2004 Ford Transit

Brake performance unable to be tested (1.2.1 (g))

Central Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Chassis Cross Member (6.1.1 (c) (i))

Engine MIL inoperative or indicates a malfunction (8.2.2.2 (g))

Front Windscreen wiper not working Both (3.4 (a))

Horn not working (7.7 (a))

Nearside Front Front passenger door cannot be opened from outside the vehicle (6.2.3 (a))

Nearside Indicator switch inoperative (4.4.2 (a) (ii))

Offside Front Body panel corroded and likely to cause injury Wing (6.2.1 (a) (i))

Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Front Inner Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting Wheel Arch (6.2.2 (d) (i))

Offside Front Outer Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting Sill Corroded (6.2.2 (d) (i))

Offside Indicator switch inoperative (4.4.2 (a) (ii))

Nearside Rear Hydraulic brake cylinder leaking and braking performance affected (1.1.16 (b) (ii)) DANGEROUS

Central Front Engine Oil Leak

Central Front Gearbox Leak

Nearside Front Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Nearside Front Wheel Arch corroded

Offside Front Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Offside Front Wheel Arch Corroded

Play in steering rack inner joint(s) ()

Supplementary restraint system warning lamp does not illuminate (7.1.6 (a))

Front Lower Oil leak, but not excessive ENGINE (8.4.1 (a) (i))

Lower Oil leak, but not excessive FROM GEARBOX (8.4.1 (a) (i))

Offside Rear Lower FROM HYDROLIC TANK

Offside Rear Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength CROSS MEMBER TO REAR SPRING HANGER (5.3.6 (a) (i))

Rear fog lamp not working (4.5.1 (a) (ii))

Supplementary restraint system warning lamp indicates a fault NO AIRBAG LIGHT (7.1.6 (a))

Nearside Front Lower Steering linkage ball joint modified such that the steering is adversely affected SPLIT PIN MISSING (2.1.3 (f) (ii)) DANGEROUS

Offside Rear Outer Tyre tread depth below requirements of 1.6mm OUTER EDGE (5.2.3 (e)) DANGEROUS

Front Lower Oil leak, but not excessive ENGINE (8.4.1 (a) (i))

Items removed from driver's view prior to test FROM MIRROR ()

Lower Oil leak, but not excessive FROM GEARBOX (8.4.1 (a) (i))

Nearside Front Headlamp aim too high (4.1.2 (a))

Offside Rear Lower FROM HYDROLIC TANK

Nearside Rear Suspension arm pin or bush worn but not resulting in excessive movement D BUSHES (5.3.4 (a) (i))

Offside Front Lower Windscreen damaged but not adversely affecting driver's view STONE CHIP ZONE A (3.2 (a) (i))

Offside Inner Vehicle structure is corroded but structural rigidity is not significantly reduced OUT RIGGER COVERD IN UNDERSEAL (6.1.1 (c) (i))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement D BUSHES (5.3.4 (a) (i))

Front Registration plate deteriorated but not likely to be misread damaged (0.1 (b))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Rear Registration plate deteriorated but not likely to be misread damaged (0.1 (b))

Windscreen wiper blade defective (3.4 (b) (i))

drivers seat worn

Front Brake disc worn, pitted or scored, but not seriously weakened Both (1.1.14 (a) (ii))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Anti-roll bar linkage damaged but not seriously weakened (5.3.3 (b) (i))

Oil leak

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Underbody/chassis and body corroded

Driver's door cannot be opened from outside the vehicle (6.2.3 (a))

Horn not working (7.7 (a) (ii))

Nearside Front Brake pipe excessively corroded (1.1.11 (c))

Nearside Track rod end ball joint has excessive play (2.1.3 (b) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Prop shaft bearing excessively worn (6.1.7 (b) (i))

Windscreen wiper does not clear the windscreen effectively Both (3.4 (b) (ii))

Offside Front Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Steering wheel has movement relative to the column such that there is a serious risk of detachment (2.2.1 (a) (ii)) DANGEROUS

Front Brake disc worn, pitted or scored, but not seriously weakened Both (1.1.14 (a) (ii))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Anti-roll bar linkage damaged but not seriously weakened (5.3.3 (b) (i))

Oil leak

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Underbody/chassis and body corroded

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Front Brakes imbalanced across an axle Axle 1 (3.7.B.5b)

Horn not working (1.6.2a)

Nearside Front position lamp(s) not working (1.1.A.3b)

Nearside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill (6.1.B.2)

Nearside Rear Anti-roll bar has excessive play in a pin/bush (2.4.G.2)

Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill in side door (6.1.B.2)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Nearside Stop lamp not working (1.2.1b)

Nearside Suspension arm has excessive play in a ball joint (2.4.G.2)

Offside Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Outer Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill (6.1.B.2)

Offside Rear Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner sill in side door (6.1.B.2)

Offside Rear position lamp(s) not working (1.1.A.3b)

Offside Stop lamp not working (1.2.1b)

Rear fog lamp not working (1.3.2b)

Service brake: efficiency below requirements (3.7.B.7)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Both inner rack joints have play

Front brake disc worn, pitted or scored, but not seriously weakened Both (3.5.1i)

Underbody and chassis slightly corroded

Driver's seat insecure (6.2.A.1)

Nearside Inner Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Sill (6.1.B.2)

Nearside Rear Anti-roll bar has excessive play in a pin/bush (2.4.G.2)

Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush (2.4.G.2)

Nearside Rear Direction indicator not working (1.4.A.2c)

Nearside Track rod end ball joint has excessive play (2.2.B.1f)

Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings Step (6.1.B.2)

Offside Rear Anti-roll bar has excessive play in a pin/bush (2.4.G.2)

Offside Rear Anti-roll bar linkage has excessive play in a pin/bush (2.4.G.2)

Both inner rack joints have play

Front brake disc worn, pitted or scored, but not seriously weakened Both (3.5.1i)

Underbody and chassis slightly corroded

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Horn not working (1.6.2a)

Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill (6.1.B.2)

Nearside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings step (6.1.B.2)

Nearside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill (6.1.B.2)

Nearside Rear position lamp(s) has less than 50% of the light sources illuminating (1.1.A.3b)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Headlamp excessively damaged so that the light output is severely reduced (1.7.5a)

Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill (6.1.B.2)

Offside Inner Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings step (6.1.B.2)

Offside Outer Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings sill (6.1.B.2)

Offside Rear Outer Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Rear position lamp(s) has less than 50% of the light sources illuminating (1.1.A.3b)

Offside Track rod end ball joint has excessive play (2.2.B.1f)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Parking brake: efficiency below requirements (3.7.C.1b)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Outer Rear Tyre worn close to the legal limit (4.1.E.1)

Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement (7.2.4b)

Horn not working (1.6.2a)

Nearside Front All position lamps not working (1.1.A.3b)

Nearside Front Upper All position lamps not working (1.1.A.3b)

Nearside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Nearside Front wheel bearing has excessive play (2.5.A.3c)

Nearside Headlamp aim too low (1.8)

Nearside Rear All position lamps not working (1.1.A.3b)

Nearside Rear Anti-roll bar linkage insecure (2.4.G.1)

Nearside Rear Brake pipe excessively corroded (3.6.B.2c)

Nearside Rear Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Offside Front All position lamps not working (1.1.A.3b)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Front Upper All position lamps not working (1.1.A.3b)

Offside Headlamp aim too low (1.8)

Offside Rear All position lamps not working (1.1.A.3b)

Offside Rear Anti-roll bar linkage insecure (2.4.G.1)

Offside Rear Brake pipe excessively corroded (3.6.B.2c)

Rear Brakes imbalanced across an axle (3.7.B.5b)

Supplementary Restraint System warning lamp indicates a fault (5.4.2)

Offside Outer Rear Tyre worn close to the legal limit (4.1.E.1)

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Engine covers fitted obscuring some components in the engine bay

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Front Track rod end ball joint has slight play (2.2.B.1f)

Nearside Rear Anti-roll bar has slight play in a ball joint (2.4.G.2)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Track rod end ball joint has slight play (2.2.B.1f)

Offside Rear Anti-roll bar has slight play in a ball joint (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Play in prop-shaft centre bearing

Under-trays fitted obscuring some underside components

Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Rear Tyre worn close to the legal limit (4.1.E.1)

Windscreen washer provides insufficient washer liquid (8.2.3)

Rear Tyre worn close to the legal limit (4.1.E.1)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Tyre worn close to the legal limit (4.1.E.1)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)