2004 Ford Transit

Brake pipe excessively corroded front to rear pipes towards rear, (1.1.11 (c))

Exhaust on a vehicle fitted with a diesel particulate filter emits visible smoke of any colour (8.2.2.2 (d))

Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis leg in wheel arch (6.1.1 (c) (i))

Nearside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii))

Nearside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill, body,wheel arch and outrigger near rear spring hanger pins (5.3.6 (a) (i))

Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill and body panel near rear spring anchor pins (5.3.6 (a) (i))

Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis leg in wheel arch (6.1.1 (c) (i))

Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b))

Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill near rear spring anchor pins (5.3.6 (a) (i))

Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill near rear spring hanger pins (5.3.6 (a) (i))

Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill, body,wheel arch and outrigger near rear spring hanger pins (5.3.6 (a) (i))

Offside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Offside Front Tyre has a bulge, caused by separation or partial failure of its structure (5.2.3 (d) (ii)) DANGEROUS

Offside Rear Tyre has ply or cords exposed cracked on inner sidewall (5.2.3 (d) (ii)) DANGEROUS

Vehicle structure is fractured and so weakened within 30cm of a towbar mounting, the towbar is likely to become detached rear crossmember corroded and holed along its length (6.1.6 (i) (ii)) DANGEROUS

Both rear wheel bearings have endfloat

Front Anti-roll bar pin or bush worn but not resulting in excessive movement D bushes (5.3.4 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Nearside Front Shock absorbers has light misting of oil (5.3.2 (b))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Nearside Seat belt webbing slightly damaged or frayed (7.1.2 (b))

Offside Front Shock absorbers has light misting of oil (5.3.2 (b))

Oil leak, but not excessive from engine (8.4.1 (a) (i))

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Suspension arm pin or bush worn but not resulting in excessive movement All suspension bushes perishing (5.3.4 (a) (i))

Underbody corrosion everywhere

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Front Anti-roll bar linkage pin or bush worn but not resulting in excessive movement D bushes (5.3.4 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive from engine (8.4.1 (a) (i))

Rear wheel bearings have end float

Suspension arm pin or bush worn but not resulting in excessive movement all (5.3.4 (a) (i))

Underbody repairs undersealed

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

underbody corrosion in most areas

Fuel cap/sealing device ineffective temp cap fitted, no positive seal (6.1.3 (b) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i))

Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill corroded and holed (7.1.1 (a) (i))

Offside Stop lamp(s) not working (4.3.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Vehicle structure is fractured and structural rigidity is significantly reduced corroded, deformed and holes above offside rear bump stop (6.1.1 (a) (i))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement D bushes (5.3.4 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Suspension arm pin or bush worn but not resulting in excessive movement spliting (5.3.4 (a) (i))

Front Tyre worn close to legal limit/worn on edge both (5.2.3 (e))

Oil leak, but not excessive Engine oil leak to floor, close to limit (8.4.1 (a) (i))

Rear Wheel bearing has slight play wheel bearing have end float (5.1.3 (a) (i))

Tyre slightly damaged/cracking or perishing All (5.2.3 (d) (ii))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

underbody corrosion in all parts, radiator support panel corroded , holes and detached at offside

Front Anti-roll bar pin or bush worn but not resulting in excessive movement both D shaped bushes (5.3.4 (a) (i))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement both bushes slightly perished (5.3.4 (a) (i))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Integral body structure is corroded but structural rigidity is not significantly reduced door step (6.1.1 (c) (i))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive sealed at time of test customer advised further investigation may de needed (8.4.1 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

corrosion throughout under side of vehicle

front crossmember support corroded and holed

milometer readings faulty

temp fuel cap fitted but sealing

Emissions not tested (8.2.2.2 (e))

Nearside Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i))

Nearside Rear Integral body structure inadequately repaired such that structural rigidity is significantly reduced crossmember (6.1.1 (d) (i))

Offside Front Inner Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced door step (6.1.1 (c) (i))

Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outrigger (6.1.1 (c) (i))

Offside Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced sill (6.1.1 (c) (i))

Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outrigger (6.1.1 (c) (i))

Oil leaking excessively from engine (8.4.1 (a) (i))

Rear Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i))

Rear Exhaust has a major leak of exhaust gases holed (6.1.2 (a))

Towbar attachment insecure electrics point insecure (6.1.6 (c) (i))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement both D shaped bushes (5.3.4 (a) (i))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement both bushes slightly perished (5.3.4 (a) (i))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

corrosion throughout under side of vehicle

front crossmember support corroded and holed

Brake pipe excessively corroded all (1.1.11 (c))

Offside Stop lamp(s) all not working (4.3.1 (a) (iii)) DANGEROUS

Brake pipe corroded, covered in grease or other material all pipes covered in grease (1.1.11 (c))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement b bushes (5.3.4 (a) (i))

Front Play in steering rack inner joint(s) both sides ()

lots of previous repairs, under body heavily under sealed

brake pipes are corroded from front to rear

nearside front wing mirror secured with glue

slight oil leak under the engine

under body corroded from front to rear

Front Windscreen wiper does not clear the windscreen effectively bothsides (3.4 (b) (ii))

Offside Front Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill and inner body, and outer sill has holes (6.2.2 (d) (i))

Offside Rear Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

brake pipes are corroded from front to rear

nearside front wing mirror secured with glue

slight oil leak under the engine

under body corroded from front to rear

Brake pipe slightly corroded 2xmain (3.6.B.2c)

Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement x2 (2.4.G.2)

Front Suspension arm rubber bush deteriorated but not resulting in excessive movement n/s and o/s (2.4.G.2)

Front coil spring corroded n/s and o/s (2.4.C.1b)

Nearside Rear outer and under sill

Offside Rear outer and under sill

Offside under sill step

Oil leak ()

Parking brake lever has little reserve travel (3.1.6b)

Front Brakes imbalanced across an axle Axle 1 (3.7.B.5b)

Nearside Front Brake pipe excessively corroded (3.6.B.2c)

Nearside Obligatory mirror missing (8.1.1)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded (front) (2.4.A.3)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Rear Brake pipe excessively corroded (3.6.B.2c)

Rear Brakes imbalanced across an axle Axle 2 (3.7.B.5b)

Service brake: efficiency below requirements (3.7.B.7)

Nearside Rear Braking system leaking brake pipe (3.6.A.1) DANGEROUS

Brake pipe slightly corroded 2xmain (3.6.B.2c)

Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement x2 (2.4.G.2)

Front Suspension arm rubber bush deteriorated but not resulting in excessive movement n/s and o/s (2.4.G.2)

Front coil spring corroded n/s and o/s (2.4.C.1b)

Nearside Rear outer and under sill

Offside Rear outer and under sill

Offside under sill step

Oil leak ()

Parking brake lever has little reserve travel (3.1.6b)

Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement n/s and o/s (2.4.G.2)

Front Brake pipe slightly corroded n/s and o/s (3.6.B.2c)

Front coil spring corroded x2 (2.4.C.1b)

Parking brake lever has little reserve travel (3.1.6b)

Rear Brake pipe slightly corroded x2 (3.6.B.2c)

Rear chassis n/s and o/s hard corrosion

Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement n/s and o/s (2.4.G.2)

Front Brake pipe slightly corroded n/s and o/s (3.6.B.2c)

Front coil spring corroded x2 (2.4.C.1b)

Offside Headlamp not working on dipped beam (1.7.5a)

Parking brake lever has little reserve travel (3.1.6b)

Rear Brake pipe slightly corroded x2 (3.6.B.2c)

Rear chassis n/s and o/s hard corrosion

Offside Rear rear brake binding (3.7.B.1)

Rear Registration plate lamp not working (1.1.C.1d)

Service brake: efficiency below requirements (3.7.B.7)

Exhaust emits an excessive level of metered smoke for a turbo charged engine (7.4.B.3b)

Nearside Rear Stop lamp not working (1.2.1b)

Centre propshaft bearing badly worn

Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Oil leak

Play in prop-shaft centre bearing

Nearside Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Registration plate lamp shows direct white light to the rear (1.1.C.1f)

Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Oil leak

Play in prop-shaft centre bearing

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Track rod end ball joint has slight play (2.2.B.1f)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Track rod end ball joint has slight play (2.2.B.1f)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Oil leak

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Nearside Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Rear Tyre worn close to the legal limit (4.1.E.1)

end float in both rear wheels(not effecting braking)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Seat belt damaged but webbing not significantly weakened (5.2.2a)

Nearside Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Registration plate lamp shows direct white light to the rear (1.1.C.1f)

Rear Tyre worn close to the legal limit (4.1.E.1)

end float in both rear wheels(not effecting braking)

N/S side load door handle broken off

Nearside Front Rear position lamp(s) not working (1.1.A.3b)

Offside Front Rear position lamp(s) not working (1.1.A.3b)

N/S side load door handle broken off