2002 Iveco Daily

Nearside Front Upper Suspension arm ball joint has slight play (5.3.4 (a) (i))

Nearside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement both bushes on arm worn (5.3.4 (a) (i))

Nearside Front Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Offside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement both bushes worn (5.3.4 (a) (i))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Integral body structure is corroded but structural rigidity is not significantly reduced inner sill (6.1.1 (c) (i))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Windscreen washer provides insufficient washer liquid (3.5 (a))

Horn not working (7.7 (a))

Nearside Front Brake hose excessively damaged (1.1.12 (b) (ii))

Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Service brake excessively binding (1.2.1 (f))

Offside Front Service brake excessively binding (1.2.1 (f))

Nearside Integral body structure is corroded but structural rigidity is not significantly reduced inner sill (6.1.1 (c) (i))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Front Integral body structure is corroded but structural rigidity is not significantly reduced inner arch engine bay (6.1.1 (c) (i))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Integral body structure is corroded but structural rigidity is not significantly reduced inner arch engine bay (6.1.1 (c) (i))

Offside Front Service brake binding but not excessively (1.2.1 (f))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Front Integral body structure is corroded but structural rigidity is not significantly reduced inner arch engine bay (6.1.1 (c) (i))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Integral body structure is corroded but structural rigidity is not significantly reduced inner arch engine bay (6.1.1 (c) (i))

Offside Front Service brake binding but not excessively (1.2.1 (f))

Offside Rear Inner Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Nearside Front Brake hose slightly deteriorated (1.1.12 (b) (ii))

Nearside Front Wheel bearing slightly noisy (5.1.3 (b) (i))

Nearside Rear Inner Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Integral body structure or chassis corroded within 30cm of a mounting, but not seriously affecting overall security in engine bay (6.2.2 (d) (i))

Offside Rear Inner Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Nearside Front Brake hose slightly deteriorated (1.1.12 (b) (ii))

Nearside Front Wheel bearing slightly noisy (5.1.3 (b) (i))

Nearside Rear Brake pipe excessively corroded 2 pipes from compensator (1.1.11 (c))

Nearside Rear Inner Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Integral body structure or chassis corroded within 30cm of a mounting, but not seriously affecting overall security in engine bay (6.2.2 (d) (i))

Offside Rear Inner Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Offside Front Upper Suspension arm ball joint has slight play (5.3.4 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Anti-roll bar ball joint has slight play (5.3.4 (a) (i))

Nearside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i))

Offside Front Cab or chassis has excessive corrosion, seriously affecting its strength within 30cm of a cab mounting (6.2.2 (d) (i))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Offside Front Upper Suspension arm ball joint has slight play (5.3.4 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Anti-roll bar ball joint has slight play (5.3.4 (a) (i))

Anti-roll bar linkage pin or bush worn but not resulting in excessive movement all rear (5.3.4 (a) (i))

Anti-roll bar pin or bush worn but not resulting in excessive movement all rear (5.3.4 (a) (i))

Cab or chassis corroded within 30cm of a mounting, but not seriously affecting overall security both front (6.2.2 (d) (i))

Nearside Front Lower Suspension arm ball joint has slight play (5.3.4 (a) (i))

Oil leak, but not excessive engine area (8.4.1 (a) (i))

Oil leak, but not excessive rear diff (8.4.1 (a) (i))

Central Seat belt buckle not functioning as intended (7.1.2 (d))

Headlamp aim too high both (4.1.2 (a))

Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Rear Prop shaft bearing excessively worn (6.1.7 (b) (i))

Anti-roll bar linkage pin or bush worn but not resulting in excessive movement all rear (5.3.4 (a) (i))

Anti-roll bar pin or bush worn but not resulting in excessive movement all rear (5.3.4 (a) (i))

Cab or chassis corroded within 30cm of a mounting, but not seriously affecting overall security both front (6.2.2 (d) (i))

Nearside Front Lower Suspension arm ball joint has slight play (5.3.4 (a) (i))

Oil leak, but not excessive engine area (8.4.1 (a) (i))

Oil leak, but not excessive rear diff (8.4.1 (a) (i))

Anti-roll bar linkage pin or bush worn but not resulting in excessive movement ALL REAR BUSHES (5.3.4 (a) (i))

GENERAL OIL LEAKS

Integral body structure or chassis corroded within 30cm of a mounting, but not seriously affecting overall security BOTH FRONT UNDER BONNET (6.2.2 (d) (i))

Nearside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Lower Suspension arm ball joint has slight play (5.3.4 (a) (i))

Anti-roll bar has slight play in a pin/bush all rear (2.4.G.2)

Central Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Rear Inner Tyre worn close to the legal limit (4.1.E.1)

Offside Front Track rod end ball joint dust cover deteriorated, but preventing the ingress of dirt (2.2.C.1c)

Offside Rear Inner Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Outer Tyre worn close to the legal limit (4.1.E.1)

Oil leak ()

Parking brake lever has little reserve travel (3.1.6b)

Play in propshaft centre bearing ()

coolant level on min

Anti-roll bar has slight play in a pin/bush all rear (2.4.G.2)

Central Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Rear Inner Tyre worn close to the legal limit (4.1.E.1)

Offside Front Track rod end ball joint dust cover deteriorated, but preventing the ingress of dirt (2.2.C.1c)

Offside Headlamp aim too low (1.8)

Offside Rear Inner Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Outer Tyre worn close to the legal limit (4.1.E.1)

Oil leak ()

Parking brake lever has little reserve travel (3.1.6b)

Play in propshaft centre bearing ()

coolant level on min

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Nearside Rear Inner Tyre worn close to the legal limit (4.1.E.1)

Offside Lower Front suspension ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Offside Track rod end ball joint dust cover deteriorated, but preventing the ingress of dirt (2.2.C.1c)

Rear Anti-roll bar linkage rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

oil leak from engine area

rear propshaft, rearmost centre bearing worn

Nearside Rear position lamp(s) insecure light mount (1.1.A.3a)

Offside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Offside Rear position lamp(s) insecure light mount (1.1.A.3a)

Parking brake: efficiency below requirements (3.7.B.7)

rear parking brake recording little or no effort both (3.7.B.6a)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Nearside Headlamp aim too low and too far to the left. (1.8)

Nearside Rear Inner Tyre worn close to the legal limit (4.1.E.1)

Offside Lower Front suspension ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Offside Track rod end ball joint dust cover deteriorated, but preventing the ingress of dirt (2.2.C.1c)

Rear Anti-roll bar linkage rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Upper Power steering pipe(s) or hose(s) slightly damaged slightly kinked (2.3.2)

oil leak from engine area

rear propshaft, rearmost centre bearing worn

Battery secure but clamp poor

Nearside Front Brake hose slightly deteriorated (3.6.B.4d)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Front Brake hose slightly deteriorated (3.6.B.4d)

Offside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Oil leak (various)

Rear Anti-roll bar linkage rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Battery secure but clamp poor

Nearside Front Brake hose slightly deteriorated (3.6.B.4d)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Front Brake hose slightly deteriorated (3.6.B.4d)

Offside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Oil leak (various)

Rear Anti-roll bar linkage rubber mounting deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Rear Anti-roll bar has slight play in a pin/bush (2.4.G.2)

Offside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Offside Rear Anti-roll bar has slight play in a pin/bush (2.4.G.2)

Oil leak

battery mounting has a temp repair

Front registration plate deteriorated but not likely to be misread (6.3.1d)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

front tyres wearing on edges

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Nearside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

n/s/r mud wing damged

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

park brake long attention soon

Offside front brake binding (3.7.B.1)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

park brake long attention soon

Nearside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

rear bump stop missing

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Oil leak

Small bind offside front brake attention soon. †Fuel tank strap repair , attention required.

Nearside Front Road wheel slightly damaged (4.2.A.1a)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Nearside Rear Leaf spring has a slightly deteriorated anchor pin rubber bush not resulting in excessive movement (2.4.B.2)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Front suspension has slight play in a upper suspension ball joint (2.5.B.1a)

Offside Rear Leaf spring has a slightly deteriorated anchor pin rubber bush not resulting in excessive movement (2.4.B.2)

fuel tank stained no active leak

no rear tyre valve extension retaining brackets

offside front body mount cracked

offside outer tyre, inner sidewall slightly damaged

Nearside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement (2.4.B.2)

Offside Rear Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement (2.4.B.2)

Fuel pipe leaking (7.2.3) DANGEROUS

Nearside Front Road wheel slightly damaged (4.2.A.1a)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Nearside Front suspension has slight play in a upper suspension ball joint (2.5.B.1a)

Nearside Rear Leaf spring has a slightly deteriorated anchor pin rubber bush not resulting in excessive movement (2.4.B.2)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Rear Leaf spring has a slightly deteriorated anchor pin rubber bush not resulting in excessive movement (2.4.B.2)

front body mount bracket cracked

fuel tank stained no active leak

nearside rear tyre under inflated

no rear tyre valve extension retaining brackets

offside ouer tyre inner sidewall slightly damages