2006 Citroen Relay

Nearside Front Front passenger door cannot be opened from inside the vehicle (6.2.3 (a))

Nearside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i))

Nearside Front Lower Suspension arm ball joint excessively worn bottom ball joint (5.3.4 (a) (i))

Nearside Rear Inner Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i))

Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength chassis leg above rear spring (5.3.6 (a) (i))

Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced inner arch at rear of arch (7.1.1 (a) (i))

Offside Rear Inner Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i))

Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength rear of spring hanger (5.3.6 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Front Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Vehicle structure is corroded but structural rigidity is not significantly reduced centre inner sill (6.1.1 (c) (i))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Vehicle structure is corroded but structural rigidity is not significantly reduced centre inner sill (6.1.1 (c) (i))

both front strut top mtgs noisy

gear change stiff / difficult selection

Front Windscreen wiper does not clear the windscreen effectively both torn (3.4 (b) (ii))

Nearside Front Service brake excessively binding knocked off (1.2.1 (f))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Parking brake inoperative on one side n/n 312kgf. o/s 172kgf.. ( o/s 50% of n /s ).. n/s.r park brake scoring noises (1.4.1 (a))

Service brake efficiency below requirements (1.2.2 (a) (i))

Nearside Front Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Items removed from driver's view prior to test sat nav ()

Offside Front Service brake binding but not excessively (1.2.1 (f))

both front strut top mtgs noisy

gear change stiff / difficult selection

Intercooler support brackets broken,

Nearside Rear Leaf spring has slight wear in an anchor pin and/or bush Front bush (5.3.4 (a) (i))

Power steering pipe/hose slightly corroded Pipes on rack corroded (2.1.5 (g) (i))

Radiator support/front cross member corroded and holed.

Rear Leaf spring anchor bracket corroded but not seriously weakened All four brackets corroded (5.3.1 (b) (i))

Nearside Front Lower Suspension arm pin or bush excessively worn Both front and rear bushes (5.3.4 (a) (i))

Nearside Front Shock absorbers has a serious fluid leak (5.3.2 (b))

Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Intercooler support brackets broken,

Nearside Rear Leaf spring has slight wear in an anchor pin and/or bush Front bush (5.3.4 (a) (i))

Power steering pipe/hose slightly corroded Pipes on rack corroded (2.1.5 (g) (i))

Radiator support/front cross member corroded and holed.

Rear Leaf spring anchor bracket corroded but not seriously weakened All four brackets corroded (5.3.1 (b) (i))

Front Lower radiator support panel corroded/holed

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear (2.4.G.2)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Front Windscreen wiper does not clear the windscreen effectively both deteriorated (8.2.2)

Nearside Front Direction indicator incorrect colour (1.4.A.2f)

Nearside rear brake excessively fluctuating park.. 130/195 (3.7.B.3)

Nearside rear parking (secondary) brake grabbing severely (3.7.B.6b)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Offside Front Direction indicator incorrect colour (1.4.A.2f)

Offside Obligatory mirror seriously damaged, affecting the rear view multi cracks now extended over whole view area (8.1.2a)

Offside rear brake excessively fluctuating (3.7.B.3)

Offside rear parking (secondary) brake grabbing severely (3.7.B.6b)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Front Lower radiator support panel corroded/holed

Front brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

Front brakes binding one place... discs corrosion

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear (2.4.G.2)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Parking brake lever is fouling adjacent parts of the vehicle fouling door trim.. reshape on mounting (3.1.6b)

Rear brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

Power steering pipe(s) or hose(s) slightly corroded (2.3.2)

Nearside Headlamp aim too high and too far to the right. (1.8)

Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement (2.4.B.2)

Offside Headlamp aim too high (1.8)

Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement (2.4.B.2)

Offside Rear Tyre has a bulge, caused by separation or partial failure of its structure (4.1.D.1b) DANGEROUS

Power steering pipe(s) or hose(s) slightly corroded (2.3.2)

Offside Front Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Oil leak

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

both rear bump stop rubbers damaged

front discs worn and pitted

slight binding of n/s/r and n/s/f wheels

Nearside Body has a sharp edge caused by damage (6.1.C.1)

Nearside Front Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Nearside Rear Stop lamp obviously incorrectly positioned (1.2.1a)

Offside Front Front wheel bearing rough when rotated (2.5.A.2)

Offside Rear Rear position lamp(s) not working (1.1.A.3b)

Offside Front Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Oil leak

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

both rear bump stop rubbers damaged

front discs worn and pitted

slight binding of n/s/r and n/s/f wheels

Offside Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Parking brake: efficiency below requirements (3.7.B.7)

Nearside Headlamp not working on dipped beam (1.7.5a)

Offside Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Suspension arm has slight play in a pin/bush (2.4.G.2)

damage to n/s sliding door edges of door sticking out wards

Nearside Front position lamp(s) not working (1.1.A.3b)

Nearside Registration plate lamp not working (1.1.C.1d)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Front Brake pad(s) wearing thin (3.5.1g)

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Nearside Front Suspension arm has slight play in a pin/bush (2.4.G.2)

damage to n/s sliding door edges of door sticking out wards

Offside Front Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Nearside Front Shock absorber has a serious fluid leak (2.7.3)

Nearside Rear Direction indicator adversely affected by the operation of another lamp (1.4.A.2h)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Front Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)