2004 Ford Galaxy

Front Tyre(s) of different sizes are fitted on the same axle. (5.2.3 (b))

Front passenger door cannot be opened from outside the vehicle (6.2.3 (a))

Nearside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i))

Offside Front Subframe mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Offside Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i))

Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Nearside Front Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Upper Macpherson strut pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Nearside Rear Shock absorbers has light misting of oil (5.3.2 (b))

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Upper Macpherson strut pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Road wheel slightly distorted (5.2.2 (c) (i))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Power steering component has slight seepage from a component (2.1.5 (a))

both rear arches slightly corroded

Brake disc worn, pitted or scored, but not seriously weakened all (1.1.14 (a) (ii))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement all (5.3.4 (a) (i))

Rear Brake pipe corroded, covered in grease or other material axle x 2 (1.1.11 (c))

both rear light units damaged

both rear occasional seatbelts chewed heavily but no occasional rear seats fitted at time of test

o/s drive shaft to gear box splines heavily worn, and quite possible about to round off causing loss of drive

reverse lights not working (pre 2009)

Nearside Front Anti-roll bar pin or bush excessively worn d (5.3.4 (a) (i))

Nearside Parking brake inoperative on one side low effort (1.4.1 (a))

Nearside Steering linkage ball joint has excessive play inner rack joint (can see because rack gaitor split) (2.1.3 (b) (i))

Nearside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Offside Front Anti-roll bar pin or bush excessively worn d (5.3.4 (a) (i))

Offside Front Brake hose excessively deteriorated (1.1.12 (b) (ii))

Offside Front Tyre not fitted in accordance with side wall instructions assymetrical tyre inside/out (5.2.3 (i))

Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Rear Tyre has ply or cords exposed 2254517 (5.2.3 (d) (ii)) DANGEROUS

Offside Rear Tyre has ply or cords exposed (5.2.3 (d) (ii)) DANGEROUS

Brake disc worn, pitted or scored, but not seriously weakened all (1.1.14 (a) (ii))

Nearside Headlamp aim too high (4.1.2 (a))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement all (5.3.4 (a) (i))

Rear Brake pipe corroded, covered in grease or other material axle x 2 (1.1.11 (c))

both rear light units damaged

both rear occasional seatbelts chewed heavily but no occasional rear seats fitted at time of test

o/s drive shaft to gear box splines heavily worn, and quite possible about to round off causing loss of drive

reverse lights not working (pre 2009)

Boot door will not open due to the cycle rack stopping the door opening.

Oil leak, but not excessive borderline leaking excessively from various areas around the engine (8.4.1 (a) (i))

Vehicle was nearly refused a test on the grounds of cleanliness!!!

Brake pad(s) worn down to wear indicator (1.1.13 (a) (i))

Exhaust has a major leak of exhaust gases centre pipe at the rear silencer and the centre box (6.1.2 (a))

Front Registration plate insecure (0.1 (a))

Nearside Front Lower Suspension arm pin or bush excessively worn rear most (5.3.4 (a) (i))

Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Nearside Front Road wheel fixing missing (5.2.1 (a) (i))

Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced marked in yellow wax (7.1.1 (a) (i))

Nearside Headlamp aim too low adjuster not working (4.1.2 (a))

Nearside Rear Seat belt missing rear most in the boot space (7.1.2 (a))

Offside Front Road wheel fixing missing (5.2.1 (a) (i))

Offside Front Seat belt anchorage prescribed area strength or continuity significantly reduced marked in yellow wax (7.1.1 (a) (i))

Offside Headlamp aim too low adjuster not working (4.1.2 (a))

Offside Rear Rear reflector defective or damaged by more than 50% of the reflecting surface (4.8.1 (a) (ii))

Offside Rear Seat belt missing rear most in the boot space (7.1.2 (a))

Nearside Front Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Boot door will not open

Offside Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Oil leak, but not excessive borderline leaking excessively from various areas around the engine (8.4.1 (a) (i))

Vehicle was nearly refused a test on the grounds of cleanliness!!!

Vehicles internal headlight adjuster altered to recheck lights ()

Central Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Rear Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))

Nearside Rear Shock absorbers has a serious fluid leak (5.3.2 (b))

Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis (5.3.6 (a) (i))

Oil leaking excessively from engine (8.4.1 (a) (i))

Central Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Rear Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Central Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Macpherson strut has slight movement at the upper attachment (2.5.A.1c)

Nearside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Nearside Front Subframe mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Rear Road wheel with a slightly distorted bead rim (4.2.A.1a)

Offside Front Macpherson strut has slight movement at the upper attachment (2.5.A.1c)

Offside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Offside Front Subframe mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Nearside Stop lamp not working (1.2.1b)

Offside Front Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Offside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Central Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Macpherson strut has slight movement at the upper attachment (2.5.A.1c)

Nearside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Nearside Front Subframe mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Rear Road wheel with a slightly distorted bead rim (4.2.A.1a)

Offside Front Macpherson strut has slight movement at the upper attachment (2.5.A.1c)

Offside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Offside Front Subframe mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Offside Front Brake hose slightly deteriorated (3.6.B.4d)

Offside Front Suspension arm ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

Nearside Front Brake hose excessively deteriorated (3.6.B.4d)

Offside Front Subframe mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear Tyre has ply or cords exposed (4.1.D.1b)

Offside Front Brake hose slightly deteriorated (3.6.B.4d)

Offside Front Suspension arm ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

both front tyres worn thin on edges

Nearside Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Nearside Front position lamp(s) not working (1.1.A.3b)

Nearside Rear Tyre(s) incorrect because different size tyres are fitted on the same axle. (4.1.A.1a)

Rear Brake pad(s) wearing thin (3.5.1g)

both front tyres worn thin on edges

Items removed from driver's view prior to test

child seats fitted not allowing full inspection of seat belts

Middle row, middle seat & Rear row seat belts only partial check due to child seats fitted

O/S/F tyre worn on edges

O/S/R tyre very worn inner edge

Steering rack boots cracking

Child seat fitted not allowing full inspection of adult belt

nearside front lower ball joint slight wear and dust cover split.

offside front inner CV boot split.

Nearside Front Road wheel bead rim badly distorted (4.2.A.1a)

Offside Stop lamp not working (1.2.1b)

offside front inner CV boot split.

Both third row seat belts have been only partially inspected (child safety seats fitted).

The front service brakes are imbalanced almost to excess (n/s lower).

The n/s/f wheel inner rim is quite badly buckled.

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Tyre has a bulge, caused by separation or partial failure of its structure (4.1.D.1b)

Nearside Rear Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Stop lamp not working (1.2.1b)

Front Brake pad(s) wearing thin (3.5.1g)

Rear registration plate deteriorated (6.3.1d)

Brake pad(s) wearing thin (3.5.1g)