2009 Iveco Daily

Central Front Seat belt anchorage prescribed area strength or continuity significantly reduced cab floor next to park brake lever excess corrosion, ALL WELDS MUST BE FULLY SEAMM WELDED (7.1.1 (a) (i))

Central Front Sub-frame corroded and seriously weakened excess corrosion, n/s/f where the lower wishbone bolts to it, MUST BE REPLACED AS A FULL UNIT, (5.3.3 (b) (i))

Nearside Front Upper Position lamp not working (4.2.1 (a) (ii))

Offside Front Bumper damaged and likely to cause injury when grazed or contacted bumper split (6.1.4 (a) (i))

Offside Front Inner Seat belt anchorage prescribed area is inadequately repaired inner sill at rear end has been repaired using steel plate and fibreglass resin, (7.1.1 (a) (i))

Offside Front Inner Seat belt anchorage prescribed area strength or continuity significantly reduced inner cab step/inner sill excess corrosion, ALL WELDS MUST BE FULLY SEAM WELDED, (7.1.1 (a) (i))

Offside Front Outer Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill/cab step, excess corrosion, ALL WELDS MUST BE FULLY SEAM WELDED, (7.1.1 (a) (i))

Offside Front Shock absorbers has a serious fluid leak (5.3.2 (b))

Offside Rear Rear fog lamp not working (4.5.1 (a) (ii))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Brake hose has slight corrosion to ferrule ALL hoses have some rust (1.1.12 (f) (i))

Front Suspension arm corroded but not seriously weakened BOTH upper and lower wishbones both sides are rusty, (5.3.3 (b) (i))

Oil leak, but not excessive rear differential oil seal moist with oil (8.4.1 (a) (i))

Passenger seat(s) missing at time of test FULL SEAT AND BASE REMOVED, ()

Front doorsteps heavily undersealed.

General underside corrosion

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear shock absorber casing corroded.

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear shock absorber casing corroded.

Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii))

Front doorsteps heavily undersealed.

General underside corrosion

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear shock absorber casing corroded.

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear shock absorber casing corroded.

Nearside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i))

Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced (7.1.1 (a) (i))

Offside Front Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting (6.2.2 (d) (i))

Nearside Front Brake hose ferrule excessively corroded and likely to fail (1.1.12 (f) (ii)) DANGEROUS

Front door steps underside heavily undersealed

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Brake pedal wearing smooth (1.1.2 (c))

Front Cab or chassis corroded within 30cm of a mounting, but not seriously affecting overall security Bonnet (6.2.2 (d) (i))

Front Exhaust mounting defective (6.1.2 (a))

Heavily undersealed

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Lower Sub-frame ball joint has slight play (5.3.4 (a) (i))

Nearside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Shock absorbers has light misting of oil (5.3.2 (b))

Rear Fluid leak, but not excessive Gearbox (8.4.1 (a) (i))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Offside Front Headlamp aim too low (4.1.2 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Brake pedal wearing smooth (1.1.2 (c))

Front Cab or chassis corroded within 30cm of a mounting, but not seriously affecting overall security Bonnet (6.2.2 (d) (i))

Front Exhaust mounting defective (6.1.2 (a))

Heavily undersealed

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Lower Sub-frame ball joint has slight play (5.3.4 (a) (i))

Nearside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Shock absorbers has light misting of oil (5.3.2 (b))

Rear Fluid leak, but not excessive Gearbox (8.4.1 (a) (i))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

All brake back plate corroded or missing

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Brake pedal wearing smooth (1.1.2 (c))

Front Exhaust mounting defective (6.1.2 (a))

Hazard warning switch faulty Working but button broken (4.4.2 (a) (i))

Nearside Front Lower Sub-frame ball joint has slight play (5.3.4 (a) (i))

Nearside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Lower Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Lower Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Oil leak, but not excessive Rear of transmission (8.4.1 (a) (i))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Top of fuel tank damp

Horn not working (7.7 (a) (ii))

Nearside Rear Parking brake inoperative on one side (1.4.1 (a))

Offside Rear Outline marker lamp does not illuminate simultaneously with the position lamps (4.2.2 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

All brake back plate corroded or missing

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Brake pedal wearing smooth (1.1.2 (c))

Front Exhaust mounting defective (6.1.2 (a))

Hazard warning switch faulty Working but button broken (4.4.2 (a) (i))

Nearside Front Lower Sub-frame ball joint has slight play (5.3.4 (a) (i))

Nearside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Lower Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Reverse light inop.

Offside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Lower Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Oil leak, but not excessive Rear of transmission (8.4.1 (a) (i))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Top of fuel tank damp

Nearside Rear Inner Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear brake disc backplate missing

Offside Rear Inner Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Fuel tank leaking (6.1.3 (b) (i))

Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Rear Inner Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear brake disc backplate missing

Offside Rear Inner Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear brake gripping slightly

Nearside front brake fluctuating, but not excessively (3.7.B.3)

Nearside rear brake fluctuating, but not excessively (3.7.B.3)

Offside Front Shock absorber has a light misting of oil (2.7.3)

Offside front brake fluctuating, but not excessively (3.7.B.3)

Offside rear brake fluctuating, but not excessively (3.7.B.3)

Nearside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2)

Nearside Front Upper Suspension arm has excessive play in a ball joint (2.4.G.2)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Nearside front brake fluctuating, but not excessively (3.7.B.3)

Nearside rear brake fluctuating, but not excessively (3.7.B.3)

Offside Front Shock absorber has a light misting of oil (2.7.3)

Offside front brake fluctuating, but not excessively (3.7.B.3)

Offside rear brake fluctuating, but not excessively (3.7.B.3)

Front Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

clutch master cylinder reservoir cap missing

Front Suspension spring mounting prescribed area is excessively corroded cross member (2.4.A.3)

Horn not working (1.6.2a)

Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Nearside Headlamp insecure (1.7.3)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Nearside Side repeater incorrect colour (1.4.A.2f)

Offside Front Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Front Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

clutch master cylinder reservoir cap missing

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Front Headlamp aim beam image obviously incorrect (1.8.A.1b)

Nearside Rear Direction indicators incorrect colour showing white (1.4.A.2f)

Nearside Rear Rear position lamp(s) adversely affected by the operation of another lamp (1.1.A.3f)

Nearside Rear Rear position lamp(s) not working (1.1.A.3b)

Nearside Stop lamp not working (1.2.1b)

Offside Front Headlamp aim beam image obviously incorrect (1.8.A.1b)

Offside Rear Direction indicators incorrect colour showing white (1.4.A.2f)

Offside Stop lamp not working (1.2.1b)

Registration plate lamp not working (1.1.C.1d)

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Rear side marker light inoperative ana affected by another light (indicator)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Bonnet safety catch seized and not operating !!

Front Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Front Upper Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Front Upper Suspension arm has slight play in a ball joint (2.4.G.2)

Brake cable insecure (3.5.1d)

Nearside rear parking brake recording little or no effort (3.7.B.6a)

Rear Anti-roll bar attachment bracket/mounting insecure (2.4.G.1)

Rear Electrical wiring insecure (1.9.2a)

Bonnet safety catch seized and not operating !!

Front Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Front Upper Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Front Upper Suspension arm has slight play in a ball joint (2.4.G.2)

Rear Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)