2004 Ford Transit

Front Windscreen washer not working (3.5 (a))

Nearside Front Seat belt buckle damaged (7.1.2 (d))

Nearside Front Seat belt buckle not functioning as intended (7.1.2 (d))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis by engine x member (5.3.6 (a) (i))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis by front sub frame (5.3.6 (a) (i))

Nearside Headlamp aim too low (4.1.2 (a))

Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill by spring mount (5.3.6 (a) (i))

Nearside Rear Parking brake inoperative on one side (1.4.1 (a))

Offside Front Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis by engine x member (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis by front sub frame (5.3.6 (a) (i))

Offside Headlamp aim too low (4.1.2 (a))

Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Brakes imbalanced across an axle (1.2.1 (b) (i))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Service brake efficiency below requirements (1.2.2 (a) (i))

Nearside Rear Service brake has no recorded effort at a wheel (1.2.1 (a) (ii)) DANGEROUS

Brake pedal wearing smooth (1.1.2 (c))

Nearside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive step (5.3.6 (a) (i))

Nearside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive wing (5.3.6 (a) (i))

Nearside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Direction indicator slightly discoloured (4.4.3 (a))

Nearside Rear Suspension component mounting prescribed area is corroded but not considered excessive chassis by shocker mounts (5.3.6 (a) (i))

Nearside Rear back plate damp

Offside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive step (5.3.6 (a) (i))

Offside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive wing (5.3.6 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive chassis by shocker mounts (5.3.6 (a) (i))

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Front Front passenger door catch deteriorated so the door cannot be readily opened or closed (6.2.3 (c) (i))

Nearside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive wing (5.3.6 (a) (i))

Nearside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Nearside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Rear Direction indicator slightly discoloured (4.4.3 (a))

Nearside Rear Leaf spring has slight wear in an anchor pin and/or bush at shackle end (5.3.4 (a) (i))

Nearside side door step coroded

Offside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive wing (5.3.6 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Rear Inner wheel arch corosion

Rear Oil leak, but not excessive diff (8.4.1 (a) (i))

Brake pedal anti-slip provision worn smooth (1.1.2 (c))

Nearside Front Headlamp aim too low (4.1.2 (a))

Nearside Front Obligatory mirror missing (3.3 (a))

Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis by fuel tank mounts x2 (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis by front sub frame mount (5.3.6 (a) (i))

Offside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Registration plate lamp inoperative in the case of a single lamp or all lamps x 2 (4.7.1 (b) (ii))

Nearside Front Front passenger door catch deteriorated so the door cannot be readily opened or closed (6.2.3 (c) (i))

Nearside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive wing (5.3.6 (a) (i))

Nearside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Nearside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Rear Direction indicator slightly discoloured (4.4.3 (a))

Nearside Rear Leaf spring has slight wear in an anchor pin and/or bush at shackle end (5.3.4 (a) (i))

Nearside side door step coroded

Offside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive wing (5.3.6 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Rear Inner wheel arch corosion

Rear Oil leak, but not excessive diff (8.4.1 (a) (i))

Front Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Rear Body not fully secure out rigger (6.2.2 (a) (i))

Nearside Rear Direction indicator slightly discoloured (4.4.3 (a))

Nearside Rear Other passenger door catch deteriorated so the door cannot be readily opened or closed (6.2.3 (c) (i))

Nearside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive inner wing (5.3.6 (a) (i))

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Nearside Front Position lamp not working (4.2.1 (a) (ii))

Nearside Front Seat belt missing stalk missing (7.1.2 (a))

Offside Front Steering rack has excessive free play detected at the steering wheel (steering rack fitted) rack end (2.3 (a) (i))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Offside Stop lamp(s) not working (4.3.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Brakes imbalanced across an axle (1.2.1 (b) (i))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Rear Exhaust has a major leak of exhaust gases silencer (6.1.2 (a))

Rear Prop shaft bearing excessively worn (6.1.7 (b) (i))

Front Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Rear Body not fully secure out rigger (6.2.2 (a) (i))

Nearside Rear Direction indicator slightly discoloured (4.4.3 (a))

Nearside Rear Other passenger door catch deteriorated so the door cannot be readily opened or closed (6.2.3 (c) (i))

Nearside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive inner wing (5.3.6 (a) (i))

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Nearside Front seat belt insecure

Nearside Front seat missing

Nearside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Oil leak, but not excessive diff (8.4.1 (a) (i))

Rear Exhaust has a minor leak of exhaust gases silencer (6.1.2 (a))

Central Rear Stop lamp(s) not working (4.3.1 (a) (ii))

Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b))

Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i))

Nearside Headlamp aim not tested (4.1.2 (b))

Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Front Suspension arm pin or bush excessively worn (5.3.4 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing (5.3.6 (a) (i))

Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced (6.1.1 (c) (i))

Offside Headlamp aim too low (4.1.2 (a))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Registration plate lamp inoperative in the case of a single lamp or all lamps x2 (4.7.1 (b) (ii))

Nearside Front Wheel bearing so rough it is likely to overheat or break up (5.1.3 (b) (ii)) DANGEROUS

Nearside Front seat belt insecure

Nearside Front seat missing

Nearside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Nearside inner sill coroded

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside inner sill coroded

Oil leak, but not excessive (8.4.1 (a) (i))

Oil leak, but not excessive diff (8.4.1 (a) (i))

Rear Exhaust has a minor leak of exhaust gases silencer (6.1.2 (a))

Nearside Front Outer Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Nearside Front tyre,direction incorect

Nearside Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Track rod end ball joint has slight play (2.1.3 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Oil leak, but not excessive diff (8.4.1 (a) (i))

handbrake travel

Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b))

Horn not working (7.7 (a) (ii))

Nearside Front Bumper insecure (6.1.4 (a) (i))

Nearside Front Headlamp aim so that beam "kick up" is not visible on the screen (4.1.2 (a))

Nearside Front Headlamp not working on main beam (4.1.1 (a) (ii))

Nearside Front Position lamp not working (4.2.1 (a))

Nearside Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Offside Front Bumper insecure (6.1.4 (a) (i))

Offside Front Headlamp aim not tested (4.1.2 (b))

Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Front Position lamp not working (4.2.1 (a))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Offside Rear Service brake excessively binding (1.2.1 (f))

Offside Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Rear Brakes imbalanced across an axle (1.2.1 (b) (i))

Offside Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Front Outer Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Nearside Front tyre,direction incorect

Nearside Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Oil leak, but not excessive diff (8.4.1 (a) (i))

handbrake travel

Offside Front steering rack arm slight play

engine oil leak

Brake pipe excessively corroded both main brake pipes (3.6.B.2c)

Brake pipe excessively corroded both sides axle brake pipes (3.6.B.2c)

Front Front position lamp(s) not working both sides light not working (1.1.A.3b)

Front Inner Brake pipe excessively corroded both sides brake pipes (3.6.B.2c)

Offside Front Inner Tyre tread depth below requirements of 1.6mm edge worn (4.1.E.1)

Rear Registration plate lamp not working both not working (1.1.C.1d)

Offside Front steering rack arm slight play

engine oil leak

Front Brake pad(s) wearing thin (3.5.1g)

Rear Brake pad(s) wearing thin (3.5.1g)

Brake pipe excessively corroded o/s/f brake pipe (3.6.B.2c)

Front wheel bearing has excessive play n/s/f wheel bearing noisy and play (2.5.A.3c)

Nearside Front position lamp(s) not working (1.1.A.3b)

Rear position lamp(s) adversely affected by the operation of another lamp rear lights interacting (1.1.A.3f)

Registration plate lamp not working (1.1.C.1d)

Seat belt retracting mechanism defective 1st row middle seatbelt retracting system inop (5.2.5b)

Shock absorber has a serious fluid leak x2 rear (2.7.3)

Suspension component mounting prescribed area is excessively corroded n/s/f inner wheel arch holed (2.4.A.3)

Suspension component mounting prescribed area is excessively corroded o/s/f inner wheel arch holed (2.4.A.3)

Suspension component mounting prescribed area is severely distorted rear panel distorted (2.4.A.3)

Windscreen wiper does not clear the windscreen effectively (8.2.2)

brake pipe to o/s/r and n/s/r calipers corroded-n/s/r backing plate damp no leak visible

exhaust and mountings corroded-front brakes juddering

front discs corroded and pitted-power steering pipes corroded

inner and outter sills corroded-front to rear brake pipes corroded

n/s/f brake pipe corroded

rear doors slightly sticking-x2 rear wheel bearings slight play and noisy

rear of vehicle damaged-anti-slip rubber deteriated

rear panel corroded-wishbone bushes perished

x2 front inner arches corroded-rack play- rear panel corroded and distorted

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Front brake disc in such a condition that it is seriously weakened (3.5.1i)

Front Tyre tread depth below requirements of 1.0mm (4.1.E.2b)

Horn not loud enough to be heard by another road user (1.6.2b)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Nearside Registration plate lamp not working (1.1.C.1d)

Nearside Stop lamp not working (1.2.1b)

Offside Front Tyre tread depth below requirements of 1.0mm (4.1.E.2b)

Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

Horn not working (1.6.2a)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Rear Tyre tread depth below requirements of 1.0mm (4.1.E.2b)

Parking brake: efficiency below requirements (3.7.B.7)

Windscreen has damage to an area in excess of a 10mm circle within zone 'A' (8.3.1a)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Rear Tyre worn close to the legal limit (4.1.E.2b)

Horn not working (1.6.2a)

Nearside Front Tyre(s) incorrect because different size tyres are fitted on the same axle. (4.1.A.1a)

Nearside Front position lamp(s) not working (1.1.A.3b)

Offside Headlamp aim not tested (1.8.A.1c)

Offside Headlamp not working on dipped beam (1.7.5a)

Offside Stop lamp not working (1.2.1b)

Parking brake: efficiency below requirements (3.7.B.7)

Registration plate lamp not working (1.1.5c)

Windscreen washer provides insufficient washer liquid (8.2.3)

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Rear Tyre worn close to the legal limit (4.1.E.2b)

Nearside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Rear position lamp(s) excessively deteriorated so that it is not visible from a reasonable distance (1.1.A.3d)

Offside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

only 12 seats fitted at time of testing