2004 Ford Transit

Nearside Rear Inner tyre very low in pressure

Nearside Rear handbrake cable fouling on tyre

corrosion in brake pipes (limited vision on exact condition )

crack in nearside of windscreen not significantly affects the driver’s view of the road

excessive corrosion at nearside front inner wing away from prescribed areas

rear brake efforts erratic ?

underside very muddy ,especially front suspension etc ,will need to be cleaned to carry out a full retest examination

Horn not working (7.7 (a) (ii))

Nearside Front Outline marker lamp not working (4.2.1 (a) (ii))

Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i))

Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch/inner wing area ,30cm to front subframe mounting (5.3.6 (a) (i))

Offside Front Lower Suspension arm pin or bush excessively worn (5.3.4 (a) (i))

Nearside Rear Inner tyre very low in pressure

Nearside Rear handbrake cable fouling on tyre

corrosion in brake pipes (limited vision on exact condition )

crack in nearside of windscreen not significantly affects the driver’s view of the road

excessive corrosion at nearside front inner wing away from prescribed areas

rear brake efforts erratic ?

underside very muddy ,especially front suspension etc ,will need to be cleaned to carry out a full retest examination

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement,advise renewing

corrosion in brake pipes,inner wings, and inner wheel arches

crack in nearside of windscreen (Failure for damage is only justified if the damage significantly affects the driver’s view of the road. )

number plate lamp tempremental -worked at time of test

very muddy underside

Nearside Front Play in steering rack inner joint(s) ()

Nearside Front wheel bearing has slight play (2.5.A.3c)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak ()

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

both front inner arches corroded

Front Suspension arm rubber bush deteriorated but not resulting in excessive movement offside and nearside back most (2.4.G.2)

Offside Front Suspension arm ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Offside Front inner arch corroded

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Oil leak ()

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Exhaust has a major leak of exhaust gases rear box section (7.1.2)

Nearside Front Track rod end ball joint has excessive play (2.2.B.1f)

Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.2.C.1c)

Front Suspension arm rubber bush deteriorated but not resulting in excessive movement offside and nearside back most (2.4.G.2)

Offside Front Suspension arm ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Offside Front inner arch corroded

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Oil leak ()

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Exhaust has a minor leak of exhaust gases rear section (7.1.2)

Nearside Rear Inner nail in tyre

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Track rod end ball joint dust cover damaged, but preventing the ingress of dirt (2.2.C.1c)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

both front tyres worn on inner edges

oil leak

Offside Front Front wheel bearing has excessive play (2.5.A.3c)

Offside Front Front wheel bearing rough when rotated (2.5.A.2)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Front Track rod end ball joint has excessive play (2.2.B.1f)

Front brake disc in such a condition that it is seriously weakened (3.5.1i)

Nearside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement (2.4.G.2)

Offside Rear rear brake recording little or no effort (3.7.B.5a)

n/s rear outter tyre in poor condition

rear tyres low

spar tyre flat

Nearside Front Shock absorber has a light misting of oil (2.7.3)

Nearside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Rear Anti-roll bar has slight play in a pin/bush (2.4.G.2)

Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

poss o/s/f wheel bearing starting to sound noisy

n/s/r tyre near wear limit

parking brake cables chaffing on rear wheels,have repositioned cable mounting brackets

both rear springs front and rear bushes worn

n/s/f lower suspension arm rear bush is partially detached

Nearside Front Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Offside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Track rod end ball joint has excessive play (2.2.B.1f)

both rear springs front and rear bushes worn

n/s/f lower suspension arm rear bush is partially detached

Registration plate lamp not working (1.1.5c)

Tyre tread depth below requirements of 1.6mm (4.1.E.1)

front brake pads near wear limit

n/s and o/s rear spring bushes worn

n/s/r s/absr bush worn

o/s/r tyres approaching wear limit

Front Suspension arm has slight play in a pin/bush (2.4.G.2)

Nearside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Rear Upper Leaf spring has slight wear in a shackle pin and/or bush (2.4.B.2)

off/side front tyre warn on iner edge

off/side hand brake cable partly seized

slight leak near/side rear hub

slight play in both rear wheel bearings