2004 Ford Transit

Front Integral body structure is corroded but structural rigidity is not significantly reduced Outer sills. (6.1.1 (c) (i))

Front Integral body structure is repaired but structural rigidity is not significantly reduced Inner steps. (6.1.1 (d) (i))

Front Subframe mounting prescribed area is corroded but not considered excessive N/s and o/s rear (5.3.6 (a) (i))

Nearside Front Subframe mounting prescribed area is corroded but not considered excessive Chassis leg (5.3.6 (a) (i))

Nearside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Front Tyre worn close to legal limit/worn on edge Inner edge. (5.2.3 (e))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Rear Tipper sub frame corroded and holed.

Rear Tyre slightly damaged/cracking or perishing ALL tyres. (5.2.3 (d) (ii))

Rear Vehicle structure or chassis corroded within 30cm of a mounting, but not seriously affecting overall security N/s and o/s. (6.2.2 (d) (i))

Front N/s and o/s outer sills corroded.

Front Steps and out riggers corroded. N/s and o/s

Front Subframe mounting prescribed area is corroded but not considered excessive N/s and o/s chassis very corroded. (5.3.6 (a) (i))

Nearside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement Rear bush. (5.3.4 (a) (i))

Nearside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Rear Body mounting fixing insecure, but overall security not significantly reduced Tipper body sub frame. (6.2.2 (c) (i))

Nearside Rear Outer Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Nearside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Nearside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement Rear bush. (5.3.4 (a) (i))

Offside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Prop shaft bearing has slight play Both bearings (6.1.7 (b) (i))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Underside of vehicle very corroded.

Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength Chassis inner wing. (5.3.6 (a) (i))

Offside Rear Rear fog lamp not working (4.5.1 (a) (ii))

Front Brake disc in such a condition that it is seriously weakened N/s and o/s. (1.1.14 (a) (ii)) DANGEROUS

Front N/s and o/s outer sills corroded.

Front Steps and out riggers corroded. N/s and o/s

Front Subframe mounting prescribed area is corroded but not considered excessive N/s and o/s chassis very corroded. (5.3.6 (a) (i))

Nearside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement Rear bush. (5.3.4 (a) (i))

Nearside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Rear Body mounting fixing insecure, but overall security not significantly reduced Tipper body sub frame. (6.2.2 (c) (i))

Nearside Rear Outer Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Nearside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Nearside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement Rear bush. (5.3.4 (a) (i))

Offside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Prop shaft bearing has slight play Both bearings (6.1.7 (b) (i))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Underside of vehicle very corroded.

Central Prop shaft flexible coupling slightly deteriorated (6.1.7 (d) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement REAR (5.3.4 (a) (i))

Nearside Seat belt slightly damaged (7.1.2 (b) (i))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement REAR (5.3.4 (a) (i))

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement REAR (5.3.4 (a) (i))

Nearside Headlamp aim too low and too far to the left. (4.1.2 (a))

Nearside Seat belt slightly damaged (7.1.2 (b) (i))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement REAR (5.3.4 (a) (i))

Offside Headlamp aim too low (4.1.2 (a))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Front Subframe mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

corrosion to cab floor+steps+rear chassis

one reverse light not working

Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c))

Nearside Front Tyre has ply or cords damaged (5.2.3 (d) (ii)) DANGEROUS

Nearside Rear Brake lining(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Offside Front Tyre has ply or cords damaged (5.2.3 (d) (ii)) DANGEROUS

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Front Subframe mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

corrosion to cab floor+steps+rear chassis

one reverse light not working

Central Prop shaft bearing has slight play rubber support deteriorated (6.1.7 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Front Subframe mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

clutch pedal rubber worn

corrosion to cab steps+cab floor+chassis rails

reverse lights not working

Brake hose excessively chafed servo hose (1.1.12 (b) (ii))

Nearside Headlamp levelling device inoperative (4.1.5 (a))

Nearside Rear Outline marker lamp missing (4.2.1 (a) (ii))

Offside Headlamp aim too high and too far to the right. (4.1.2 (a))

Offside Headlamp levelling device inoperative (4.1.5 (a))

Offside Rear Outline marker lamp missing (4.2.1 (a) (ii))

Central Prop shaft bearing has slight play rubber support deteriorated (6.1.7 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Front Subframe mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Nail in tyre ()

Nearside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

clutch pedal rubber worn

corrosion to cab steps+cab floor+chassis rails

reverse lights not working

tow ball pin missing at time of test

Exhaust emissions exceed manufacturer's specified limit 0.90 (8.2.2.2 (a))

Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Headlamp aim too low will not adjust up (4.1.2 (a))

Offside Rear Rear fog lamp not working (4.5.1 (a) (ii))

Stop lamp(s) all not working (4.3.1 (a) (iii)) DANGEROUS

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear bush (5.3.4 (a) (i))

Nearside Front Service brake fluctuating, but not excessively (1.2.1 (e))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear bush (5.3.4 (a) (i))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Prop shaft bearing has slight play (6.1.7 (b) (i))

Suspension component mounting prescribed area is corroded but not considered excessive front sub frame mount (5.3.6 (a) (i))

handbrake travel

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear bush (5.3.4 (a) (i))

Nearside Front Service brake fluctuating, but not excessively (1.2.1 (e))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear bush (5.3.4 (a) (i))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Brake pipe excessively corroded (1.1.11 (c))

Prop shaft bearing has slight play (6.1.7 (b) (i))

Suspension component mounting prescribed area is corroded but not considered excessive front sub frame mount (5.3.6 (a) (i))

handbrake travel

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Nearside Front front brake fluctuating, but not excessively (3.7.B.3)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Offside Front Tyre worn close to the legal limit inner edge (4.1.E.1)

Offside Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Offside Rear Inner Road wheel with a slightly distorted bead rim (4.2.A.1a)

Parking brake lever has little reserve travel (3.1.6b)

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Shock absorber has a light misting of oil (2.7.3)

Nearside Seat belt damaged but webbing not significantly weakened (5.2.2a)

Offside Rear Shock absorber has a light misting of oil (2.7.3)

clutch pedal rubber worn

corrosion to chassis rails,body rails,front inner wings,cab floors

front brake pads getting low

front tyres worn on edges

major weld repairs made to steps/cab floor and front inner wings

nearside rear inner tyre flat

offside mirror slightly insecure

Brake pedal anti-slip provision incomplete (3.3.A.1b)

Nearside Rear Direction indicator not working (1.4.A.2c)

Offside Stop lamp not working (1.2.1b)

clutch pedal rubber worn

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Shock absorber has a light misting of oil (2.7.3)

Nearside Seat belt damaged but webbing not significantly weakened (5.2.2a)

Offside Rear Shock absorber has a light misting of oil (2.7.3)

corrosion to chassis rails,body rails,front inner wings,cab floors

front brake pads getting low

front tyres worn on edges

major weld repairs made to steps/cab floor and front inner wings

nearside rear inner tyre flat

offside mirror slightly insecure

Nearside Seat belt damaged but not affecting the operation of the belt (5.2.2a)

Shock absorber has a light misting of oil (2.7.3)

brake pedel anti-slip worn on the edge

rear tipping body corroded next to the hinges

Nearside Front Upper Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Lower Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Towbar locking device missing (6.6.3b)

Nearside Seat belt damaged but not affecting the operation of the belt (5.2.2a)

Offside Rear position lamp(s) has light sources not illuminating, but not more than 50% (1.1.A.3b)

Shock absorber has a light misting of oil (2.7.3)

brake pedel anti-slip worn on the edge

rear tipping body slightly coroded next to the hinges

Front Brake pipe slightly corroded (3.6.B.2c)

Front Vehicle structure has slight corrosion (6.1.A.1)

Nearside Inner Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside Outer Seat belt damaged but webbing not significantly weakened (5.2.2a)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Power steering component(s) has slight seepage from a component (2.3.3b)

Rear Vehicle structure has slight corrosion (6.1.A.1)

Nearside Headlamp aim too far to the right (1.8)

Nearside Rear Brake pipe excessively corroded (3.6.B.2c)

Nearside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside Side repeater missing (1.4.A.2b)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Headlamp aim too far to the right (1.8)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Inner Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Power steering component(s) has slight seepage from a component (2.3.3b)

Rear Vehicle structure has slight corrosion (6.1.A.1)

Nearside Rear Anti-roll bar linkage rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Shock absorber has a light misting of oil (2.7.3)

Nearside Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar linkage rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Shock absorber has a light misting of oil (2.7.3)

Offside Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

nearside and offside outer sills slight corrosion

Exhaust emits an excessive level of metered smoke for a turbo charged engine (7.4.B.3b)

Nearside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Offside Front wheel bearing rough when rotated (2.5.A.2)

Offside Rear fog lamp not working (1.3.2b)

Offside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Offside Stop lamp not working (1.2.1b)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Nearside Rear Anti-roll bar has slight play in a pin/bush (2.4.G.2)

Nearside Rear Shock absorber has a light misting of oil (2.7.3)

Nearside Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar has slight play in a pin/bush (2.4.G.2)

Offside Rear Shock absorber has a light misting of oil (2.7.3)

Offside Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

outer sills rusty

both front suspension arm bushes seperating slightly

brake fluid level close to minimum

o/s/r handbrake effort not as strong as could be

Nearside Front Seat belt damaged sufficient to significantly weakened the webbing (5.2.2a)

Nearside Front wheel bearing rough when rotated (2.5.A.2)

Nearside Rear Braking system leaking (3.6.A.1)

Nearside rear brake recording little or no effort (3.7.B.5a)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Offside Rear fog lamp not working (1.3.2b)

Parking brake: efficiency below requirements (3.7.C.1b)

both front suspension arm bushes seperating slightly

brake fluid level close to minimum

o/s/r handbrake effort not as strong as could be

Nearside Obligatory mirror seriously damaged, affecting the rear view (8.1.2a)

Offside rear brake recording little or no effort (3.7.B.5a)

Parking brake: efficiency below requirements (3.7.B.7)

Offside Stop lamp not working (1.2.1b)