2003 Iveco Daily

Offside Rear Position lamp slightly affected by the operation of another lamp (4.2.3 (c))

underside of vehicle corroded but not excessive

Nearside Front Brake hose excessively deteriorated (1.1.12 (b) (ii))

Nearside Front Outer Seat belt buckle not functioning as intended (7.1.2 (d))

Brake fluid warning lamp illuminated (1.1.10 (f))

Offside Rear Anti-roll bar attachment bracket/mounting insecure (5.3.3 (a) (i))

Offside Rear Position lamp slightly affected by the operation of another lamp (4.2.3 (c))

underside of vehicle corroded but not excessive

Front cab mounts worn

clutch pedal rubber missing.

Front cab mounts worn

Fuel system component leaking TANK HOSE (6.1.3 (b) (i))

clutch pedal rubber missing.

Nearside Rear Leaf spring shackle pin or bush excessively worn rear top and bottom bushes (5.3.4 (a) (i))

Offside Rear Leaf spring shackle pin or bush excessively worn rear top and bottom bushes (5.3.4 (a) (i))

Rear Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Clutch pedal rubber missing.

Front cab mounts worn near limit.

Lower arm bushes perished.

Nearside Rear Fog light n/w

Brake pad(s) worn down to wear indicator (1.1.13 (a) (i))

Central Seat belt buckle missing Stalk missing (7.1.2 (d))

Exhaust has a major leak of exhaust gases (6.1.2 (a))

Nearside Brake pipe excessively corroded (1.1.11 (c))

Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Nearside Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) DANGEROUS

Nearside Rear Tyre has ply or cords exposed (5.2.3 (d) (ii)) DANGEROUS

Clutch pedal rubber missing

Lower arm bushes perished

N/S/R fog light n/w

Brake pipe excessively corroded pipe across front sub frame (1.1.11 (c))

Exhaust has a major leak of exhaust gases blowing before silencer box. (6.1.2 (a))

Headlamp insecure lower nut loose (4.1.1 (c))

Nearside Front Position lamp not working side light n/w (4.2.1 (a) (ii))

Nearside Front Seat belt buckle not functioning as intended not locking in to stalk. (7.1.2 (d))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rust hole within 30cm of rear cab mount. (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rust hole within 30cm of front /rear spring (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rust hole within 30cm of rear spring hanger. (5.3.6 (a) (i))

Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rust hole within 30cm of rear cab mount. (5.3.6 (a) (i))

Offside Rear Anti-roll bar attachment bracket/mounting corroded and seriously weakened rusted away from chassis (5.3.3 (b) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rust hole within 30cm of front/rear spring (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength rust hole within 30cm of rear spring hanger (5.3.6 (a) (i))

Offside Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords perished (5.2.3 (d) (i))

Registration plate lamp inoperative in the case of a single lamp or all lamps both lamps (4.7.1 (b) (ii))

Brake load sensing valve seized and ABS not fitted or inoperative (1.1.17 (c) (ii)) DANGEROUS

Nearside Front Upper Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) DANGEROUS

Brake fluid close to minimum mark (1.1.10 (d) (ii))

Brake fluid warning lamp illuminated (1.1.10 (f))

brake pedal rubber worn on edge.

clutch pedal rubber missing.

front suspension arm bushes worn perished split but no play.

fuel tank damp.

n/s/r bump stop missing.

n/s/r fog light n/w

n/s/r tyre perished.

no rev,s lights

wiper blades starting to split.

Chassis brake pipes rusty.

Offside Rear Stop lamp slightly affected by the operation of another lamp (1.2.1f)

Rust hole o/s/under sill.

Nearside Front Headlamp not working on main beam (1.7.5a)

Nearside Rear Inner Anti-roll bar linkage has excessive play in a pin/bush (2.4.G.2)

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Offside Rear Stop lamp slightly affected by the operation of another lamp (1.2.1f)

Anti-roll bar attachment bracket/mounting corroded but its strength is not seriously reduced both rear (2.4.G.1)

Vehicle structure has slight corrosion (6.1.A.1)

clutch pedal rubber missing

general suspension corrosion

outriggers corroded

Exhaust has a major leak of exhaust gases to front silencer (7.1.2)

Parking brake: efficiency below requirements (3.7.B.7)

Service brake: efficiency below requirements (3.7.B.7)

front brake application uneven (3.7.B.2)

Anti-roll bar attachment bracket/mounting corroded but its strength is not seriously reduced both rear (2.4.G.1)

Vehicle structure has slight corrosion (6.1.A.1)

clutch pedal rubber missing

general suspension corrosion

outriggers corroded

Driver's seat fore and aft adjustment mechanism not functioning as intended. (6.2.A.3)

Exhaust has a major leak of exhaust gases (7.1.2)

Fuel cap/sealing device does not fasten securely by positive means (7.2.4b)

Nearside Headlamp not working on main beam (1.7.5a)

Nearside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Nearside Rear Leaf spring has excessive wear in an anchor pin and/or bush (2.4.B.2)

Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Offside Rear Leaf spring has excessive wear in an anchor pin and/or bush (2.4.B.2)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside front tyre inner edge worn

Nearside rear suspension bump stop missing

Nearside windscreen wiper blade deteriorated

Parking brake efficiency on just met

Service brake efficiency only just met

Clutch pedal anti-slip missing

Front brakes slightly binding

Nearside rear suspension bump stop missing

Offside park brake low performance

Brake pipe excessively corroded (3.6.B.2c)

Driver's seat fore and aft adjustment mechanism not functioning as intended. (6.2.A.3)

Front Exhaust has a major leak of exhaust gases (7.1.2)

Nearside Rear Brake pipe excessively corroded (3.6.B.2c)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Rear Brake pipe excessively corroded (3.6.B.2c)

Parking brake: efficiency below requirements (3.7.B.7)

Clutch pedal anti-slip missing

Front brakes slightly binding

Nearside rear suspension bump stop missing

Offside park brake low performance

Exhaust rusty

Both rear tyres and O/S/F tyre getting low on tread

Front inner b/pads appear low and nearing limits of wear

Front to rear metal b/pipes and O/S/F pipe all getting abit corroded in places

Slight wear at front b/discs

Brakes imbalanced across an axle (3.7.D.2c)

Parking brake: efficiency below requirements (3.7.D.4)

Nearside Rear rear brake recording little or no effort (3.7.B.5a) DANGEROUS

Both rear tyres and O/S/F tyre getting low on tread

Exhaust rusty

Front inner b/pads appear low and nearing limits of wear

Front to rear metal b/pipes and O/S/F pipe all getting abit corroded in places

Slight wear at front b/discs

Front and rear suspension and brake components getting abit corroded (esp O/S/F top suspension arm)

Front to rear metal b/pipes at rear areas, getting abit corroded in places

P/Brake efficiency starting to get abit low

Rear b/pipes getting abit corroded in places

Rear chassis and crosssmember areas getting abit corroded, and body mounts

Brakes imbalanced across an axle (3.7.D.2c)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Registration plate lamp not working (1.1.C.1d)

Parking brake: efficiency below requirements (3.7.D.4)

B/Fluid level appears abit low

Brake warning light at dash stays ON

Front and rear suspension and brake components starting to get abit corroded

Front to rear metal b/pipe at N/S/R area getting abit corroded and O/S/F pipe at inner w/arch also abit corroded

Metal b/pipe at O/S/R abit corroded in places

N/S/R light lens abit cracked

Offside Front Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Offside Rear Direction indicator incorrect colour (1.4.A.2f)

brake performance at lower end of pass values

Nearside Registration plate lamp not working (1.1.5c)

Offside Registration plate lamp not working (1.1.5c)

Front to rear chassis and crossmember areas getting abit corroded

O/S/R indicator abit faded

P/Brake efficiency low at 17 % (16% = MIN limit)

Rear tyres getting abit low on tread

rear upper leaf spring shackle bushes now showing wear , where new lower bushes have been fitted allround changing position of springs . bump stops are running at close tolerance this added wear/general suspension weakening with age will effect this

Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement (2.4.B.2)

Leaf spring has a deteriorated shackle pin rubber bush resulting in excessive movement (2.4.B.2)

Rear Registration plate lamp not working (1.1.5c)

Rear Suspension has inadequate clearance with the bump stop (2.4.A.1a)

Registration plate lamp not working (1.1.5c)

wiper blade rubbers splitting at ends

Appears to be very slight wear and movement starting at N/S/F top ball joint

Brake light at dash stays ON

Rear inner b/pads appear to be getting low

Nearside Windscreen wiper blade deteriorated (8.2.2)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Registration plate lamp not working (1.1.5c)

Nearside Windscreen wiper blade deteriorated (8.2.2)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Registration plate lamp not working (1.1.5c)

Windscreen has damage to the swept area in excess of a 40mm circle outside zone 'A' (8.3.1d)

Fuel tank abit damp(No actual fuel leaking at time of test)

Rear tyres abit low on tread(Esp O/S/R,nearly ON tread limit at centre area)