1996 Mazda Bongo

Front Lower Suspension arm corroded but not seriously weakened Both sides (5.3.3 (b) (i))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Rear Sub-frame corroded but not seriously weakened Axle (5.3.3 (b) (i))

Rear Suspension arm corroded but not seriously weakened All (5.3.3 (b) (i))

Under body corrosion

Brake disc worn, pitted or scored, but not seriously weakened front and rear (1.1.14 (a) (ii))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Oil leak, but not excessive (8.4.1 (a) (i))

Vehicle structure is corroded but structural rigidity is not significantly reduced underbody (6.1.1 (c) (i))

Brake disc worn, pitted or scored, but not seriously weakened front and rear (1.1.14 (a) (ii))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Oil leak, but not excessive (8.4.1 (a) (i))

Tyre slightly damaged/cracking or perishing all four (5.2.3 (d) (ii))

Tyre slightly damaged/cracking or perishing all four tyres (5.2.3 (d) (ii))

Fuel Pipe/s corroded ()

Exhaust emissions test not completed because smoke levels are significantly in excess of the specified limit values (8.2.2.2 (f))

Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Offside Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting middle of the sill (6.2.2 (d) (i))

Offside Rear Inner Integral body structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Central Fuel Pipe/s corroded ()

Nearside Front Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Offside Front Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Nearside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.1 (c) (ii)) DANGEROUS

Brake lever has insufficient reserve travel (1.1.2 (a))

Front Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Offside Front Anti-roll bar pin or bush excessively worn (5.3.4 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Power steering component leaking (2.1.5 (a))

Oil leak, but not excessive (8.4.1 (a) (i))

Parking brake lever has little reserve travel (3.1.6b)

Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement (7.2.4b)

Nearside Headlamp excessively deteriorated so that the light output is severely reduced (1.7.5a)

Offside Headlamp excessively deteriorated so that the light output is severely reduced (1.7.5a)

Offside Outer Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Parking brake lever has little reserve travel (3.1.6b)

vehicle under body heavily undersealed

Fuel Pipe/s corroded ()

Nearside Front Lower Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Nearside Rear Nail in tyre ()

Oil leak ()

Rear Bumper insecure due to rear crossmember corrosion ()

all brake pipes greased

rear lower crossmember heavily corroded by towbar mounts (TOWBAR NOT FITTED AT TIME OF TEST )

radiator support heavily corroded

Nearside Rear Suspension spring mounting prescribed area is excessively corroded chassis (2.4.A.3)

Offside Rear Suspension spring mounting prescribed area is excessively corroded chassis (2.4.A.3)

Fuel Pipe/s corroded ()

Nearside Front Lower Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Nearside Rear Nail in tyre ()

Oil leak ()

Rear Bumper insecure due to rear crossmember corrosion ()

all brake pipes greased

rear lower crossmember heavily corroded by towbar mounts (TOWBAR NOT FITTED AT TIME OF TEST )

radiator support heavily corroded

Centre Rear Registration plate lamp not working (1.1.C.1d)

Front Sub-frame corroded and seriously weakened radiator support (2.4.G.1)

Fuel cap/sealing device does not fasten securely maintaining the sealing arrangement (7.2.4b)

Nearside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Rear Suspension component mounting prescribed area is excessively corroded inner arch (2.4.A.3)

Nearside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.6.6)

Nearside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner arch (6.1.B.2)

Nearside Seat belt anchorage prescribed area is excessively corroded inner sill (5.2.6)

Nearside Seat belt anchorage prescribed area is excessively corroded outer sill (5.2.6)

Offside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Offside Rear Vehicle structure excessively corroded within 30cm of towbar mounting (6.6.6)

Offside Rear Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings inner arch (6.1.B.2)

Offside Seat belt anchorage prescribed area is excessively corroded inner sill (5.2.6)

Offside Seat belt anchorage prescribed area is excessively corroded outer sill (5.2.6)

Parking brake: efficiency below requirements (3.7.C.1b)

Rear Exhaust has a major leak of exhaust gases flexi (7.1.2)

Nearside Front Lower Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Nearside Rear tyre has a nail in.

Oil leak

all brake pipes heavily coated with grease making inspection difficult

Nearside Front Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

offside front /nearside rear /offside rear tyres perishing

nearside front tyre wearing on outer edge

Nearside Front Suspension arm has excessive play in a ball joint (2.4.G.2)

Offside Front Anti-roll bar linkage has excessive play in a pin/bush (2.4.G.2)

Offside Outer Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

nearside front tyre wearing on outer edge

Headlamp not working on dipped beam (1.7.5a)

Headlamp not working on main beam (1.7.5a)

Nearside Front Anti-roll bar has slight play in a ball joint (2.4.G.2)

All brake discs are corroded.

Both inner side sills are corroded.

Both rear chassis legs are corroded.

Both wiper blades are starting to smear screen.

Exhaust has a minor leak of exhaust gases (7.1.2)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Fuel pipe/s corroded

Nearside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Rear Towbar component slightly corroded (6.6.1)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Non obligatory rear seat belt stalks are fitted poorly

Offside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Oil leak

Power steering component(s) has slight seepage from a component (2.3.3b)

Nearside Front Tyre not fitted in accordance with side wall instructions (4.1.D.1f)

Nearside Front constant velocity joint gaiter split (2.5.C.1a)

Offside Front constant velocity joint gaiter split (2.5.C.1a)

All brake discs are corroded.

Both inner side sills are corroded.

Both rear chassis legs are corroded.

Both wiper blades are starting to smear screen.

Exhaust has a minor leak of exhaust gases (7.1.2)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Fuel pipe/s corroded

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.C.1b)

Nearside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Nearside Rear Towbar component slightly corroded (6.6.1)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside front tyre sidewalls are in poor condition.

Non obligatory rear seat belt stalks are fitted poorly

Offside Rear Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Oil leak

Power steering component(s) has slight seepage from a component (2.3.3b)

Nearside Front constant velocity joint gaiter split (2.5.C.1a)

Offside Front Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Offside Front Wheel nut(s) missing (4.2.A.1e)

Offside Front constant velocity joint gaiter split (2.5.C.1a)

Offside Rear fog lamp emits a light other than red (1.3.2e)

Offside Vehicle structure excessively corroded within 30cm of towbar mounting (6.6.6)

Corrosion to both inner side sills.

Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Body has slight corrosion (6.1.B.2)

Nearside Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.C.1b)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside front tyre is wearing on edges.

Offside Rear Vehicle structure has slight corrosion (6.1.B.2)

Power steering component(s) has slight seepage from a component (2.3.3b)

Centre Exhaust has part of the system excessively deteriorated (7.1.1a)

Front Exhaust has part of the system excessively deteriorated (7.1.1a)

Nearside Front wheel bearing has excessive play (2.5.A.3c)

Nearside Rear Anti-roll bar attachment bracket/mounting insecure (2.4.G.1)

Nearside Rear Tyre has a bulge, caused by separation or partial failure of its structure (4.1.D.1b)

Parking brake lever has no reserve travel (3.1.6b)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Spare tyre defective

Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Parking brake lever has no reserve travel (3.1.6b)

Rear Rear fog lamp missing (1.3.2a)

Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Brake pad(s) wearing thin (3.5.1g)

Front front brake juddering slightly (3.7.A.2b)

Parking brake lever ratchet mechanism is slightly worn (3.1.5)

brake disc slightly pitted (3.5.1h)