2005 Ford Transit

some prep work for welding near side front not reduced strenth

Offside Front position lamp(s) not working (1.1.A.3b)

some prep work for welding near side front not reduced strenth

rear out riggers rusty shailing both front door steps/outer sills corroded out of test area this test

Nearside Rear Suspension component mounting prescribed area is excessively corroded cross member (2.4.A.3)

Nearside Rear Suspension component mounting prescribed area is excessively corroded side panal (2.4.A.3)

Nearside Rear Suspension component mounting prescribed area is excessively corroded spring hanger (2.4.A.3)

Nearside Track rod end ball joint has excessive play (2.2.B.1f)

Offside Rear Suspension component mounting prescribed area is excessively corroded cross member (2.4.A.3)

Offside Rear Suspension component mounting prescribed area is excessively corroded forward spring hanger (2.4.A.3)

Offside Rear Suspension component mounting prescribed area is excessively corroded side panal (2.4.A.3)

Offside Rear Suspension component mounting prescribed area is excessively corroded spring hanger (2.4.A.3)

Offside Track rod end ball joint has excessive play (2.2.B.1f)

Service brake: efficiency below requirements (3.7.B.7)

both front lower door steps back of sill corroded out of test area

Brake pipe slightly corroded both rear axle (3.6.B.2c)

Suspension spring mounting prescribed area is corroded but not considered excessive nearside rear wheel arch holed in centre (2.4.A.3)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

strong advise offside step & inner step corroded

Exhaust has a major leak of exhaust gases centre box holed (7.1.2)

Nearside Front Suspension spring mounting prescribed area is excessively corroded of rear inner wheel arch holed by spring hanger (2.4.A.3)

Nearside Rear Tyre has a bulge, caused by separation or partial failure of its structure tyre sidewall (4.1.D.1b)

Nearside Stop lamp not working (1.2.1b)

Nearside Suspension spring mounting prescribed area is excessively corroded sill holed (2.4.A.3)

Offside Rear Suspension spring mounting prescribed area is excessively corroded corner wheel arch by rear spring hanger holed (2.4.A.3)

Offside Rear Suspension spring mounting prescribed area is excessively corroded front of spring hanger mount (2.4.A.3)

Offside Rear Suspension spring mounting prescribed area is excessively corroded of spring hanger mount holed (2.4.A.3)

Parking brake: efficiency below requirements (3.7.B.7)

Rear Brakes imbalanced across an axle Axle 2 (3.7.B.5b)

Brake pipe slightly corroded both rear axle (3.6.B.2c)

Suspension spring mounting prescribed area is corroded but not considered excessive nearside rear wheel arch holed in centre (2.4.A.3)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

strong advise offside step & inner step corroded

Nearside Front Outer Seat belt anchorage prescribed area is excessively corroded SILL AREA (5.2.6)

Nearside Front Seat belt anchorage prescribed area is excessively corroded INNER SILL SILL STEP AREA (5.2.6)

Nearside Outer Body has a sharp edge caused by corrosion LOWER BODY SILL AREA (6.1.C.1)

Nearside Rear Stop lamp not working (1.2.1b)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Outer Seat belt anchorage prescribed area is excessively corroded SILL AREA (5.2.6)

Offside Front Seat belt anchorage prescribed area is excessively corroded FLOOR PAN AREA (5.2.6)

Offside Front Seat belt anchorage prescribed area is excessively corroded INNER SILL SILL STEP AREA (5.2.6)

Offside Rear Brake pipe excessively corroded (3.6.B.2c)

Offside Rear Hydraulic brake cylinder leaking hydraulic fluid (3.6.A.1)

Offside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear rear brake recording little or no effort SERVICE BRAKE (3.7.B.5a)

Offside Rear rear parking brake recording little or no effort PARK BRAKE (3.7.B.6a)

Rear Brakes imbalanced across an axle Axle 2 (3.7.B.5b)

Rear rear brake application uneven SERVICE BRAKE (3.7.B.2)

Centre Front Upper Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Rear Body has slight corrosion (6.1.B.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Vehicle structure has slight corrosion (6.1.A.1)

Offside Front Anti-roll bar synthetic bush deteriorated but not resulting in excessive movement D BUSH (2.4.G.2)

Offside Rear Body has slight corrosion (6.1.B.2)

Offside Rear Vehicle structure has slight corrosion (6.1.A.1)

Centre Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Outer Lower Body has slight corrosion (6.1.B.2)

Nearside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Rear Vehicle structure has slight corrosion (6.1.A.1)

Offside Brake pipe slightly corroded (3.6.B.2c)

Offside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Offside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Offside Rear Vehicle structure has slight corrosion (6.1.A.1)

Oil leak

Rear Body has slight corrosion (6.1.B.2)

Exhaust emits an excessive level of metered smoke for a turbo charged engine (7.4.B.3b)

Nearside Front Fuel system component leaking (7.2.3)

Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement (2.4.G.2)

Nearside Front Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Offside Front Front position lamp(s) not working (1.1.A.3b)

Offside Front Headlamp aim too low (1.8)

Centre Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Outer Lower Body has slight corrosion (6.1.B.2)

Nearside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Rear Vehicle structure has slight corrosion (6.1.A.1)

Offside Brake pipe slightly corroded (3.6.B.2c)

Offside Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Offside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Offside Rear Vehicle structure has slight corrosion (6.1.A.1)

Oil leak

Rear Body has slight corrosion (6.1.B.2)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Rear Registration plate lamp not working (1.1.C.1d)

Nearside Front Headlamp aim too low (1.8)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Headlamp aim too low (1.8)

exhaust outer skin split

Front Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

exhaust outer skin split

Nearside Front Suspension arm has slight play in a pin/bush (2.4.G.2)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Brake pedal anti-slip provision incomplete (3.3.A.1b)

Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Front Suspension arm has slight play in a pin/bush (2.4.G.2)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

front brake discs worn and corroded

Wipers smearing slightly

front brake discs very worn

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Wipers smearing slightly

front brake discs very worn