2005 Volvo S40

Covers and Shields fitted

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement Both sides lower wishbone rear bushes have slight play (5.3.4 (a) (i))

Rear Tyre slightly damaged/cracking or perishing Both sides (5.2.3 (d) (ii))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened Both sides (1.1.14 (a) (ii))

Front Windscreen damaged but not adversely affecting driver's view Stone chip (3.2 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened Both sides (1.1.14 (a) (ii))

Rear Coil spring corroded Both sides (5.3.1 (b) (i))

exhaust system deteriorated

under vehicle corroded

Nearside Front Coil spring fractured or broken (5.3.1 (b) (i))

Nearside Rear Road wheel fixing missing (5.2.1 (a) (i))

Offside Rear Road wheel fixing missing (5.2.1 (a) (i))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened Both sides (1.1.14 (a) (ii))

Front Windscreen damaged but not adversely affecting driver's view Stone chip (3.2 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened Both sides (1.1.14 (a) (ii))

Rear Coil spring corroded Both sides (5.3.1 (b) (i))

exhaust system deteriorated

under vehicle corroded

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Front Windscreen damaged but not adversely affecting driver's view stone chips (3.2 (a) (i))

Offside Front Brake hose slightly twisted (1.1.12 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Rear Brake pad(s) wearing thin both sides (1.1.13 (a) (ii))

handbrake travel

under vehicle corrode

Front Headlamp aim projected beam image is obviously incorrect both sides (4.1.2 (c))

Offside Front Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Nearside Front Tyre has a tear, caused by separation or partial failure of its structure (5.2.3 (d) (ii)) DANGEROUS

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Front Windscreen damaged but not adversely affecting driver's view stone chips (3.2 (a) (i))

Offside Front Brake hose slightly twisted (1.1.12 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Rear Brake pad(s) wearing thin both sides (1.1.13 (a) (ii))

handbrake travel

under vehicle corrode

Brake disc worn, pitted or scored, but not seriously weakened Off side and near side front (1.1.14 (a) (ii))

Brake disc worn, pitted or scored, but not seriously weakened Off side and near side rear (1.1.14 (a) (ii))

Nearside Front Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Brake hose slightly twisted (1.1.12 (b) (i))

Offside Front Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Offside Front Tyre slightly damaged (5.2.3 (d) (ii))

Oil leak, but not excessive gear box,sump and suspension (8.4.1 (a) (i))

Slight general corrosion under vehicle at rear

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Brake disc worn, pitted or scored, but not seriously weakened Off side and near side front (1.1.14 (a) (ii))

Brake disc worn, pitted or scored, but not seriously weakened Off side and near side rear (1.1.14 (a) (ii))

Nearside Front Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Brake hose slightly twisted (1.1.12 (b) (i))

Offside Front Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Offside Front Tyre slightly damaged (5.2.3 (d) (ii))

Oil leak, but not excessive gear box,sump and suspension (8.4.1 (a) (i))

Road wheel fixing missing Off side front and off side rear (nut (5.2.1 (a) (i))

Slight general corrosion under vehicle at rear

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Offside Front Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Oil leak, but not excessive (8.4.1 (a) (i))

all rear suspension components corroded

covers & shields fitted

Offside Front Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Oil leak, but not excessive (8.4.1 (a) (i))

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer's specified limits (8.2.1.2 (a))

Exhaust hydrocarbon content after 2nd fast idle exceeds manufacturer's specified limits (8.2.1.2 (a))

Offside Front Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Oil leak, but not excessive (8.4.1 (a) (i))

Oil leak ()

Emissions not tested (7.3.A.1)

Front Tyre(s) incorrect because a tyre fitted to a non-steerable driven axle is of a different type of structure from that fitted to another non-steerable driven axle too big should b on rear of car (4.1.A.2d)

Nearside Front Suspension arm rubber mounting deteriorated resulting in excessive movement (2.4.G.2)

Offside Front Brake hose twisted (found during steering lock to lock check) (2.2.D.2b)

Offside Front Suspension arm rubber mounting deteriorated resulting in excessive movement (2.4.G.2)

Oil leak ()

Exhaust emissions Lambda reading after 2nd fast idle outside specified limits (7.3.D.3)

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Exhaust emissions carbon monoxide content at idle excessive (7.3.D.4)

Exhaust emissions hydrocarbon content after 2nd fast idle excessive (7.3.D.3)

Exhaust emits excessive dense blue smoke during acceleration (7.3.A.2c)

Offside Front wheel bearing rough when rotated (2.5.A.2)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

engine oil low on pre-check (added 2 litres)

nearside rear wheel bearing slightly rough

Nearside Front Shock absorber has a light misting of oil (2.7.3)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear tyre inner edge low

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Exhaust emissions carbon monoxide content at idle excessive (7.3.D.4)

Exhaust emissions hydrocarbon content after 2nd fast idle excessive (7.3.D.3)

Exhaust emits dense blue smoke at idle (7.3.A.2b)

Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Horn not working (1.6.2a)

Nearside Front Shock absorber has a serious fluid leak (2.7.3)

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Rear Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

engine light is on

engine management light on

Offside Rear Registration plate lamp not working (1.1.C.1d)

engine management light on

nearside front tyre wearing close to legal limit

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Nearside Registration plate lamp not working (1.1.C.1d)

Rear Brake pad(s) wearing thin (3.5.1g)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Road wheel with a slightly distorted bead rim (4.2.A.1a)

Rear Brake pad(s) wearing thin (3.5.1g)

NEARSIDE FRONT TYRE TREAD DEPTH NOW 2mm.

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)