1990 Volvo 240

Front Anti-roll bar pin or bush worn but not resulting in excessive movement Nearside and Offside (5.3.4 (a) (i))

Front Lower Suspension arm corroded but not seriously weakened Nearside and Offside (5.3.3 (b) (i))

Rear Exhaust has a minor leak of exhaust gases Central & Rear joints (6.1.2 (a))

Rear Suspension arm corroded but not seriously weakened Nearside and Offside (5.3.3 (b) (i))

Rear Suspension component mounting repair covered in underseal (5.3.6 (a) (i))

Van/Commercial Tyres Fitted to Vehicle

Parking brake inoperative on one side very low on both sides (1.4.1 (a))

Service brake efficiency below requirements (1.2.2 (a) (i))

Service brake effort inadequate at a wheel all 4 wheels (1.2.1 (a) (i))

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Tyre worn close to legal limit/worn on edge all 4 tyres close to limit (5.2.3 (e))

severe scrapping noise from rear , when footbrake applied.

Nearside Front Headlamp aim projected beam image is obviously incorrect appears to be european lamps fitted (4.1.2 (c))

Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt insecure (2.1.3 (g) (ii))

Nearside Front Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a))

Nearside Rear Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i))

Nearside Rear Service brake excessively fluctuating (1.2.1 (e))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch (5.3.6 (a) (i))

Offside Front Headlamp aim projected beam image is obviously incorrect appears to be european lamps fitted (4.1.2 (c))

Offside Front Steering rack gaiter missing or no longer prevents the ingress of dirt insecure (2.1.3 (g) (ii))

Offside Front Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Offside Rear Lower Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced inner sill (6.1.1 (c) (i))

Offside Rear Rear fog lamp switch not operating in accordance with the requirements lens discolored and not showing as red (4.5.3 (a))

Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced lower outer sill (7.1.1 (a) (i))

Offside Rear Stop lamp(s) emits other than a steady red light lens discolored (4.3.3 (a) (ii))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner arch (5.3.6 (a) (i))

Hydraulic leak, but not excessive (8.4.1 (a) (i))

Nearside Front Lower Integral body structure is corroded but structural rigidity is not significantly reduced outer sill heavily corroded (6.1.1 (c) (i))

Nearside Front wiper smearing lightly

Offside Front Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Rear Position lamp incorrect colour (4.2.3 (a) (i))

Offside Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Offside Rear noise from wheel when spun

Play in steering rack inner joint(s) both sides worn and also has play inside rack too ()

Rear Brake disc worn, pitted or scored, but not seriously weakened both heavily corroded/pitted (1.1.14 (a) (ii))

fitted with incorrect size of tyres for vehicle /van tyres fitted on both axles

Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Offside Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Wheel bearing has slight play Nearside and offside axle end float (5.1.3 (a) (i))

Slight movement in steering column pinion

Oil leak, but not excessive (8.4.1 (a) (i))

Play in steering rack inner joint(s) ()

Nearside Front Position lamp not working (4.2.1 (a) (ii))

Nearside Front Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Rear Other passenger door cannot be opened from outside the vehicle (6.2.3 (a))

Offside Rear Stop lamp(s) not working (4.3.1 (a) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Play in steering rack inner joint(s) ()

Offside Rear Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Registration plate lamp does not illuminate simultaneously with the position lamps (4.7.2 (a))

Nearside Play in steering rack inner joint(s) ()

Offside Play in steering rack inner joint(s) ()

Offside Rear Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Front Brake hose slightly deteriorated offside/nearside perished (3.6.B.4d)

Offside Play in steering rack inner joint(s) ()

Offside windscreen washer not working fully

Bonnet retaining device ineffective (8.4.2)

Nearside Front Inner Track rod end ball joint has excessive play (2.2.B.1f)

Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Offside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Rear fog lamp not working (1.3.2b)

Rear fog lamp tell tale not working (1.3.1b)

Headlamp has a product on the lens but not seriously reducing light output both (1.7.5a)

unable to test under bonnet components due to bonnet not opening.

Play at nearside inner steering rack ballend.

registration plate deteriorated but not likely to be misread Front & rear. (6.3.1d)

Nearside Front Body has a projection caused by damage At lower door trim. (6.1.C.1)

Offside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Offside Windscreen washer provides insufficient washer liquid Washer jet. (8.2.3)

Play at nearside inner steering rack ballend.

registration plate deteriorated but not likely to be misread Front & rear. (6.3.1d)

Offside Headlamp deteriorated but light output not reduced (1.7.5a)

Play in steering rack inner joint(s)

Centre Exhaust system not adequately supported (7.1.1)

Nearside Headlamp excessively deteriorated so that the light output is severely reduced (1.7.5a)

Nearside Rear Direction indicator incorrect colour (1.4.A.2f)

Nearside Rear Suspension arm rubber bush bonding deteriorated resulting in excessive movement (2.4.G.2)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Rear fog lamp not working (1.3.2b)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Rear fog lamp tell tale not working (1.3.1b)

Offside Headlamp deteriorated but light output not reduced (1.7.5a)

Play in steering rack inner joint(s)

cracking on both front brake hoses

headlights on definition limit

nearside rear light lens faded

offside rear shoack absorber weeping

wear in both steering rack arms

all tyres badly cracked

deterioration on rear number plate

headlights deteriorated and output reduced

nearside rear brake pads near wear limit

offside rear shock absorber weeping

pitting on rear brake discs

stonechip in windscreen

wear in both steering rack arms

both headlights near deterioration limit beam pattern not affected

cracking on both front brake flex hoses

offside rear shock absorber weeping

stonechip in windscreen

wear in both steering rack arms

Headlamp deteriorated but light output not reduced (1.7.5a)

pitting on both rear brake discs

wear in steering rack arms

corrosion on both rear brake disc inner faces

wear in nearside steering rack arm

wear in offside front lower ball joint

both headlights close to definition limit

rear number plate fading near limit

wear in both steering rack arems

headlights reflectors near limit

n/s rack arm nearing wear limit

wear in o/s rack arm

wear in both sides of steering rack

Front Brake pad(s) wearing thin (3.5.1g)

n/s front tyre close to legal limit

o/s and n/s rear tyres close to legal limit