2003 Iveco Daily

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Fuel filler pipe damp

Nearside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Front Shock absorbers has light misting of oil (5.3.2 (b))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Front Upper Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Shock absorbers has light misting of oil (5.3.2 (b))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear leaf spring bushes slightly worn

Reversing lights not working

Some body mountings corroded/broken away. Body still secure

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Suspension component mounting prescribed area is corroded but not considered excessive Rear upper shock mounting (5.3.6 (a) (i))

Nearside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Rear Road wheel slightly distorted (5.2.2 (c) (i))

Offside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Power steering component has slight seepage from a component (2.1.5 (a))

Rear Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Rear leaf spring bushes worn

Reversing lights not working

Some body mountings corroded/broken away. Body still secure

Fuel filler pipe/tank slightly damp

Nearside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Rear Inner Road wheel slightly distorted (5.2.2 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Power steering component has slight seepage from a component (2.1.5 (a))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Rear offside tyre worn close to wear markers

Reversing lights not working

Some bed securing clamps corroded and broken away

Brake valve leaking Rear load valve (1.1.7 (d) (i))

Front Brake hose excessively deteriorated Both sides (1.1.12 (b) (ii))

Front Position lamp not working Both (4.2.1 (a) (ii))

Headlamp aim projected beam image is obviously incorrect Both (4.1.2 (c))

Seat belt anchorage prescribed area strength or continuity significantly reduced Cab (7.1.1 (a) (i))

Suspension arm ball joint excessively worn Both front, upper ball joints (5.3.4 (a) (i))

Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength Rear offside leaf spring mounting (5.3.6 (a) (i))

Front Brake pipe corroded, covered in grease or other material Both sides *Borderline pass* (1.1.11 (c))

Fuel filler pipe/tank slightly damp

Nearside Front Lower Suspension arm ball joint has slight play (5.3.4 (a) (i))

Nearside Front Service brake binding but not excessively And pads worn low (1.2.1 (f))

Nearside Rear Inner Road wheel slightly distorted (5.2.2 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Power steering component has slight seepage from a component (2.1.5 (a))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Rear offside tyre worn close to wear markers

Reversing lights not working

Some bed securing clamps corroded and broken away

Nearside Front Inner Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Front Inner Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Front Inner Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Inner Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Front Upper Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Front Exhaust has a major leak of exhaust gases (6.1.2 (a))

Headlamp aim not tested (4.1.2 (b))

Nearside Front Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii))

Nearside Front Road wheel badly distorted (5.2.2 (c) (i))

Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Front Upper Suspension arm pin or bush excessively worn (5.3.4 (a) (i))

Offside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Headlamp not working on main beam (4.1.1 (a) (ii))

Offside Rear Direction indicator lens defective such that the emitted light is adversely affected (4.4.1 (b) (ii))

Offside Rear Position lamp not working (4.2.1 (a) (ii))

Offside Seat belt buckle missing (7.1.2 (d))

Offside Stop lamp(s) not working (4.3.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Service brake lagging in operation (1.2.1 (d))

Offside Rear Wheel bearing play so excessive it is likely to break up (5.1.3 (a) (ii)) DANGEROUS

Brake warning device malfunctioning or defective (1.1.4 (a) (i))

Nearside Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Front Direction indicator lens defective which has no effect on emitted light (4.4.1 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Direction indicator lens defective which has no effect on emitted light (4.4.1 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Nearside Front tyre has damage to sidewall

Nearside Lower Front suspension ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Lower Front suspension ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Offside Rear Outer Tyre worn close to the legal limit 3mm (4.1.E.1)

Oil leak

corrosion on bonnet

front brake fluctuating, but not excessively (3.7.B.3)

Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Nearside Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Offside Upper Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Nearside Front tyre has damage to sidewall

Nearside Lower Front suspension ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Offside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Lower Front suspension ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Offside Rear Outer Tyre worn close to the legal limit 3mm (4.1.E.1)

Oil leak

corrosion on bonnet

front brake fluctuating, but not excessively (3.7.B.3)

Front Front suspension ball joint dust cover deteriorated, but preventing the ingress of dirt upper / lower both sides (2.4.G.2)

Nearside Front tyre has side wall damage

Offside Front Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Rear Outer tyre on 3 mm

corrosion behind air box unable to inspect

corrosion to bonnet

oil leak

Parking brake: efficiency below requirements (3.7.B.7)

Front Front suspension ball joint dust cover deteriorated, but preventing the ingress of dirt upper / lower both sides (2.4.G.2)

Nearside Front tyre has side wall damage

Offside Front Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Rear Outer tyre on 3 mm

corrosion behind air box unable to inspect

corrosion to bonnet

oil leak

Front Front suspension has slight play in a lower suspension ball joint both (2.5.B.1a)

Offside Rear Inner tyre on 3 mm

corrosion behind air box unable to inspect

oil leak

Offside Headlamp aim too low (1.8)

Offside Registration plate lamp not working (1.1.C.1d)

Tow ball/hitch not fitted at time of test

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

both front lower suspension arms corroding

previous repairs,underseal and paint

underbody corrosion

Front front brake application uneven (3.7.B.2)

Offside Headlamp aim too low (1.8)

Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Offside front brake binding (3.7.B.1)

Parking brake: efficiency below requirements (3.7.B.7)

Service brake: efficiency below requirements (3.7.B.7)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Front Upper Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Upper Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak

Tow ball/hitch not fitted at time of test

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

both front lower suspension arms corroding

nearside front tyre sidewall damaged

nearside rear outer tyre cracking

previous repairs,underseal and paint

underbody corrosion

Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Offside Front Brake master cylinder/servo mounting prescribed area is excessively corroded (3.6.C.3)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Headlamp aim too low (1.8)

Offside Headlamp aim too low and too far to the left. (1.8)

Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Offside front brake binding (3.7.B.1)

Parking brake: efficiency below requirements (3.7.B.7)

Service brake: efficiency below requirements (3.7.B.7)

front brake application uneven (3.7.B.2)

Nearside Front Upper Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Front Upper Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak

Tow ball/hitch not fitted at time of test

all side marker lights not working

both front brake discs deteriorated

centre sidemarker lights insecure

nearside front tyre sidewall damaged

nearside rear outer tyre cracking

underbody corrosion

vehicle leans to nearside

Warning lamp on dash

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

engine oily

exhaust has slight corrosion

front discs slightly corroded

n/s/f tyre worn on sidewall

n/s/r tyre worn on sidewall

rear diff oily

slight damage to o/s/r inner rim

vehicle sits slightly to the left

Offside Inner Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Warning lamp on dash

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

engine oily

exhaust has slight corrosion

front discs slightly corroded

n/s/f tyre worn on sidewall

n/s/r tyre worn on sidewall

rear diff oily

slight damage to o/s/r inner rim

vehicle sits slightly to the left

Brakes imbalanced across an axle (3.7.B.5b)

Nearside Headlamp not working on dipped beam (1.7.5a)

Nearside Rear Direction indicator incorrect colour (1.4.A.2f)

Nearside Rear position lamp(s) does not face the rear (1.1.A.3a)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Offside Outer Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Rear Brake pipe excessively corroded (3.6.B.2c)

Offside Registration plate lamp not working (1.1.C.1d)

Parking brake: efficiency below requirements (3.7.B.7)

Parking brake lever has little reserve travel (3.1.6b)

side maeker lights not working offside and nearside

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Oil leak

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

bonnet catch stiff (attention required)

brake warning light on dash

front to rear brake pipe greased and coroding (attention required)

fuel tank stained

nearside front position lamp slightly impaired

nearside marker light insecure

offside outer tyre close to limit and cracking (attention required)

slight bind,offside front brake

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

brake warning light on

front to rear brake pipe greased

fuel tank stained

screw in nearside front tyre on outer edge

slight bind,offside front brake

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

slight lift to nearside and offside lower ball joints

Braking system leaking (3.6.A.1)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

slight lift in nearside front lower ball joint

slight lift in offside front lower ball joint

Nearside Front Tyre(s) is inadequate for the vehicles maximum permitted laden weight due to an incorrect load index (4.1.B.1b)

Offside Front Tyre(s) is inadequate for the vehicles maximum permitted laden weight due to an incorrect load index (4.1.B.1b)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Front Front suspension has slight play in a upper suspension ball joint (2.5.B.1a)

both front tyres wearing on edges

nearside rear tyre outer sidewall damaged not revealing cords

tailboard damaged

Nearside Rear position lamp(s) excessively deteriorated so that it is not visible from a reasonable distance (1.1.A.3d)

Nearside Rear position lamp(s) incomplete (1.1.4a)

Nearside Rear position lamp(s) incorrect colour (1.1.A.3e)

Offside Headlamp not in good working order adversely affecting beam image (1.2.4a)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake lever has no reserve travel (3.1.6b)

Registration plate lamp not working (1.1.5c)

Windscreen has damage to the swept area in excess of a 40mm circle outside zone 'A' (8.3.1d)

front brake application uneven (3.7.B.2)

Brakes imbalanced across an axle (3.7.B.5b) DANGEROUS

Parking brake: efficiency below requirements (3.7.B.7) DANGEROUS

Brake master cylinder fluid close to minimum level (3.6.G.1e)

Front Brake pad(s) wearing thin (3.5.1g)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Front suspension has slight play in a upper suspension ball joint (2.5.B.1a)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

front tyres wearing on edges

front wiring loom rubbed though by propshaft

nearside rear tyre has sidewall damage, not revealing cords

offside rear side marker light missing

tail board damaged