2004 Ford Transit

Brake pipe corroded, covered in grease or other material Fronts to rears (1.1.11 (c))

Exhaust deteriorated

Front Brake disc worn, pitted or scored, but not seriously weakened Nearside and offside (1.1.14 (a) (ii))

Front Brake pipe corroded, covered in grease or other material Nearside and offside (1.1.11 (c))

Front Coil spring corroded Nearside and offside (5.3.1 (b) (i))

Front Subframe mounting prescribed area is corroded but not considered excessive Chassis and inner wing areas (5.3.6 (a) (i))

Front Wheel bearing has slight play Nearside and offside (5.1.3 (a) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Inner Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Inner Tyre worn close to legal limit/worn on edge Also nail in tread area (5.2.3 (e))

Outer and undersill areas corroded and holed outside prescribed areas

Parking brake efficiency only just met

Propshaft center bearing carrier rubber deteriorated

Rear Leaf spring has slight wear in a shackle pin and/or bush Nearside and offside (5.3.4 (a) (i))

Rear Leaf spring has slight wear in an anchor pin and/or bush Nearside and offside (5.3.4 (a) (i))

Rear Passenger seat(s) missing at time of test ()

Suspension component mounting prescribed area is corroded but not considered excessive Chassis and crossmembers (5.3.6 (a) (i))

Suspension spring mounting prescribed area is corroded but not considered excessive Chassis and crossmembers (5.3.6 (a) (i))

Tipper body/bed corroded

Towbar slightly corroded within 30cm of towbar mounting (6.1.6 (i) (i))

Nearside Front Outline marker lamp not working (4.2.1 (a) (ii))

Offside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Outline marker lamp not working Nearside and offside (4.2.1 (a) (ii))

Rear fog lamp does not emit a steady red light Lenses damaged (4.5.4 (a))

Stop lamp(s) all not working (4.3.1 (a) (iii)) DANGEROUS

Brake pipe corroded, covered in grease or other material Fronts to rears (1.1.11 (c))

Exhaust deteriorated

Front Brake disc worn, pitted or scored, but not seriously weakened Nearside and offside (1.1.14 (a) (ii))

Front Brake pipe corroded, covered in grease or other material Nearside and offside (1.1.11 (c))

Front Coil spring corroded Nearside and offside (5.3.1 (b) (i))

Front Subframe mounting prescribed area is corroded but not considered excessive Chassis and inner wing areas (5.3.6 (a) (i))

Front Wheel bearing has slight play Nearside and offside (5.1.3 (a) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Inner Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Inner Tyre worn close to legal limit/worn on edge Also nail in tread area (5.2.3 (e))

Outer and undersill areas corroded and holed outside prescribed areas

Propshaft center bearing carrier rubber deteriorated

Rear Leaf spring has slight wear in a shackle pin and/or bush Nearside and offside (5.3.4 (a) (i))

Rear Leaf spring has slight wear in an anchor pin and/or bush Nearside and offside (5.3.4 (a) (i))

Rear Passenger seat(s) missing at time of test ()

Suspension component mounting prescribed area is corroded but not considered excessive Chassis and crossmembers (5.3.6 (a) (i))

Suspension spring mounting prescribed area is corroded but not considered excessive Chassis and crossmembers (5.3.6 (a) (i))

Tipper body/bed corroded

Towbar slightly corroded within 30cm of towbar mounting (6.1.6 (i) (i))

Front Suspension arm pin or bush worn but not resulting in excessive movement nearside & offside (5.3.4 (a) (i))

Nearside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Rear Inner Tyre slightly damaged/cracking or perishing (5.2.3 (d) (i))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Nail in tyre ()

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Outer Tyre slightly damaged/cracking or perishing (5.2.3 (d) (i))

Offside Seat belt anchorage prescribed area is corroded but not considered excessive door step areas (7.1.1 (a) (i))

Play in steering rack inner joint(s) ()

Rear Leaf spring has slight wear in a shackle pin and/or bush nearside & offside (5.3.4 (a) (i))

Suspension component mounting prescribed area is corroded but not considered excessive chassis & crossmembers (5.3.6 (a) (i))

Suspension spring mounting prescribed area is corroded but not considered excessive chassis & crossmembers (5.3.6 (a) (i))

nearside & offside, undersill areas corroded & holed

rear bed & carrier corroded

Driver's door cannot be opened from outside the vehicle (6.2.3 (a))

Exhaust emissions exceed manufacturer's specified limit (8.2.2.2 (a))

Nearside Rear Outer Tyre has a cut in excess of the requirements deep enough to reach the ply or cords sidewall damage (5.2.3 (d) (i))

Nearside Stop lamp(s) not working (4.3.1 (a) (ii))

Offside Front Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Rear Body component corroded and likely to cause injury side of bed (6.2.1 (a) (i))

Offside Rear Position lamp not working (4.2.1 (a))

Windscreen wiper does not clear the windscreen effectively nearside & offside (3.4 (b) (ii))

Nearside Front Tyre has ply or cords exposed (5.2.3 (d) (ii)) DANGEROUS

Offside Rear Inner Tyre has ply or cords exposed (5.2.3 (d) (ii)) DANGEROUS

Front Suspension arm pin or bush worn but not resulting in excessive movement nearside & offside (5.3.4 (a) (i))

Nearside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Rear Inner Tyre slightly damaged/cracking or perishing (5.2.3 (d) (i))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Nail in tyre ()

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Outer Tyre slightly damaged/cracking or perishing (5.2.3 (d) (i))

Offside Seat belt anchorage prescribed area is corroded but not considered excessive door step areas (7.1.1 (a) (i))

Play in steering rack inner joint(s) ()

Rear Leaf spring has slight wear in a shackle pin and/or bush nearside & offside (5.3.4 (a) (i))

Suspension component mounting prescribed area is corroded but not considered excessive chassis & crossmembers (5.3.6 (a) (i))

Suspension spring mounting prescribed area is corroded but not considered excessive chassis & crossmembers (5.3.6 (a) (i))

nearside & offside, undersill areas corroded & holed

rear bed & carrier corroded

Brake pipe slightly corroded Fronts to rears (3.6.B.2c)

Front Brake pipe slightly corroded Nearside & offside (3.6.B.2c)

Front coil spring corroded Nearside & offside (2.4.C.1b)

General corrosion to chassis & crossmembers

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear spring eye bushes deteriorated

Undersill areas corroded & holed

Nearside Stop lamp not working (1.2.1b)

Offside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Offside Rear fog lamp not working (1.3.2b)

Brake pipe slightly corroded Fronts to rears (3.6.B.2c)

Front Brake pipe slightly corroded Nearside & offside (3.6.B.2c)

Front coil spring corroded Nearside & offside (2.4.C.1b)

General corrosion to chassis & crossmembers

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear spring eye bushes deteriorated

Undersill areas corroded & holed

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

front brake pipes surface rust

Nearside Rear Tyre incorrectly seated on the wheel rim flat (4.1.D.1d)

Nearside Rear rear brake binding (3.7.B.1)

Nearside Seat belt anchorage prescribed area is excessively corroded sill (5.2.6)

Nearside Seat belt damaged sufficient to significantly weakened the webbing (5.2.2a)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Offside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Front Front wheel bearing rough when rotated (2.5.A.2)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Seat belt anchorage prescribed area is excessively corroded sill (5.2.6)

Offside Track rod end ball joint has excessive play (2.2.B.1f)

Parking brake: efficiency below requirements (3.7.B.7)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

front brake pipes surface rust

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Seat belt stitching slightly frayed (5.2.2b)

Offside Front Seat belt stitching slightly frayed (5.2.2b)

oil leak

Exhaust emits an excessive level of metered smoke for a turbo charged engine (7.4.B.3b)

Nearside Front wheel bearing rough when rotated (2.5.A.2)

Offside Registration plate lamp not working (1.1.C.1d)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Seat belt stitching slightly frayed (5.2.2b)

Offside Front Seat belt stitching slightly frayed (5.2.2b)

oil leak

Nearside Front Lower Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Nearside Rear Stop lamp not working (1.2.1b)

Offside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Rear Road wheel with a slightly distorted bead rim (4.2.A.1a)

Oil leak

Nearside Front Seat belt stitching slightly frayed (5.2.2b)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Inner Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside Outer Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Inner Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Outer Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Rear wheel bearing has slight play (2.6.2)

Offside rear mud flap missing

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Front Track rod end ball joint has excessive play (2.2.B.1f)

Nearside Rear Rear position lamp(s) excessively deteriorated so that it is not visible from a reasonable distance (1.1.A.3d)

Offside Rear Rear wheel bearing has slight play (2.6.2)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Front Lower Front suspension has excessive play in a track control arm inner bush (2.5.B.2b)