2003 Volkswagen Caravelle

Exhaust emissions exceed manufacturer's specified limit (8.2.2.2 (a))

Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a))

Offside Front Driver's door cannot be opened from inside the vehicle (6.2.3 (a))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Nearside Front Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Front Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Front Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Nail in tyre ()

Horn not working (7.7 (a))

Nearside Front Service brake excessively fluctuating (1.2.1 (e))

Nearside Rear Service brake excessively fluctuating (1.2.1 (e))

Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Offside Front Headlamp light intensity severely reduced (4.1.4 (a))

Offside Front Service brake excessively fluctuating (1.2.1 (e))

Offside Rear Service brake excessively fluctuating (1.2.1 (e))

Other passenger door cannot be opened from outside the vehicle side door (6.2.3 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Service brake efficiency below requirements (1.2.2 (a) (i))

Service brake effort inadequate at a wheel (1.2.1 (a) (i))

Front Exhaust mounting defective (6.1.2 (a))

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Nail in tyre ()

offside sill/step is corroded

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Play in steering rack inner joint(s) ()

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Rear Passenger seat(s) missing at time of test ()

Brake cable damaged parking brake cable is corroded with wires broken. (1.1.15 (a))

Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b))

Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Nearside Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Offside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Headlamp not working on main beam (4.1.1 (a) (ii))

Offside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Offside Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Rear Tyre(s) of different sizes are fitted on the same axle. (5.2.3 (b))

Offside Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Front sill/step is corroded

Oil leak, but not excessive (8.4.1 (a) (i))

Passenger seat(s) missing at time of test rear seats ()

Play in steering rack inner joint(s) ()

Service brake item Result Brake efficiency 55% only just met the requirement

Nearside Front Front wheel bearing has slight play (2.5.A.3c)

Nearside Front Tyre worn close to the legal limit inner (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Oil leak ()

Central Rear Statutory seat belt missing (5.1.1)

Front Tyre(s) incorrect because tyres fitted to all steerable axle are not of the same structure (4.1.A.2c)

Horn not working (1.6.2a)

Nearside Front Seat belt anchorage prescribed area is excessively corroded sill (5.2.6)

Nearside Front position lamp(s) not working (1.1.A.3b)

Offside Front Track rod end ball joint has excessive play (2.2.B.1f)

Offside Registration plate lamp not working (1.1.C.1d)

Windscreen washer provides insufficient washer liquid (8.2.3)

Nearside Front Front wheel bearing has slight play (2.5.A.3c)

Nearside Front Tyre worn close to the legal limit inner (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Oil leak ()

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Outer Seat belt anchorage prescribed area is corroded but not considered excessive sill (5.2.6)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

Track rod end ball joint dust cover deteriorated, but preventing the ingress of dirt (2.2.C.1c)

Exhaust emits excessive smoke or vapour of any colour (7.4.B.4)

Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Front Exhaust has a major leak of exhaust gases (7.1.2)

Rear brake disc in such a condition that it is seriously weakened (3.5.1i)

Registration plate lamp not working (1.1.C.1d)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Outer Seat belt anchorage prescribed area is corroded but not considered excessive sill (5.2.6)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

Track rod end ball joint dust cover deteriorated, but preventing the ingress of dirt (2.2.C.1c)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Play in steering rack inner joint(s)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

temp repair to exh

Horn not working (1.6.2a)

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Registration plate lamp not working (1.1.C.1d)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Play in steering rack inner joint(s)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Service brake: service brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

temp repair to exh

Centre Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Brake load sensing valve seized (3.6.E.3)

Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Front Anti-roll bar rubber bush bonding deteriorated resulting in excessive movement (2.4.G.2)

Offside Front Direction indicators incorrect colour (1.4.A.2f)

Offside Registration plate lamp not working (1.1.C.1d)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Service brake: efficiency below requirements (3.7.B.7)

Centre Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

An item not tested (Manual)

Driver's door cannot be opened from inside the vehicle (6.2.B.1b)

Nearside Windscreen washer provides insufficient washer liquid (8.2.3)

Nearside passenger door cannot be opened from outside the vehicle (6.2.B.1c)

Offside Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Rear Stop lamp not working (1.2.1b) DANGEROUS

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Play in steering rack inner joint(s)

Rear coil spring incomplete (2.4.C.1a)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Play in steering rack inner joint(s)

Service brake: service brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Nearside Steering system has slight free play detected at steering wheel (2.2.A.1b)

Offside Steering system has slight free play detected at steering wheel (2.2.A.1b)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

Exhaust emits an excessive level of metered smoke for a turbo charged engine (7.4.B.3b)

Nearside Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Nearside Steering system has slight free play detected at steering wheel (2.2.A.1b)

Offside Steering system has slight free play detected at steering wheel (2.2.A.1b)

Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Steering system has slight free play detected at steering wheel (2.2.A.1b)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

n/s front o/s rear tyres cut on sidewalls

Nearside Front Ball joint has excessive play (2.2.B.1f)

Rear brake disc excessively pitted (3.5.1h)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Steering system has slight free play detected at steering wheel (2.2.A.1b)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

n/s front o/s rear tyres cut on sidewalls