1992 Saab 900

Front and rear suspension components corroded

Integral body structure is corroded but structural rigidity is not significantly reduced complete - heavily undersealed (6.1.1 (c) (i))

Nearside Front Brake disc worn, but not excessively (1.1.14 (a) (i))

Nearside Front Suspension arm corroded but not seriously weakened upper and lower (5.3.3 (b) (i))

Nearside Front Wheel bearing slightly noisy borderline (5.1.3 (b) (i))

Nearside Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Nearside Headlamp reflector slightly defective (4.1.1 (b) (i))

Nearside Rear Brake disc worn, but not excessively (1.1.14 (a) (i))

Nearside Rear Position lamp slightly affected by the operation of another lamp (4.2.3 (c))

Offside Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Offside Headlamp reflector slightly defective (4.1.1 (b) (i))

Offside Suspension arm corroded but not seriously weakened upper and lower (5.3.3 (b) (i))

Steering components corroded

Vehicle structure is corroded but structural rigidity is not significantly reduced complete - heavily undersealed (6.1.1 (c) (i))

Battery insecure and likely to fall from carrier due to excessive corrosion (4.13 (a) (ii))

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing at floor (5.3.6 (a) (i))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis at tunnel area in 2 places (5.3.6 (a) (i))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jack point in 2 places (5.3.6 (a) (i))

Nearside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing at spring (5.3.6 (a) (i))

Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i))

Nearside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Nearside Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b))

Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing (5.3.6 (a) (i))

Nearside Rear Outer Suspension component mounting prescribed area excessively corroded significantly reducing structural strength sill (5.3.6 (a) (i))

Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing at front (5.3.6 (a) (i))

Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced battery tray area (6.1.1 (c) (i))

Offside Front Lower Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis at rear of wishbone bolts (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing at rear section (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength main chassis at wishbone mount front bolts (5.3.6 (a) (i))

Offside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner wing at spring (5.3.6 (a) (i))

Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Offside Headlamp has a product on the light source so that the light output is severely reduced (4.1.4 (b))

Offside Rear Brake lever has restricted free movement on caliper (1.1.15 (e))

Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing at front (5.3.6 (a) (i))

Offside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing at rear suspension mount (5.3.6 (a) (i))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor at wishbone front mount (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jack point (5.3.6 (a) (i))

Offside Side repeater not working (4.4.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Corrosion of all front and rear suspension components

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Suspension arm corroded but not seriously weakened upper and lower (5.3.3 (b) (i))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Position lamp slightly affected by the operation of another lamp (4.2.3 (c))

Offside Front Suspension arm corroded but not seriously weakened upper and lower (5.3.3 (b) (i))

Steering components all corroded

Extensive welding to underside front to rear

Front Lower Suspension arm corroded but not seriously weakened both sides (5.3.3 (b) (i))

Offside Rear Brake hose has slight corrosion to ferrule borderline (1.1.12 (f) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Central Exhaust system insecure support missing (6.1.2 (a))

Emissions unable to be completed due to major exhaust leak (8.2.1.2 (d))

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Front Exhaust has a major leak of exhaust gases (6.1.2 (a))

Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wheel arch (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor 2 places (5.3.6 (a) (i))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Front Lower Suspension arm corroded but not seriously weakened both sides (5.3.3 (b) (i))

Offside Rear Brake hose has slight corrosion to ferrule borderline (1.1.12 (f) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Corrosion of all steering and suspension components

Front Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Integral body structure is corroded but structural rigidity is not significantly reduced front to rear of underside (6.1.1 (c) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Rear Upper Shock absorbers has a slightly worn bush both sides (5.3.2 (c))

Emissions unable to be completed rear section missing (8.2.1.2 (d))

Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing (5.3.6 (a) (i))

Nearside Rear Bumper damaged and likely to cause injury when grazed or contacted (6.1.4 (a) (i))

Nearside Rear Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing at tie bar mount (5.3.6 (a) (i))

Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing at battery tray area (5.3.6 (a) (i))

Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing/turret in 2 places (5.3.6 (a) (i))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Exhaust has a major leak of exhaust gases section missing (6.1.2 (a))

Nearside Rear Tyre has a tear, caused by separation or partial failure of its structure (5.2.3 (d) (ii)) DANGEROUS

Offside Rear Tyre has a tear, caused by separation or partial failure of its structure (5.2.3 (d) (ii)) DANGEROUS

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Corrosion of steering and suspension components

Front Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Integral body structure is repaired but structural rigidity is not significantly reduced front to rear underside (6.1.1 (d) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Rear Upper Shock absorbers has a slightly worn bush on both sides (5.3.2 (c))

Front Exhaust has a minor leak of exhaust gases and rear silencer (6.1.2 (a))

Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing at 2 areas (5.3.6 (a) (i))

Nearside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor/inner sill centre to rear (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rib at rear section (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor and jack point area (5.3.6 (a) (i))

Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i))

Offside Front Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Front Exhaust has a minor leak of exhaust gases and rear silencer (6.1.2 (a))

Front and rear steering and suspension components corroded

Nearside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive wing/chassis (5.3.6 (a) (i))

Nearside Front Suspension arm corroded but not seriously weakened upper and lower (5.3.3 (b) (i))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Suspension arm corroded but not seriously weakened upper and lower (5.3.3 (b) (i))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive jack point area (5.3.6 (a) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Emissions not tested (8.2.1.2 (d))

Front Exhaust has a major leak of exhaust gases (6.1.2 (a))

Nearside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing (5.3.6 (a) (i))

Nearside Front Service brake excessively binding (1.2.1 (f))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis leg (5.3.6 (a) (i))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jack point area (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jack point area (5.3.6 (a) (i))

Offside Front Inner Suspension component mounting prescribed area excessively corroded significantly reducing structural strength wing (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis leg (5.3.6 (a) (i))

Offside Rear Brake linkage has restricted free movement (1.1.15 (e))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength floor (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength jack point area (5.3.6 (a) (i))

Offside Side repeater not working (4.4.1 (a) (ii))

Front and rear steering and suspension components corroded

Nearside Front Inner Suspension component mounting prescribed area is corroded but not considered excessive wing/chassis (5.3.6 (a) (i))

Nearside Front Suspension arm corroded but not seriously weakened upper and lower (5.3.3 (b) (i))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Suspension arm corroded but not seriously weakened upper and lower (5.3.3 (b) (i))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive jack point area (5.3.6 (a) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Fuel tank slightly loose (6.1.3 (a) (i))

Nearside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Nearside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. low (1.2.1 (b) (i))

Offside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Nearside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Nearside Front Coil spring corroded (5.3.1 (b) (i))

Nearside Front Inner Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Front Service brake binding but not excessively (1.2.1 (f))

Offside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Offside Front Inner Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Lower Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Front Upper Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Rear Service brake requirements only just met. It would appear that the braking system requires adjustment or repair (1.2.1 (c))

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Rear Upper Suspension arm corroded but not seriously weakened (2.4.G.1)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Lower Suspension arm corroded but not seriously weakened (2.4.G.1)

Offside Front Upper Suspension arm corroded but not seriously weakened (2.4.G.1)

Nearside Outer Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Nearside Seat belt anchorage prescribed area is excessively corroded floor pan (5.2.6)

Nearside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings floor pan (6.1.B.2)

Offside Front Suspension component mounting prescribed area is excessively corroded inner wing (2.4.A.3)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Nearside Front Lower Suspension arm corroded and seriously weakened (2.4.G.1) DANGEROUS

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Rear Brake pad(s) wearing thin (3.5.1g)

Nearside Rear Upper Suspension arm corroded but not seriously weakened (2.4.G.1)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Lower Suspension arm corroded but not seriously weakened (2.4.G.1)

Offside Front Upper Suspension arm corroded but not seriously weakened (2.4.G.1)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Outer Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Outer Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Rear fog lamp not working (1.3.2b)

Nearside Outer Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Centre Rear Brake hose ferrule excessively corroded (3.6.B.4e)

Nearside Rear brake disc in such a condition that it is seriously weakened (3.5.1i)

Nearside Track rod end ball joint has excessive play (2.2.B.1f)

Nearside rear brake excessively fluctuating (3.7.B.3)

Offside Rear brake disc in such a condition that it is seriously weakened (3.5.1i)

Offside rear brake excessively fluctuating (3.7.B.3)

Nearside Outer Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Service brake: service brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

rear exhaust clamp corroded

Battery insecure

Centre Rear Brake hose has slight corrosion to ferrules (3.6.B.4e)

General oil leaks

General surface corrosion of suspension components

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Nearside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside front brake backplate corroded

Nearside Rear Brake pipe excessively corroded (3.6.B.2c)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Offside Front Track rod end ball joint has excessive play (2.2.B.1f)

Offside Rear Brake pipe excessively corroded (3.6.B.2c)

Offside Rear Tyre(s) incorrect because different size tyres are fitted on the same axle. (4.1.A.1a)

Battery insecure

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Centre Rear Brake hose has slight corrosion to ferrules (3.6.B.4e)

General oil leaks

General surface corrosion of suspension components

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Nearside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside front brake backplate corroded

Wiper blades poor

Offside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Outer Front constant velocity joint gaiter deteriorated (2.5.C.1a)

Rear Brake hose has slight corrosion to ferrules (3.6.B.4e)

General surface corrosion of steering and suspension components

Oil leak

Surface corrosion of metal brake pipes

Nearside Front Front constant velocity joint gaiter deteriorated (2.5.C.1a)

Offside Front Front constant velocity joint gaiter deteriorated (2.5.C.1a)

Nearside Front Front constant velocity joint gaiter deteriorated (2.5.C.1a)

Nearside Headlamp not in a clean condition affecting beam image (1.2.4a)

Offside Front Front constant velocity joint gaiter deteriorated (2.5.C.1a)

Offside Headlamp not in a clean condition affecting beam image (1.2.4a)

Offside Rear Tyre not fitted in accordance with side wall instructions (4.1.D.1f)

Nearside Headlamp not in a clean condition but not affecting beam image (1.2.4a)

Offside Headlamp not in a clean condition but not affecting beam image (1.2.4a)

Offside Rear brake disc slightly scored (3.5.1h)