

Offside Headlamp aim too high main beam (1.8)

Offside Registration plate lamp not illuminating the registration plate (1.1.C.1e)

Nearside Front Anti-roll bar linkage ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Nearside engine is noisey

Offside Front Front position lamp(s) has light sources not illuminating, but not more than 50% (1.1.A.3b)

Offside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Offside Front bumper damaged

Offside Rear Brake pad(s) wearing thin (3.5.1g)

Offside Rear Tyre worn close to the legal limit 2mm (4.1.E.1)

bonnet does not lock down fully

Brake hydraulic reservoir fluid close to minimum level (3.6.G.1b)

n/s front tyre worn/scrubbed

o/s front tyre worn/scrubbed

o/s of front bumper acci damaged

o/s rear tyre worn tread

o/s reg plate light dull

rear reg plate has one screw loose

Offside Rear Direction indicator slightly discoloured (1.4.A.2f)

o/s of front bumper damaged / holed

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Nearside Front Direction indicator incorrect colour (1.4.A.2f)

Offside Rear Shock absorber has a serious fluid leak (2.7.3)

Offside Registration plate lamp not working (1.1.C.1d)

Offside Rear Direction indicator slightly discoloured (1.4.A.2f)

bonnet not locking down

o/s of front bumper damaged / holed

one o/s rear side light bulb not working

Offside Front Direction indicator slightly discoloured (1.4.A.2f)

Offside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Offside Front Tie bar/rod rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

clutch and brake pedal ribbers worn

front bumper damaged

Exhaust emissions Lambda reading after 2nd fast idle outside specified limits (7.3.D.3)

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Exhaust emissions carbon monoxide content at idle excessive (7.3.D.4)

Nearside Rear Brake pipe excessively corroded (3.6.B.2c)

Nearside Rear Direction indicator incorrect colour (1.4.A.2f)

Offside Rear Brake pipe excessively corroded (3.6.B.2c)

Offside Side repeater incorrect colour (1.4.A.2f)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Offside Front coil spring fractured (2.4.C.1a) DANGEROUS

Offside Front Direction indicator slightly discoloured (1.4.A.2f)

Offside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Offside Rear Tie bar/rod rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

clutch and brake pedal rubbers worn

front bumper damaged/holed

n/s rear tyre wall damaged

one o/s rear and one n/s rear side light bulb not working

plastic panels loose under o/s front of car

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Headlamp aim beam image obviously incorrect (1.8.A.1b)

Nearside Rear Rear position lamp(s) not working (1.1.A.3b)

Offside Front Body has a sharp edge caused by corrosion (6.1.C.1)

Offside Front Body has a sharp edge caused by damage (6.1.C.1)

Offside Front Headlamp aim too low (1.8)

Nearside Front Brake hose excessively deteriorated (3.6.B.4d) DANGEROUS

Offside Front Brake hose excessively deteriorated (3.6.B.4d) DANGEROUS

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

cuts in outer wall of N/S/R tyre not showing cords

Nearside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Rear Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Registration plate lamp not illuminating the registration plate (1.1.C.1e)

Offside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Rear Direction indicator slightly discoloured (1.4.A.2f)

Nearside Rear brake disc slightly scored (3.5.1h)

Offside Front Seat belt damaged but not affecting the operation of the belt (5.2.2a)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Rear Brake pad(s) wearing thin (3.5.1g)

n/s door mirror cracked

o/s and n/s rear tyre walls cracking on inner and outer walls

rear no plate screw loose

Nearside Registration plate lamp not working (1.1.5c)

Offside Rear Direction indicators incorrect colour (1.4.A.2f)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Rear brake disc slightly scored (3.5.1h)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Rear brake disc slightly scored (3.5.1h)

n/s door mirror cracked

n/s rear tyre wall damaged

rear tyres inner walls cracking

Nearside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

n/s door mirror cracked

n/s front tyre side wall and wheel damaged

nail in n/s rear tyre