2004 Iveco Daily

Front Brake pipe corroded, covered in grease or other material both front pipes corroded (1.1.11 (c))

Front Exhaust has a minor leak of exhaust gases front section (6.1.2 (a))

Front Inner wheel-arch area on both sides corroded

Front Lower Suspension arm corroded but not seriously weakened both front lower arms corroded (5.3.3 (b) (i))

Front Power steering component has slight seepage from a component rack damp (2.1.5 (a))

Front Shock absorbers has light misting of oil on both sides (5.3.2 (b))

Front Sub-frame corroded but not seriously weakened front sub-frame corroded (5.3.3 (b) (i))

Nearside Parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (1.4.2 (a) (i))

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive engine (8.4.1 (a) (i))

Rear Oil leak, but not excessive rear diff (8.4.1 (a) (i))

chassis on both sides corroded

Nearside Front Inner Vehicle structure is corroded but structural rigidity is not significantly reduced arch floor (6.1.1 (c) (i))

Nearside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Shock absorbers has light misting of oil (5.3.2 (b))

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front indicator lense missing

Offside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

chassis scabby in areas

ramp gaiter damp

Brake load sensing valve linkage defective and function impaired bent (1.1.17 (a))

Brake load sensing valve seized but ABS functioning (1.1.17 (c) (i))

Emissions unable to be completed due to diesel leak (8.2.2.2 (e))

Nearside Front Position lamp not working (4.2.1 (a) (ii))

Nearside Rear Outline marker lamp missing (4.2.1 (a) (ii))

Offside Front Brake prescribed area is excessively corroded at pedal box area (1.1.21 (e) (i))

Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i))

Offside Rear Direction indicator not working (4.4.1 (a) (ii))

Offside Rear Outline marker lamp missing (4.2.1 (a) (ii))

Offside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Nearside Front Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Nearside Front Fuel pipe leaking excessively or a risk of fire filter area (6.1.3 (b) (ii)) DANGEROUS

Nearside Rear Body component likely to become detached arch (6.2.1 (a) (ii)) DANGEROUS

Offside Rear Body component likely to become detached arch (6.2.1 (a) (ii)) DANGEROUS

Nearside Front Inner Vehicle structure is corroded but structural rigidity is not significantly reduced arch floor (6.1.1 (c) (i))

Nearside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Shock absorbers has light misting of oil (5.3.2 (b))

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front indicator lense missing

Offside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

chassis scabby in areas

ramp gaiter damp

Front Shock absorbers has light misting of oil on both sides (5.3.2 (b))

Nearside Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Front Service brake binding but not excessively (1.2.1 (f))

Offside Front Inner wheel-arch corroded

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Oil leak, but not excessive engine (8.4.1 (a) (i))

Rear Leaf spring has slight wear in a shackle pin and/or bush both sides front and rear (5.3.4 (a) (i))

Rear Oil leak, but not excessive rear diff (8.4.1 (a) (i))

Nearside Front Upper Suspension arm ball joint has slight play (5.3.4 (a) (i))

Nearside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement split (5.3.4 (a) (i))

Offside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

clutch slipping

Nearside Rear Inner Worn close to legal limit/worn on edge

Offside Rear Inner Worn close to legal limit/worn on edge

Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f))

Nearside Front Headlamp aim too high (4.1.2 (a))

Nearside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting chassis (6.2.2 (d) (i))

Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting chassis (6.2.2 (d) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Registration plate lamp inoperative in the case of a single lamp or all lamps both (4.7.1 (b) (ii))

Nearside Front Upper Suspension arm ball joint has slight play (5.3.4 (a) (i))

Nearside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement split (5.3.4 (a) (i))

Offside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

clutch slipping

Nearside Rear Inner Worn close to legal limit/worn on edge

Offside Rear Inner Worn close to legal limit/worn on edge

Nearside Front Body mounting fixing insecure, but overall security not significantly reduced (6.2.2 (c) (i))

Nearside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement split (5.3.4 (a) (i))

Offside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Brake load sensing valve inoperative but ABS functioning disconnected (1.1.17 (c) (i))

Front Position lamp not working both (4.2.1 (a) (ii))

Nearside Front Headlamp aim too low (4.1.2 (a))

Offside Front Headlamp aim too high (4.1.2 (a))

Offside Rear Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i))

Offside Rear Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i))

Offside Rear Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i))

Windscreen washer provides insufficient washer liquid (3.5 (a))

Front Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Nearside Front Body mounting fixing insecure, but overall security not significantly reduced (6.2.2 (c) (i))

Nearside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement split (5.3.4 (a) (i))

Offside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside wing mirror loose

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front wheel arch holed

Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

surface corrosion to front subframe

Brake load sensing valve linkage obviously incorrectly adjusted (1.1.17 (b))

Front Registration plate inscription illegible (0.1 (b))

Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Service brake excessively binding (1.2.1 (f))

Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Offside Front Service brake excessively binding (1.2.1 (f))

Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Offside Rear fog lamp not working (4.5.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Offside Rear Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Offside Rear Vehicle structure strengthening plate or fastening so insecure that structural rigidity is seriously reduced crossmember (6.1.1 (b) (ii)) DANGEROUS

Nearside wing mirror loose

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front wheel arch holed

Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

surface corrosion to front subframe

Nearside Front Direction indicator incorrect colour (4.4.3 (a))

Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Nearside Headlamp aim too high (4.1.2 (a))

Nearside Rear Body component insecure Wheel arch (6.2.1 (a) (i))

Offside Headlamp aim too low (4.1.2 (a))

Offside Rear Body component insecure Wheel arch (6.2.1 (a) (i))

Electrical wiring inadequately secured Positive battery terminal loose (4.11 (a) (i))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced Near shock absorber mount (6.1.1 (c) (i))

Offside Front Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Offside Rear Outer Tyre worn close to legal limit/worn on edge 2mm (5.2.3 (e))

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced Near shock absorber mount (6.1.1 (c) (i))

Nearside Rear tail gate lock missing

Offside Front driver door hinges loose

Brake valve leaking lsv (1.1.7 (d) (i))

Nearside Rear Outline marker lamp missing (4.2.1 (a))

Offside Headlamp aim so that beam "kick up" is not visible on the screen (4.1.2 (a))

Offside Rear Outline marker lamp missing (4.2.1 (a))

Offside Rear Anti-roll bar linkage fractured snapped (5.3.3 (b) (ii)) DANGEROUS

Steering column attachment defective to the extent that there is a serious risk of detachment lower steering u/j (2.2.2 (d) (ii)) DANGEROUS

Nearside Rear tail gate lock missing

Offside Front driver door hinges loose

Nearside Rear Inner Tyre worn close to the legal limit 3mm 195/65/16c (4.1.E.1)

Nearside wing mirror insecure

Offside Rear Inner Tyre worn close to the legal limit 3mm 195/65/16c (4.1.E.1)

Offside Track rod end ball joint has slight play (2.2.B.1f)

all offside and nearside side markers inoperative

both front upper suspension arm bushes deteriorated but no play found

both rear anti roll bar 'D' bushes have slight play

both steering rack arms have play

drivers door hinge has play and bracket slightly loose

front registration plate deteriorated

rear differential leaking oil

All position lamps not working (1.1.A.3b)

Horn not working (1.6.2a)

Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Offside Outer Seat belt anchorage prescribed area is excessively corroded sill x1 (5.2.6)

Offside front brake binding (3.7.B.1)

Parking brake: efficiency below requirements (3.7.B.7)

Registration plate lamp not working both not working (1.1.C.1d)

Offside Rear Outer Tyre has ply or cords exposed cut to cords 195/65/16c (4.1.D.1b) DANGEROUS

Nearside Rear Inner Tyre worn close to the legal limit 3mm 195/65/16c (4.1.E.1)

Nearside wing mirror insecure

Offside Rear Inner Tyre worn close to the legal limit 3mm 195/65/16c (4.1.E.1)

Offside Track rod end ball joint has slight play (2.2.B.1f)

all offside and nearside side markers inoperative

both front upper suspension arm bushes deteriorated but no play found

both rear anti roll bar 'D' bushes have slight play

both steering rack arms have play

drivers door hinge has play and bracket slightly loose

front registration plate deteriorated

rear differential leaking oil

Offside Rear Outer Tyre worn close to the legal limit 2mm 195/65/16c (4.1.E.1)

Front registration plate deteriorated but not likely to be misread (6.3.1d)

Brake load sensing valve defective and function impaired linkage insecure (3.6.E.3)

Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Offside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Offside Track rod end ball joint has excessive play (2.2.B.1f)

Front registration plate deteriorated but not likely to be misread (6.3.1d)

Nearside Tyre worn close to the legal limit 195/65/16 (4.1.E.1)

brake pedal rubber split

injection light on

Battery insecure (1.9.1)

Nearside Front Track rod end ball joint has excessive play (2.2.B.1f)

Nearside Obligatory mirror missing (8.1.1)

Offside Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.2.C.1c)

Offside Front Track rod end ball joint has excessive play (2.2.B.1f)

Offside Obligatory mirror insecure (8.1.1)

Offside Obligatory mirror missing (8.1.1)

Windscreen has damage to an area in excess of a 10mm circle within zone 'A' (8.3.1a)

Nearside hub appears to be bent

brake pedal rubber split

injection light on

tracking obviously incorrect

ecu lt on

Brake fluid warning lamp illuminated (3.6.G.2)

Centre Exhaust has a major leak of exhaust gases (7.1.2)

Emissions not tested (7.4.B.1)

Front Brakes imbalanced across an axle (3.7.B.5b)

Headlamp switch faulty (1.7.1)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Offside Headlamp not working on dipped beam (1.7.5a)

Offside Outer Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Inner Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1) DANGEROUS

Nearside Outer Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1) DANGEROUS

Offside Inner Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1) DANGEROUS

Parking brake: efficiency below requirements (3.7.B.7) DANGEROUS

Service brake: efficiency below requirements (3.7.B.7) DANGEROUS

bonnet cable broken

ecu lt on

front discs in poor condition

n/s handbrake cable in poor condition

lower steering colume bush worn

slight exhaust leak

slight roughness in steering

Battery insecure (1.9.1)

Electrical wiring insecure (1.9.2a)

Nearside Outer Front Track rod end ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.2.C.1c)

Nearside Outer Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Outer Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Brake load sensing valve has been disconnected and was fitted as standard (3.6.E.2) DANGEROUS

Nearside rear parking brake recording little or no effort (3.7.B.6a) DANGEROUS

Offside rear parking brake recording little or no effort (3.7.B.6a) DANGEROUS

Parking brake lever has no reserve travel (3.1.6b) DANGEROUS

Parking brake: efficiency below requirements (3.7.B.7) DANGEROUS

front brakes have a slight brake bind

lower steering column bearing/bush not worn and has play

offside rear brake has no back plate

slight exhaust leak at front of exhaust silencer

steering system is slightly stiff and rough caused by lower column bush

surface corrosion to chassis and undervehicle

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Brake load sensing valve linkage defective and function impaired (3.6.E.3)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Parking brake: efficiency below requirements (3.7.B.7)

Towbar locking device missing (6.6.3b)

Windscreen has damage to an area in excess of a 10mm circle within zone 'A' (8.3.1a)

Offside Front Direction indicator incomplete (1.5.A1b)