1990 Volvo 240

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Rear Suspension component mounting prescribed area is corroded but not considered excessive sill end has corrosion (5.3.6 (a) (i))

Offside Front Wheel bearing has slight play (5.1.3 (a) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive sill end has corrosion (5.3.6 (a) (i))

Body component damaged and likely to cause injury Front bumper has sharp edges. (6.2.1 (a) (i))

Brake pedal has insufficient reserve travel Brake pedal has travel (1.1.2 (a))

Hazard warning lamps inoperative (4.4.1 (e))

Headlamp not working on dipped beam Headlamp relay faulty (4.1.1 (a) (ii))

Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill (7.1.1 (a) (i))

Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced cross member x 2 holes (6.1.1 (c) (i))

Offside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting chassis x 1 hole (6.2.2 (d) (i))

Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Inner sill (7.1.1 (a) (i))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Rear Suspension component mounting prescribed area is corroded but not considered excessive sill end has corrosion (5.3.6 (a) (i))

Offside Front Wheel bearing has slight play (5.1.3 (a) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive sill end has corrosion (5.3.6 (a) (i))

Brake disc worn, but not excessively n/s and o/s front (1.1.14 (a) (i))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Front Headlamp reflector slightly defective (4.1.1 (b) (i))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Offside Front Headlamp reflector slightly defective (4.1.1 (b) (i))

Offside Front Wheel bearing has slight play (5.1.3 (a) (i))

Offside Rear Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

brake pedal feels slightly spongy

n/s/r lamp unit lens slight deteriorated

Brake disc worn, but not excessively n/s and o/s front (1.1.14 (a) (i))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Front Headlamp reflector slightly defective (4.1.1 (b) (i))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Front Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Offside Front Headlamp reflector slightly defective (4.1.1 (b) (i))

Offside Front Wheel bearing has slight play (5.1.3 (a) (i))

Offside Front Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Offside Rear Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

brake pedal feels slightly spongy

n/s/r lamp unit lens slight deteriorated

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Rear Axle swivel pins and bushes swivel pin and/or bush slightly worn (5.1.2 (b) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge inner edge wear (5.2.3 (e))

Nearside Rear suspension bump stop missing

Offside Rear Axle swivel pins and bushes swivel pin and/or bush slightly worn (5.1.2 (b) (i))

Offside Rear Tyre worn close to legal limit/worn on edge close to limit on inner edge (5.2.3 (e))

Offside steering rack gaiter is perished

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

brake pedal slightly spongy

Nearside Rear Upper Suspension arm pin or bush excessively worn arm to top of axle x2 bushes (5.3.4 (a) (i))

Nearside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock mount area (5.3.6 (a) (i))

Offside Rear Position lamp light intensity significantly reduced (4.2.3 (a) (ii))

Offside Rear Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength shock mount area (5.3.6 (a) (i))

Offside Rear Tyre has a bulge, caused by separation or partial failure of its structure (5.2.3 (d) (ii)) DANGEROUS

Offside Rear Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Front Tyre worn close to legal limit/worn on edge inner edge wear (5.2.3 (e))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Headlamp aim too high (4.1.2 (a))

Nearside Rear Axle swivel pins and bushes swivel pin and/or bush slightly worn (5.1.2 (b) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge inner edge wear (5.2.3 (e))

Nearside Rear suspension bump stop missing

Offside Front Tyre worn close to legal limit/worn on edge on 2mm & edge wear (5.2.3 (e))

Offside Headlamp aim too low (4.1.2 (a))

Offside Rear Axle swivel pins and bushes swivel pin and/or bush slightly worn (5.1.2 (b) (i))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement arm to top of axle x2 bushes (5.3.4 (a) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive outer sill panel corroded and holed (5.3.6 (a) (i))

Offside steering rack gaiter is perished

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Rear fog lamp not working (4.5.1 (a) (ii))

Rear fog lamp tell-tale not working (4.9.1 (a) (ii))

brake pedal slightly spongy

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Front Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Upper Suspension component mounting prescribed area is corroded but not considered excessive shock mount (5.3.6 (a) (i))

Nearside Rear Upper Suspension rod pin or bush worn but not resulting in excessive movement axle support rod (5.3.4 (a) (i))

Nearside Rear lamp unit slightly deteriorated (lens)

Offside Front Tyre worn close to legal limit/worn on edge outer edge (5.2.3 (e))

Offside Rear Upper Suspension rod pin or bush worn but not resulting in excessive movement axle support rod (5.3.4 (a) (i))

Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt slightly perished (2.1.3 (g) (i))

centre exhaust pipe corroded and has slight blow

Battery insecure and likely to fall from carrier (4.13 (a) (ii))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Front Direction indicator not working (4.4.1 (a) (ii))

Nearside Front Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Upper Suspension component mounting prescribed area is corroded but not considered excessive shock mount (5.3.6 (a) (i))

Nearside Rear Upper Suspension rod pin or bush worn but not resulting in excessive movement axle support rod (5.3.4 (a) (i))

Nearside Rear lamp unit slightly deteriorated (lens)

Offside Front Tyre worn close to legal limit/worn on edge outer edge (5.2.3 (e))

Offside Rear Upper Suspension rod pin or bush worn but not resulting in excessive movement axle support rod (5.3.4 (a) (i))

Rear fog lamp switch inoperative (4.5.3 (a) (ii))

Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt slightly perished (2.1.3 (g) (i))

centre exhaust pipe corroded and has slight blow

Central Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Front Registration plate deteriorated but not likely to be misread (0.1 (b))

Nearside Front Brake hose slightly deteriorated (1.1.12 (b) (ii))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake hose slightly deteriorated x2 (1.1.12 (b) (ii))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Towbar slightly corroded within 30cm of towbar mounting (6.1.6 (i) (i))

all brake back plates are corroded

brake fluid slightly dis-coloured

underside in a dirty condition

windscreen wipers are slow in operation

Nearside Front Anti-roll bar pin or bush worn but not resulting in excessive movement d bush (5.3.4 (a) (i))

Nearside Front tyre has slight inner edge wear

Nearside Rear Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Anti-roll bar pin or bush worn but not resulting in excessive movement d bush (5.3.4 (a) (i))

Offside Front tyre has inner edge wear

Offside Rear Lower Suspension component mounting prescribed area is corroded but not considered excessive spring mounting on axle (5.3.6 (a) (i))

Offside Rear Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

brake fluid slightly contaminated

Central Front Stop lamp(s) not working (4.3.1 (a) (ii))

Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b))

Nearside Side repeater not working (4.4.1 (a) (ii))

Nearside Stop lamp(s) not working (4.3.1 (a) (ii))

Nearside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Offside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Nearside Front Anti-roll bar pin or bush worn but not resulting in excessive movement d bush (5.3.4 (a) (i))

Nearside Front tyre has slight inner edge wear

Nearside Rear Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Anti-roll bar pin or bush worn but not resulting in excessive movement d bush (5.3.4 (a) (i))

Offside Front tyre has inner edge wear

Offside Rear Lower Suspension component mounting prescribed area is corroded but not considered excessive spring mounting on axle (5.3.6 (a) (i))

Offside Rear Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

brake fluid slightly contaminated

Front Brake pad(s) wearing thin (3.5.1g)

Front Exhaust has a minor leak of exhaust gases pipe (7.1.2)

Rear Brake pad(s) wearing thin (3.5.1g)

Front Brake pad(s) wearing thin (3.5.1g)

Rear Brake pad(s) wearing thin (3.5.1g)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Rear Brake pipe inadequately clipped on axle (3.6.B.1)

Offside Side repeater not working (1.4.A.2c)

Rear Brake pad(s) wearing thin (3.5.1g)

Brake master cylinder/servo mounting prescribed area is corroded but not considered excessive (3.6.C.3)

Nearside rear brake fluctuating, but not excessively (3.7.B.3)

Offside rear brake fluctuating, but not excessively (3.7.B.3)

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Track rod end ball joint has excessive play (2.2.B.1f)

Brake master cylinder/servo mounting prescribed area is corroded but not considered excessive (3.6.C.3)

Nearside Headlamp aim too high (1.8)

Nearside rear brake fluctuating, but not excessively (3.7.B.3)

Offside Headlamp aim too low (1.8)

Offside rear brake fluctuating, but not excessively (3.7.B.3)

Nearside Track rod end ball joint has slight play (2.2.B.1f)

Rear Brake pad(s) wearing thin (3.5.1g)

Nearside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Centre Exhaust system not adequately supported (7.1.1)

Nearside Headlamp insecure (1.7.3)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Rear Exhaust system not adequately supported (7.1.1)

Nearside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Rear Brake pad(s) wearing thin (3.5.1g)

exhaust centre pipe corroded

Nearside Rear Lower Trailing arm rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Offside Front Track rod end ball joint has excessive play (2.2.B.1f)

Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Front wheel bearing has slight play (2.5.A.3c)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Rear Brake pad(s) wearing thin (3.5.1g)

drivers wiper blade split on end.(clears ok)

exhaust centre pipe corroded

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Headlamp deteriorated but light output not reduced (1.7.5a)

Brake pedal spongy (3.3.B.1b)

Nearside Front Brake hose bulging under pressure (3.6.B.3)

Nearside Front Brake hose leaking (3.6.A.1)

Nearside Steering rack gaiter split (2.2.D.2d)

Offside Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Front Brake hose slightly deteriorated (3.6.B.4d)

Offside Headlamp deteriorated but light output not reduced (1.7.5a)

Front Brake pad(s) wearing thin (3.5.1g)

Front Exhaust has a major leak of exhaust gases (7.1.2)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

offside rear tyre tyre is perished in sidewalls.

Nearside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Registration plate lamp not working (1.1.5c)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Registration plate lamp not working (1.1.5c)

Offside Steering rack gaiter split (2.2.D.2d)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

offside rear tyre tyre is perished in sidewalls.

Nearside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Nearside Rear Trailing arm rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Offside Rear Trailing arm rubber bush deteriorated resulting in excessive movement (2.4.G.2)

as previous test

Nearside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

note O/S/ handbrake reading low

note slight play N/S/F lower ball joint

As previous test.

Nearside Front Braking system leaking (3.6.A.1)

Offside Registration plate lamp not working (1.1.5c)

Nearside Front wheel bearing has slight play (2.5.A.3c)

Slight play in offside of steering rack.