2005 Ford Transit Connect

Engine mounting damaged or deteriorated resulting in excessive movement (6.1.8 (a) (i))

Front Exhaust has a major leak of exhaust gases (6.1.2 (a))

Front Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii))

Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i))

Offside Front Lower Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner & outer sill (5.3.6 (a) (i))

Tyre(s) of different sizes are fitted on the same axle. o/s/r 225/40/18 n/s/r 215/45/17 (5.2.3 (b))

Offside Front Inner Tyre tread depth below requirements of 1.6mm 225/40/18 (5.2.3 (e)) DANGEROUS

Nearside Front Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Front Tyre has a cut but not deep enough to reach the ply or cords (5.2.3 (d) (i))

Nearside Front wheel nut missing

Offside Front Anti-roll bar ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Drag link end ball joint has slight play (2.1.3 (b) (i))

Offside Front headlamp insecure

Offside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

both inner & outer sill corroded

exhaust deteriorated

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Offside Front Drag link end ball joint has slight play (2.1.3 (b) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front headlamp insecure

Oil leak, but not excessive (8.4.1 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Steering column top bearing slightly worn (2.2.2 (b))

both inner & outer sill corroded

exhaust deteriorated

Nearside Front Inner Tyre has a cut in excess of the requirements deep enough to reach the ply or cords 225/40/18 (5.2.3 (d) (i))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner & outer sill (5.3.6 (a) (i))

Offside Front Headlamp aim too high (4.1.2 (a))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Tyre(s) of different sizes are fitted on the same axle. o/s/r tyre 215/45/18 n/s/r 225/40/18 (5.2.3 (b))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Offside Front Drag link end ball joint has slight play (2.1.3 (b) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front headlamp insecure

Oil leak, but not excessive (8.4.1 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Steering column top bearing slightly worn (2.2.2 (b))

both inner & outer sill corroded

exhaust deteriorated

Offside Front Macpherson strut pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Front Macpherson strut pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Play in steering rack inner joint(s)

Offside Front Coil spring corroded (5.3.1 (b) (i))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside and nearside rear leaf springs corroded

Rear suspension has surface corrosion

Front Registration plate inscription illegible (0.1 (b))

Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced Sill (7.1.1 (a) (i))

Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i))

Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i))

Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Rear Registration plate inscription illegible (0.1 (b))

Windscreen washer provides insufficient washer liquid (3.5 (a))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Play in steering rack inner joint(s)

Nearside Rear Direction indicator slightly discoloured (4.4.3 (a))

Offside Front Coil spring corroded (5.3.1 (b) (i))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Direction indicator slightly discoloured (4.4.3 (a))

Offside and nearside rear leaf springs corroded

Oil leak, but not excessive Engine (8.4.1 (a) (i))

Rear suspension has surface corrosion

Brake pedal wearing smooth (1.1.2 (c))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Headlamp lens slightly defective (4.1.1 (b) (i))

Nearside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Headlamp lens slightly defective (4.1.1 (b) (i))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

nearside wiper smearing

rear leaf springs corroded

unable to fully inspect inner brake pads

Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Headlamp lenses poor.

Offside Rear ourt sill corroded not excessive

Oil leak, but not excessive (8.4.1 (a) (i))

Brake pedal rubber worn

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Headlamp lenses slightly cloudy.

Nearside Front Wheel bearing slightly noisy (5.1.3 (b) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive outer sill (5.3.6 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Windscreen wiper blade defective Both (3.4 (b) (i))

Brake pedal wearing smooth (1.1.2 (c))

Offside Rear Outer sill slightly corroded.

Exhaust emissions likely to be affected by an exhaust leak (8.2.2.1 (b))

Exhaust has a major leak of exhaust gases (6.1.2 (a))

Nearside Front Lower Anti-roll bar ball joint excessively worn (5.3.4 (a) (i))

Nearside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i))

Brake pedal wearing smooth (1.1.2 (c))

Nearside Rear Bumper end missing not leaving a sharp edge.

Offside Rear Outer sill slightly corroded.

Front coil spring corroded both sides (2.4.C.1b)

Nearside Front Anti-roll bar linkage ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Nearside Front Tyre worn close to the legal limit on limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

exhaust box corrosion

Nearside Front Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Offside Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Front coil spring corroded both sides (2.4.C.1b)

Nearside Front Anti-roll bar linkage ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Nearside Front Tyre worn close to the legal limit on limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

exhaust box corrosion

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Offside Front Anti-roll bar ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Offside Front Anti-roll bar has slight play in a ball joint (2.4.G.2)

fluid around steering rack.

n/s/f tyre perishing and splitting.

odd size tyre fitted to front and rear.

Exhaust has a major leak of exhaust gases (7.1.2)

Front registration plate character(s) incorrectly spaced (6.3.4a)

fluid around steering rack no leak at time of test

nearside front tyre inner sidewall splitting

odd sized tyres fitted to front and rear axles

Oil leak

nearside front tyre has 2mm tread remaining

power steering fluid looks slightly low, recommend checking when cold

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Front Leaf spring deteriorated but not seriously weakened (2.4.B.1a)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front coil spring corroded (2.4.C.1b)

Offside Rear Leaf spring deteriorated but not seriously weakened (2.4.B.1a)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

some test items hidden by covers and components

Nearside Front Coil spring not correctly located (2.4.C.2)

Nearside Front Windscreen wiper blade insecure (8.2.2)

Offside Front Steering rack gaiter insecure (2.2.D.2d)

Nearside Front Leaf spring deteriorated but not seriously weakened (2.4.B.1a)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front coil spring corroded (2.4.C.1b)

Offside Rear Leaf spring deteriorated but not seriously weakened (2.4.B.1a)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

some test items hidden by covers and components