2003 Vauxhall Vivaro

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength box section corroded on previous repair within 12 inch of subframe mount (5.3.6 (a) (i))

Nearside Front Tyre has a cut in excess of the requirements deep enough to reach the ply or cords tyre cut to cord on worn section tyre 2.5mm (5.2.3 (d) (i))

Nearside Headlamp has a product on the lens so that the light output is severely reduced no beam pattern (4.1.4 (b))

Offside Front Brake pipe excessively corroded metal pipe in wheel arch corroded (chalked) (1.1.11 (c))

Offside Headlamp has a product on the lens so that the light output is severely reduced no beam pattern (4.1.4 (b))

Offside Rear Stop lamp(s) emits other than a steady red light (4.3.3 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Nearside Rear Tyre has a tear, caused by separation or partial failure of its structure tyre cracked to cord (5.2.3 (d) (ii)) DANGEROUS

Offside Rear Tyre has a tear, caused by separation or partial failure of its structure tyre cracked to cord (5.2.3 (d) (ii)) DANGEROUS

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Play in steering rack inner joint(s) ()

Nearside Rear Brake pipe corroded, covered in grease or other material metal pipe corroded at join to flexi (1.1.11 (c))

Nearside Rear Position lamp slightly affected by the operation of another lamp affected by indicator (4.2.3 (c))

Offside Front Direction indicator insecure lens insecure (4.4.1 (c) (i))

Offside Front Tyre worn close to legal limit/worn on edge tyre worn out on both edges and low 2.5mm (5.2.3 (e))

Offside Play in steering rack inner joint(s) ()

Offside Rear Position lamp light intensity obviously reduced (4.2.3 (a) (i))

Offside Rear Position lamp slightly affected by the operation of another lamp affected by indicator (4.2.3 (c))

Offside Rear Stop lamp(s) light intensity obviously reduced (4.3.3 (a) (i))

Offside sun visor loose

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Rear Brake pipe inadequately clipped or supported metal pipes tp load valve (1.1.11 (d) (i))

power steering noisey

spare wheel carrier corroded

Offside Rear brake backplate corroded and loose

Front Inner Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Rear brake backing plate excessively corroded

Offside sun visior loose replace asap

Oil leak, but not excessive (8.4.1 (a) (i))

both rear road springs are a different profile

Nearside Front Lower Macpherson strut ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Nearside Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b))

Offside Front Lower Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i))

Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b))

Offside Front Lower Macpherson strut ball joint likely to become detached (5.3.4 (a) (ii)) DANGEROUS

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Front Inner Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Nail in tyre ()

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Rear brake backing plate excessively corroded

Oil leak, but not excessive (8.4.1 (a) (i))

both rear road springs are a different profile

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Inner Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear brake backing plate heavily corroded

Oil leak, but not excessive (8.4.1 (a) (i))

Rear road springs are different

Nearside Front Lower Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Nearside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b))

Offside Driver's view of the road through the swept area of the windscreen significantly affected by an obstruction (3.1 (a) (ii))

Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Headlamp has a product on the lens so that the light output is severely reduced (4.1.4 (b))

Offside Rear Position lamp not working (4.2.1 (a) (ii))

Offside Stop lamp(s) not working (4.3.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Inner Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear brake backing plate heavily corroded

Oil leak, but not excessive (8.4.1 (a) (i))

Rear road springs are different

Driver's view Items removed from driver's view prior to test (3.1 (a) (ii))

Nearside Front Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Offside Front Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Headlamp has a product on the lens but not seriously reducing light output (4.1.4 (b))

Offside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

rear brake backing heavily corroded

rear coil springs are different sizes

Offside Driver's view of the road through the swept area of the windscreen significantly affected by an obstruction sun visor stuck down (3.1 (a) (ii))

Offside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Supplementary restraint system warning lamp indicates a fault (7.1.6 (a))

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Driver's view Items removed from driver's view prior to test (3.1 (a) (ii))

Nearside Front Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Offside Front Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Headlamp has a product on the lens but not seriously reducing light output (4.1.4 (b))

Offside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Tyre obviously under inflated (5.2.3 (l))

Oil leak, but not excessive (8.4.1 (a) (i))

rear brake backing heavily corroded

rear coil springs are different sizes

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Offside Front Inner Play in steering rack inner joint(s) ()

Offside Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Oil leak, but not excessive (8.4.1 (a) (i))

both rear springs are different sizes

osr brake backing plate heavily corroded

Central Stop lamp(s) not working (4.3.1 (a) (ii))

Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Nearside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i))

Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i))

Offside Stop lamp(s) not working (4.3.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Supplementary restraint system warning lamp indicates a fault (7.1.6 (a))

Nearside Front Outer Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) DANGEROUS

Offside Front Inner Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Offside Rear Brake pad(s) incorrectly mounted pad come loose (1.1.13 (c)) DANGEROUS

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Offside Front Inner Play in steering rack inner joint(s) ()

Offside Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Oil leak, but not excessive (8.4.1 (a) (i))

Tyre obviously under inflated (5.2.3 (l))

both rear springs are different sizes

osr brake backing plate heavily corroded

Central Exhaust mounting defective (6.1.2 (a))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Hazard warning switch inoperative (4.4.2 (a) (ii))

Offside Front Direction indicator adversely affected by the operation of another lamp illuminates with brake application (4.4.3 (b))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Offside Rear Direction indicator adversely affected by the operation of another lamp (4.4.3 (b))

Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii))

Offside Track rod end ball joint has excessive play (2.1.3 (b) (i))

Steering wheel has movement relative to the column indicating looseness (2.2.1 (a) (i))

Central Exhaust mounting defective (6.1.2 (a))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Position lamp light intensity obviously reduced (4.2.3 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Central Rear Stop lamp(s) not working High level. (4.3.1 (a) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Front seat belt slow to retract

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Oil leak ()

rear tyre pressures low

Nearside Front position lamp(s) not working (1.1.A.3b)

Nearside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Nearside Rear Brake pipe excessively corroded (3.6.B.2c)

Offside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Offside Rear position lamp(s) has less than 50% of the light sources illuminating (1.1.A.3b)

Offside Stop lamp has less than 50% of the light sources illuminating (1.2.1b)

Registration plate lamp not working (1.1.C.1d)

Nearside Front seat belt slow to retract

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Oil leak ()

rear tyre pressures low

Nearside Front seat belt slow to retract

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear position lamp(s) has light sources not illuminating, but not more than 50% (1.1.A.3b)

Centre Stop lamp not working (1.2.1b)

Front Inner Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Headlamp not working on main beam (1.7.5a)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Front seat belt slow to retract

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear position lamp(s) has light sources not illuminating, but not more than 50% (1.1.A.3b)

Nearside Front Direction indicator damaged, but still visible from a reasonable distance (1.4.A.2e)

Nearside Front Track rod end ball joint has excessive play (2.2.B.1f)

Nearside Front Direction indicator damaged, but still visible from a reasonable distance (1.4.A.2e)

Offside Front Track rod end ball joint has slight play (2.2.B.1f)

Brake pipe excessively corroded (3.6.B.2c)

Offside Front Brake hose has insufficient room to move, resulting in fouling on any part (3.6.B.4a)

Offside Front coil spring broken (2.4.C.1a)

Supplementary Restraint System warning lamp indicates a fault (5.4.2)

Offside Front Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Play in steering rack inner joint(s)

Offside Front Suspension arm has excessive play in a ball joint (2.4.G.2)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Rear Brake pad(s) wearing thin (3.5.1g)

Nearside Front Suspension arm has excessive play in a ball joint (2.4.G.2)

Rear Brake load sensing valve linkage defective and function impaired (3.6.E.3)

o/s rear outer light cover broken

o/s rear tyre tread starting to crack (slight)

Nearside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Front Track rod end ball joint has excessive play (2.2.B.1f)

Nearside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Rear Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Front Track rod end ball joint has excessive play (2.2.B.1f)

Offside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Headlamp aim too high (1.8)

Nearside front brake juddering slightly (3.7.A.2b)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Offside Headlamp aim too high (1.8)

Offside Rear Brake pad(s) wearing thin (3.5.1g)

o/s rear outer light cover broken

o/s rear tyre tread starting to crack (slight)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear fog lamp not working (1.3.2b)

Rear Brake pad(s) wearing thin (3.5.1g)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Rear Brake pad(s) wearing thin (3.5.1g)