2003 Ford Transit

Brake pedal wearing smooth on edge (1.1.2 (c))

Front Brake disc worn, pitted or scored, but not seriously weakened both front brake discs inner surfaces rusting (1.1.14 (a) (ii))

Integral body structure is corroded but structural rigidity is not significantly reduced General underbody condition is quite rusty & various repairs have been made to several areas. Repair to nearside front inner wing is visually of poor quality & some rust holes to nearside centre sill area. (6.1.1 (c) (i))

Nearside Obligatory mirror slightly damaged outer casing missing - no sharp edges exposed at time of test (3.3 (b) (i))

Offside Obligatory mirror slightly damaged lower section of glass missing (3.3 (b) (i))

Offside Rear Tyre worn close to legal limit/worn on edge tread at wear marker (5.2.3 (e))

Nearside Front Outer Obligatory mirror slightly damaged (3.3 (b) (i))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Emissions not tested (8.2.1.2 (d))

Exhaust emissions likely to be affected by an exhaust leak (8.2.1.1 (b))

Nearside Fuel cap/sealing device ineffective seal split (6.1.3 (b) (i))

Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength within 30cm of rear shock absorber mounting (5.3.6 (a) (i))

Nearside Rear Position lamp lens seriously defective broken / holed /sharp edges (4.2.1 (b))

Offside Front Outer Side repeater likely to become detached (4.4.1 (c) (ii))

Offside Rear All direction indicators incorrect colour (4.4.3 (a))

Offside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis corroded within 30cm of shock absorber mounting (5.3.6 (a) (i))

Offside Rear Position lamp showing white light to the rear (4.2.3 (a) (ii))

Rear All position lamps adversely affected by the operation of another lamp both (4.2.3 (c))

Rear Exhaust has a major leak of exhaust gases and middle (6.1.2 (a))

Nearside Rear Inner Vehicle structure is so deformed it is likely to adversely affect braking or steering near load compensator brake valve mounting (6.1.1 (a) (ii)) DANGEROUS

Nearside Front Outer Obligatory mirror slightly damaged (3.3 (b) (i))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened heavily corroded Strongly advise to be replaced (1.1.14 (a) (ii))

Front Tyre worn close to legal limit/worn on edge both close to limit and badly worn on inner edges Strongly advise to be replaced (5.2.3 (e))

Nearside inner and outer sills corroded but not within any prescribed areas

Offside Rear side ,stop and fog lights slightly discoloured

Offside outer sill corroded but not within any prescribed areas

Power steering component has slight seepage from a component (2.1.5 (a))

Power steering pipe/hose slightly corroded (2.1.5 (g) (i))

parking brake lever has very little reserve travel

Central Exhaust has a major leak of exhaust gases (6.1.2 (a))

Emissions not tested due to major leak (8.2.1.2 (d))

Horn not working (7.7 (a) (ii))

Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i))

Nearside Headlamp aim too high (4.1.2 (a))

Nearside Rear Brake pipe excessively corroded axle (1.1.11 (c))

Offside Rear Service brake excessively binding (1.2.1 (f))

Offside Rear Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Rear Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) DANGEROUS

Front Brake disc worn, pitted or scored, but not seriously weakened heavily corroded Strongly advise to be replaced (1.1.14 (a) (ii))

Front Tyre worn close to legal limit/worn on edge both close to limit and badly worn on inner edges Strongly advise to be replaced (5.2.3 (e))

Nearside inner and outer sills corroded but not within any prescribed areas

Offside Rear side ,stop and fog lights slightly discoloured

Offside outer sill corroded but not within any prescribed areas

Power steering component has slight seepage from a component (2.1.5 (a))

Power steering pipe/hose slightly corroded (2.1.5 (g) (i))

parking brake lever has very little reserve travel

Both front tyres getting low on 3mm

Corrosion forming on various front and rear suspension, brake and steering components

Corrosion taking place nearside front inner wheelarch

Corrosion taking place nearside rear chassis member close to brake limiter valve

Exhaust deteriorating

Front brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

Offside Rear Rear position lamp(s) slightly discoloured (1.1.A.3e)

Offside Rear Tyre worn close to the legal limit on 2mm Strongly advise to be replaced (4.1.E.1)

Offside Rear fog lamp slightly discoloured (1.3.2e)

Offside Stop lamp slightly discoloured (1.2.1e)

Play in steering rack inner joint(s) ()

Power steering pipe(s) or hose(s) slightly corroded (2.3.2)

Surface corrosion forming and taking place at various points on chassis and underbody

Nearside Track rod end ball joint has excessive play (2.2.B.1f)

Both front tyres getting low on 3mm

Corrosion forming on various front and rear suspension, brake and steering components

Corrosion taking place nearside front inner wheelarch

Corrosion taking place nearside rear chassis member close to brake limiter valve

Exhaust deteriorating

Front brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

Offside Rear Rear position lamp(s) slightly discoloured (1.1.A.3e)

Offside Rear Tyre worn close to the legal limit on 2mm Strongly advise to be replaced (4.1.E.1)

Offside Rear fog lamp slightly discoloured (1.3.2e)

Offside Stop lamp slightly discoloured (1.2.1e)

Play in steering rack inner joint(s) ()

Power steering pipe(s) or hose(s) slightly corroded (2.3.2)

Surface corrosion forming and taking place at various points on chassis and underbody

Corrosion forming on various brake suspension and steering components

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Play in steering rack inner joint(s) ()

Nearside Track rod end ball joint has slight play (2.2.B.1f)

Power steering pipe(s) or hose(s) slightly corroded (2.3.2)

Rear Exhaust has a minor leak of exhaust gases (7.1.2)

Rear propshaft universal joint worn

Surface corrosion forming and taking place at various points on chassis and underbody

Exhaust emissions hydrocarbon content after 2nd fast idle excessive (7.3.D.3)

Horn not working (1.6.2a)

Corrosion forming on various brake suspension and steering components

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Play in steering rack inner joint(s) ()

Nearside Track rod end ball joint has slight play (2.2.B.1f)

Power steering pipe(s) or hose(s) slightly corroded (2.3.2)

Rear Exhaust has a minor leak of exhaust gases (7.1.2)

Rear propshaft universal joint worn

Surface corrosion forming and taking place at various points on chassis and underbody

Brake pipe excessively corroded all mainline (3.6.B.2c)

Offside Front Inner Suspension component mounting prescribed area is excessively corroded wheel arch (2.4.A.3)

Offside Registration plate lamp not working (1.1.C.1d)

Parking brake: efficiency below requirements (3.7.B.7)

All offside rear lights slightly discoloured

Corrosion forming on various brake, suspension and steering components

Corrosion forming on various other brake pipes

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Nearside Play in steering rack inner joint(s) ()

Nearside Track rod end ball joint has slight play (2.2.B.1f)

Power steering pipe(s) or hose(s) slightly corroded (2.3.2)

Rear Exhaust has a minor leak of exhaust gases (7.1.2)

Rear Propshaft universal joint worn ()

Surface corrosion taking place at various points on chassis and underbody some within prescribed areas

Corrosion forming on both rear chassis members.

Handbrake warning light not working.

Offside front hub-seal leaking grease.

Steering rack damp.

Brake load sensing valve linkage seized REAR (3.6.E.3)

Offside Front Front position lamp(s) not working (1.1.A.3b)

Offside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement REARMOST (2.4.G.2)

Windscreen wiper does not clear the windscreen effectively BOTH FRONT (8.2.2)

Corrosion forming on both rear chassis members.

Handbrake warning light not working.

Offside front hub-seal leaking grease.

Steering rack damp.

Both rear suspension bump stops insecure.

Offside Front Lower Suspension arm synthetic bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside rear tyre wearing on inner edge.

Slight corrosion to rear of both main chassis members.

Brake load sensing valve linkage seized (3.6.E.3)

Nearside Front Brake pipe excessively corroded (3.6.B.2c)

Nearside Front Lower Suspension arm synthetic bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Power steering pipe(s) or hose(s) leaking (2.3.3b)

rear brake binding (3.7.B.1)

Both rear suspension bump stops insecure.

Handbrake cable adjustment slack.

Offside Front Lower Suspension arm synthetic bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside rear tyre wearing on inner edge.

Parking brake lever has little reserve travel (3.1.6b)

Slight corrosion to rear of both main chassis members.

Play in steering rack inner joint(s)

Centre Rear Exhaust has a major leak of exhaust gases (7.1.2)

Front brake disc in such a condition that it is seriously weakened (3.5.1i)

Nearside Rear Brake load sensing valve seized (3.6.E.3)

Nearside Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.A.1)

Nearside Windscreen has damage to the swept area in excess of a 40mm circle outside zone 'A' (8.3.1d)

Offside Front Front wheel bearing has excessive play (2.5.A.3c)

Offside Front Power steering pump drive system defective (2.3.6)

Offside Front brake disc in such a condition that it is seriously weakened (3.5.1i)

Windscreen has damage to an area in excess of a 10mm circle within zone 'A' (8.3.1a)

Play in steering rack inner joint(s)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Rear rear brake binding (3.7.B.1)

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

front brake discs worn

nearside wing mirror

Centre Exhaust has a minor leak of exhaust gases (7.1.2)

Centre Exhaust has part of the system slightly deteriorated (7.1.1a)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

offside windscreen wiper not fitted correctly but still clears screen

Nearside Headlamp not in good working order adversely affecting beam image (1.2.4a)

Nearside Rear brake drum contaminated by brake fluid (3.5.1h)

Nearside Rear rear brake recording little or no effort (3.7.B.5a)

Nearside Rear rear parking brake recording little or no effort (3.7.B.6a)

Offside Stop lamp not working (1.2.1b)

Parking brake: efficiency below requirements (3.7.B.7)

Centre Exhaust has a minor leak of exhaust gases (7.1.2)

Centre Exhaust has part of the system slightly deteriorated (7.1.1a)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

offside windscreen wiper not fitted correctly but still clears screen

Brake load sensing valve linkage stiff (3.6.E.3)

Offside Rear rear brake grabbing slightly (3.7.A.5b)

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Exhaust emissions carbon monoxide content at idle excessive (7.3.D.4)

Nearside Headlamp insecure (1.7.3)

Nearside Headlamp not working on dipped beam (1.7.5a)

Nearside Obligatory mirror seriously damaged, affecting the rear view (8.1.2a)

Offside Stop lamp not working (1.2.1b)

nearside front and rear tyres outer side walls slight damage