2004 Iveco Daily

Multiple welding repairs underneath

Nearside Front Brake hose slightly deteriorated Small cracks (1.1.12 (b) (ii))

Nearside Front Brake pipe corroded, covered in grease or other material Both brake pipes in nearside front wheel arch area (1.1.11 (c))

Nearside Rear Brake hose slightly damaged (1.1.12 (b) (i))

Noise from clock spring behind steering wheel

Offside Front Brake hose slightly deteriorated Small cracks (1.1.12 (b) (ii))

Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Both rears (5.3.4 (a) (i))

Windscreen damaged but not adversely affecting driver's view Chip (3.2 (a) (i))

Trailer electrical socket (13 pin) not operating the trailer lamps as intended (4.10 (c) (i))

Brake warning light on dashboard

Multiple welding repairs underneath

Nearside Front Brake hose slightly deteriorated Small cracks (1.1.12 (b) (ii))

Nearside Front Brake pipe corroded, covered in grease or other material Both brake pipes in nearside front wheel arch area (1.1.11 (c))

Nearside Rear Brake hose slightly damaged (1.1.12 (b) (i))

Nearside Rear Outer Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Bush (5.3.4 (a) (i))

Noise from clock spring behind steering wheel

Offside Front Brake hose slightly deteriorated Small cracks (1.1.12 (b) (ii))

Windscreen damaged but not adversely affecting driver's view Chip (3.2 (a) (i))

Nearside Front Brake hose slightly deteriorated (1.1.12 (b) (ii))

Nearside Front Brake pipe corroded, covered in grease or other material both front brake pipes on nearside front (1.1.11 (c))

Nearside Front Tyre worn close to legal limit/worn on edge starting too wear outer edge (5.2.3 (e))

Nearside Rear Brake hose slightly deteriorated (1.1.12 (b) (ii))

Offside Front Brake hose slightly deteriorated (1.1.12 (b) (ii))

Offside Rear Oil leak, but not excessive axle seal starting too weep (8.4.1 (a) (i))

Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement both sides (5.3.4 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

multiple welding repairs visible too underside of vehicle

sill covers fitted

Exhaust has a major leak of exhaust gases (6.1.2 (a))

Nearside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Upper Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Rear Brake pipe excessively corroded chalked (1.1.11 (c))

Nearside Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired multiple holes across nearside of vehicle (6.2.2 (d) (ii)) DANGEROUS

Offside Vehicle structure or chassis has excessive corrosion to the extent that overall security or stability of the body is impaired offside has multiple holes too vehicle structure (6.2.2 (d) (ii)) DANGEROUS

Nearside Front Brake hose slightly deteriorated (1.1.12 (b) (ii))

Nearside Front Brake pipe corroded, covered in grease or other material both front brake pipes on nearside front (1.1.11 (c))

Nearside Front Tyre worn close to legal limit/worn on edge starting too wear outer edge (5.2.3 (e))

Nearside Rear Brake hose slightly deteriorated (1.1.12 (b) (ii))

Offside Front Brake hose slightly deteriorated (1.1.12 (b) (ii))

Offside Rear Oil leak, but not excessive axle seal starting too weep (8.4.1 (a) (i))

Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement both sides (5.3.4 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

sill covers fitted

Front suspension components corroded

Nearside Rear Brake pipe corroded, covered in grease or other material Corroded` (1.1.11 (c))

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement Outer bushes (5.3.4 (a) (i))

Small chip in windscreen

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Suspension arm ball joint dust cover severely deteriorated Both front upper dust covers are starting to split (5.3.4 (b) (i))

Front Upper Both front upper suspension arm ball joint dust covers have cracks in them - no splits

Front suspension components corroded

Nearside Front Vehicle structure is corroded but structural rigidity is not significantly reduced inner sill (6.1.1 (c) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material Corroded (1.1.11 (c))

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Both rear linkage bushes (5.3.4 (a) (i))

Windscreen damaged but not adversely affecting driver's view Small chips (3.2 (a) (i))

Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Both rear link bushes (5.3.4 (a) (i))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Front suspension components corroded

Nearside Front Upper Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Nearside Front Vehicle structure is corroded but structural rigidity is not significantly reduced Inner sill (6.1.1 (c) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material Corroded (1.1.11 (c))

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Back of rear wheel arch area (6.1.1 (c) (i))

Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Back of rear wheel arch area (6.1.1 (c) (i))

Position lamp not working All position lamps! (4.2.1 (a) (ii))

Registration plate lamp inoperative in the case of a single lamp or all lamps Both not working (4.7.1 (b) (ii))

Service brake efficiency below requirements (1.2.2 (a) (i))

Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Both rear link bushes (5.3.4 (a) (i))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Front suspension components corroded

Nearside Front Upper Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Nearside Front Vehicle structure is corroded but structural rigidity is not significantly reduced Inner sill (6.1.1 (c) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material Corroded (1.1.11 (c))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Front Exhaust has a minor leak of exhaust gases front of centre silencer (6.1.2 (a))

Nearside Front inner sill corroded out of area

Nearside Rear Brake pipe corroded, covered in grease or other material corroded (1.1.11 (c))

Nearside Rear Upper Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Upper Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Parking brake lever has excessive movement indicating incorrect adjustment no reserve travel (1.1.6 (c))

Nearside Inner body sill corroded

Nearside Windscreen wiper blade defective (3.4 (b) (i))

Upper steering wheel attachment has minor play

Nearside Direction indicator slightly discoloured (1.4.A.2f)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Offside Rear suspension bump stop missing

Nearside Rear Upper Leaf spring has excessive wear in an anchor pin and/or bush (2.4.B.2)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear Upper Leaf spring has excessive wear in an anchor pin and/or bush (2.4.B.2)

Offside Registration plate lamp not working (1.1.C.1d)

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Offside Rear suspension bump stop missing

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Offside Rear Leaf spring has slight side play at eye (anchor) rear lower (2.4.B.4)

Horn not working (1.6.2a)

Nearside Rear Brake hose twisted (3.6.B.4c)

Nearside Rear Leaf spring has excessive side play at eye (anchor) rear lower (2.4.B.4)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Registration plate lamp not working (1.1.C.1d)

Parking brake: efficiency below requirements (3.7.B.7)

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Offside Rear Leaf spring has slight side play at eye (anchor) rear lower (2.4.B.4)

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

offside front tyre has a cut in tread area

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

offside front tyre has minor cut in tread area

rear suspension spring hanger and shackle bushes worn

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

cuts in offside front tyre

Front registration plate deteriorated (6.3.1d)

Offside rear brake binding (3.7.B.1)

Front Brake pad(s) wearing thin (3.5.1g)

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

cuts in offside front tyre

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Rear position lamp(s) slightly affected by the operation of another lamp (1.1.A.3f)

Offside Rear position lamp(s) slightly affected by the operation of another lamp (1.1.A.3f)

Brakes imbalanced across an axle (3.7.B.5b)

Parking brake: efficiency below requirements (3.7.B.7)

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Rear position lamp(s) slightly affected by the operation of another lamp (1.1.A.3f)

Offside Rear position lamp(s) slightly affected by the operation of another lamp (1.1.A.3f)

Rear Service brake: service brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)