2004 Suzuki Carry

Headlamp aim unable to be tested (4.1.2 (b))

Headlamp not working on dipped beam switch faulty / very intermittent (4.1.1 (a) (ii))

Nearside Front Lower Suspension arm pin or bush excessively worn inner bush (5.3.4 (a) (i))

Nearside Headlamp not working on main beam (4.1.1 (a) (ii))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail (5.3.6 (a) (i))

Offside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut mounting (5.3.6 (a) (i))

Offside Headlamp not working on main beam (4.1.1 (a) (ii))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail (5.3.6 (a) (i))

Position lamp switch does not illuminate the front and rear position lamps with a single operation (4.2.2 (a))

Rear fog lamp does not face the rear (4.5.4 (a))

Nearside Front Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Nearside Front Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Nearside Front Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Inner Integral body structure is corroded but structural rigidity is not significantly reduced sill (6.1.1 (c) (i))

Nearside Front Play in steering rack inner joint(s) ()

Offside Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Offside Front Bumper mountings corroded but not likely to become detached (6.1.4 (a) (i))

Offside Front Integral body structure is corroded but structural rigidity is not significantly reduced step (6.1.1 (c) (i))

Offside Front Rear cage insecure / bolts loose

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Windscreen damaged but not adversely affecting driver's view chipped (3.2 (a) (i))

Nearside Front Headlamp lens slightly defective (4.1.1 (b) (i))

Nearside Front Vehicle structure is corroded but structural rigidity is not significantly reduced inner seal (6.1.1 (c) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge on 2mm and bold inner edge strongly advise change (5.2.3 (e))

Nearside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Offside Front Headlamp lens slightly defective (4.1.1 (b) (i))

Offside Front Vehicle structure is deformed but structural rigidity is not significantly reduced seal step hold (6.1.1 (a) (i))

Nearside Front Headlamp lens slightly defective (4.1.1 (b) (i))

Nearside Front Vehicle structure is corroded but structural rigidity is not significantly reduced inner seal (6.1.1 (c) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge on 2mm and bold inner edge strongly advise change (5.2.3 (e))

Nearside Rear Wheel bearing has slight play (5.1.3 (a) (i))

Offside Front Headlamp lens slightly defective (4.1.1 (b) (i))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Front Vehicle structure is deformed but structural rigidity is not significantly reduced seal step hold (6.1.1 (a) (i))

Offside Front Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Offside Play in steering rack inner joint(s) ()

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

reverse lights not working

Brake lever has insufficient reserve travel (1.1.2 (a))

Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))

Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))

Offside Front Shock absorbers has a serious fluid leak (5.3.2 (b))

Nearside Front Tyre has ply or cords exposed 155/80 13 (5.2.3 (d) (ii)) DANGEROUS

Offside Front Tyre worn close to legal limit/worn on edge inner very low (5.2.3 (e))

Offside Play in steering rack inner joint(s) ()

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

reverse lights not working

Front Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

O/S/F door sill corroded

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Play in steering rack inner joint(s) ()

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Central Exhaust has a major leak of exhaust gases joint (6.1.2 (a))

Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c))

Nearside Headlamp aim too low (4.1.2 (a))

Nearside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail (5.3.6 (a) (i))

Offside Headlamp aim too low (4.1.2 (a))

Offside Rear Leaf spring shackle pin or bush excessively worn (5.3.4 (a) (i))

Offside Front Macpherson strut insecure and impairing directional stability top mount corroded through (5.3.3 (a) (ii)) DANGEROUS

Oil leak, but not excessive gearbox and rear diff (8.4.1 (a) (i))

Play in steering rack inner joint(s) ()

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

corrosion to underside of vehicle within prescribed areas

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive inner wheel arch (5.3.6 (a) (i))

Offside Rear Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Play in steering rack inner joint(s) ()

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

corrosion to chassis rails

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch / door shut (5.3.6 (a) (i))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive inner wheel arch (5.3.6 (a) (i))

Offside Rear Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Play in steering rack inner joint(s) ()

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

corrosion to chassis rails

Nearside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Offside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Play in steering rack inner joint(s) ()

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

slight corrosion to chassis and sills

Nearside Front Shock absorbers has a serious fluid leak (5.3.2 (b))

Offside Rear Service brake excessively binding after operating handbrake (1.2.1 (f))

Rear Brakes imbalanced across an axle (1.2.1 (b) (i))

Nearside Front Tyre tread depth below requirements of 1.6mm 155R13 (5.2.3 (e)) DANGEROUS

Nearside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Offside Rear Leaf spring has slight wear in a shackle pin and/or bush (5.3.4 (a) (i))

Play in steering rack inner joint(s) ()

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

slight corrosion to chassis and sills

Nearside Front Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Nearside Play in steering rack inner joint(s) ()

Oil leak, but not excessive Engine and rear axle (8.4.1 (a) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced Both sides rear bumpstop supports (6.1.1 (c) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced Rear lateral cross bar/ Foglamp mount (6.1.1 (c) (i))

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Nearside Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Offside Parking brake inoperative on one side Very low effort (1.4.1 (a))

Parking brake lever has excessive movement indicating incorrect adjustment (1.1.6 (c))

Nearside Front Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Exhaust mounting defective Centre mount detatched (6.1.2 (a))

Nearside Front Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Nearside Play in steering rack inner joint(s) ()

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive Engine and rear axle (8.4.1 (a) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced Both sides rear bumpstop supports (6.1.1 (c) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced Rear lateral cross bar/ Foglamp mount (6.1.1 (c) (i))

Nearside Front Play in steering rack inner joint(s) ()

Offside Rear Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Rear Shock absorber has slight corrosion to the casing (2.7.2a)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Front Play in steering rack inner joint(s) ()

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Rear Shock absorber has slight corrosion to the casing (2.7.2a)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

chassis damaged rear bump stop areas

Driver's door hinge deteriorated but the door can still be readily opened and closed (6.2.B.2)

Play in steering rack inner joint(s)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

both seat cusions deteraited

management light on

rear chassis nearside bump stop area damaded

Nearside Rear Direction indicator not working (1.4.A.2c)

Brakes imbalanced across an axle (3.7.B.5b) DANGEROUS

Braking system leaking (3.6.A.1) DANGEROUS

Driver's door hinge deteriorated but the door can still be readily opened and closed (6.2.B.2)

Play in steering rack inner joint(s)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

both seat cusions deteraited

management light on

rear chassis nearside bump stop area damaded

Brake pedal anti-slip provision missing (3.3.A.1b)

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Steering system has excessive free play detected at the steering wheel (steering rack fitted) (2.2.A.1b)

Nearside Rear Leaf spring fractured (2.4.B.1a) DANGEROUS

Driver's door hinge deteriorated but the door can still be readily opened and closed (6.2.B.2)

Play in steering rack inner joint(s)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

both seats padding worn out

clutch pedal anti-slip missing

rear bump stopd damaged rear chassis brakets

Nearside Stop lamp not working (1.2.1b)

Offside Stop lamp not working (1.2.1b)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

both rear bump stops bump area damaged

management light on

Steering system has slight free play detected at steering wheel (2.2.A.1b)

both rear bump stops bump area damaged

management light on

Nearside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement (2.4.B.2)

Nearside Rear Leaf spring longitudinally displaced (2.4.B.1d)

Offside Front Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Offside Rear Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement (2.4.B.2)

Offside Rear Leaf spring longitudinally displaced (2.4.B.1d)

Offside rear brake recording little or no effort (3.7.B.5a)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Offside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2) DANGEROUS

Offside Rear Braking system leaking (3.6.A.1) DANGEROUS

Offside Rear Upper Body insecure and dangerous to other road users (6.1.B.1b) DANGEROUS

Rear rear brake application uneven (3.7.B.2) DANGEROUS

Nearside Front Anti-roll bar rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Front Suspension arm has excessive play in a ball joint (2.4.G.2)

Nearside Front coil spring incomplete (2.4.C.1a)

Offside Front coil spring incomplete (2.4.C.1a)

Nearside Front Anti-roll bar rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Offside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

accident damage to nearside front

Nearside Headlamp aim aimed so that it dazzles other road users (1.8.A.1a)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Front Direction indicator flashing more than 120 times a minute (1.4.A.2g)

Offside Rear Direction indicator not working (1.4.A.2c)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Offside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

accident damage to nearside front

Offside Ball joint has slight play (2.2.B.1f)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Nearside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Offside Rear Leaf spring splayed but action not impaired (2.4.B.1c)

Offside Rear Road wheel with a slightly distorted bead rim (4.2.A.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

rear brake hose ferule corroding

Nearside Front Headlamp not in good working order adversely affecting beam image (1.2.4a)

Offside Front Headlamp aim too high (1.8)

Offside Rear Parking brake recording little or no effort (3.7.D.3a)

Offside Rear rear brake binding (3.7.B.1)

Rear Registration plate lamp not working (1.1.5c)

Brakes imbalanced across an axle (3.7.B.5b) DANGEROUS