2005 Mazda Bongo

Offside Rear Inner Suspension component mounting prescribed area is inadequately repaired Sill has been spot welded (5.3.6 (a) (i))

Central Rear Stop lamp(s) non-obligatory stop lamp not working (4.3.1 (a) (ii))

Front Coil spring corroded Both (5.3.1 (b) (i))

Front Differential mounting bush is deteriorated

Front Prop shaft rear joint has movement

Handbrake has little reserve travel

Nearside Front Integral body structure is corroded but structural rigidity is not significantly reduced Chassis sill (6.1.1 (c) (i))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Drive shaft mounting bush is deteriorated

Offside Front Integral body structure is corroded but structural rigidity is not significantly reduced Chassis sill (6.1.1 (c) (i))

Offside Rear Coil spring corroded (5.3.1 (b) (i))

Offside Rear Outer Chassis sill has been repaired, unsure of method of repair as sill is painted

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened Both (1.1.14 (a) (ii))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Rear Tyre slightly damaged/cracking or perishing Both (5.2.3 (d) (ii))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Offside Front Upper Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Sill (5.3.6 (a) (i))

Central Rear Stop lamp(s) non-obligatory stop lamp not working (4.3.1 (a) (ii))

Front Coil spring corroded Both (5.3.1 (b) (i))

Front Differential mounting bush is deteriorated

Front Prop shaft rear joint has movement

Handbrake has little reserve travel

Nearside Front Integral body structure is corroded but structural rigidity is not significantly reduced Chassis sill (6.1.1 (c) (i))

Offside Front Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Drive shaft mounting bush is deteriorated

Offside Front Integral body structure is corroded but structural rigidity is not significantly reduced Chassis sill (6.1.1 (c) (i))

Offside Rear Coil spring corroded (5.3.1 (b) (i))

Offside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened Both (1.1.14 (a) (ii))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

Rear Tyre slightly damaged/cracking or perishing Both (5.2.3 (d) (ii))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Central Coolant leak ()

Exhaust emits excessive smoke or vapour but not likely to obscure the vision of other road users (8.2.2.2 (c))

Nearside Front Outer Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Nearside Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Offside Front Inner Brake pad(s) wearing thin (1.1.13 (a) (ii))

Offside Front Lower Suspension arm ball joint has slight play (5.3.4 (a) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake disc worn, but not excessively both sides (1.1.14 (a) (i))

Rear Inner Brake pad(s) wearing thin (1.1.13 (a) (ii))

Exhaust emits excessive smoke or vapour but not likely to obscure the vision of other road users (8.2.2.2 (c))

Nearside Rear Integral body structure is corroded but structural rigidity is not significantly reduced Outer seal (6.1.1 (c) (i))

Nearside Rear Integral body structure is corroded but structural rigidity is not significantly reduced Wheel arch (6.1.1 (c) (i))

Offside Front Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Offside Front Inner Brake pad(s) wearing thin (1.1.13 (a) (ii))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Integral body structure is corroded but structural rigidity is not significantly reduced Inner seal (6.1.1 (c) (i))

Offside Obligatory mirror slightly loose (3.3 (b) (i))

Offside Rear Integral body structure is corroded but structural rigidity is not significantly reduced Chassis (6.1.1 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Tyre worn close to legal limit/worn on edge Both (5.2.3 (e))

Rear seats not fitted and obviously not in use

Steering wheel material is deteriorated

Front Windscreen wiper does not clear the windscreen effectively Both (3.4 (b) (ii))

Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Front Outer Track rod end ball joint dust cover insecure so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Offside Front Direction indicator likely to become detached (4.4.1 (c) (ii))

Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Position lamp likely to become detached (4.2.1 (c) (ii))

Exhaust emits excessive smoke or vapour but not likely to obscure the vision of other road users (8.2.2.2 (c))

Nearside Rear Integral body structure is corroded but structural rigidity is not significantly reduced Outer seal (6.1.1 (c) (i))

Nearside Rear Integral body structure is corroded but structural rigidity is not significantly reduced Wheel arch (6.1.1 (c) (i))

Offside Front Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Offside Front Inner Brake pad(s) wearing thin (1.1.13 (a) (ii))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Integral body structure is corroded but structural rigidity is not significantly reduced Inner seal (6.1.1 (c) (i))

Offside Obligatory mirror slightly loose (3.3 (b) (i))

Offside Rear Integral body structure is corroded but structural rigidity is not significantly reduced Chassis (6.1.1 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Tyre worn close to legal limit/worn on edge Both (5.2.3 (e))

Rear seats not fitted and obviously not in use

Steering wheel material is deteriorated

Front Anti-roll bar linkage ball joint has slight play Both (5.3.4 (a) (i))

Front Lower Suspension arm ball joint dust cover severely deteriorated Both (5.3.4 (b) (i))

Nearside Rear Outer Integral body structure is corroded but structural rigidity is not significantly reduced Seal end (6.1.1 (c) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Inner Integral body structure is corroded but structural rigidity is not significantly reduced Seal (6.1.1 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Offside Rear fog lamp not working (4.5.1 (a) (ii))

Offside Side repeater not working (4.4.1 (a) (ii))

Offside Front Driver's seat insecure (6.2.5 (a) (ii)) DANGEROUS

Front Anti-roll bar linkage ball joint has slight play Both (5.3.4 (a) (i))

Front Lower Suspension arm ball joint dust cover severely deteriorated Both (5.3.4 (b) (i))

Nearside Rear Outer Integral body structure is corroded but structural rigidity is not significantly reduced Seal end (6.1.1 (c) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Inner Integral body structure is corroded but structural rigidity is not significantly reduced Seal (6.1.1 (c) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Outer Vehicle structure is deformed but structural rigidity is not significantly reduced sill rear end (6.1.1 (a) (i))

Offside Front Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill rear end (7.1.1 (a) (i))

Rear fog lamp not working (4.5.1 (a) (ii))

Nearside Outer Vehicle structure is deformed but structural rigidity is not significantly reduced sill rear end (6.1.1 (a) (i))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Front Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Front Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Headlamp has a product on the lens but not seriously reducing light output (4.1.4 (b))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Front Headlamp has a product on the light source but not seriously reducing light output (4.1.4 (b))

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Headlamp has a product on the lens but not seriously reducing light output (4.1.4 (b))

Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Headlamp aim too high (1.8)

Offside Headlamp aim too high (1.8)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Centre Rear Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Front Seat belt stitching slightly frayed (5.2.2b)

Offside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Oil leak

Rear Brake pad(s) wearing thin (3.5.1g)

general body corrosion

n/s/f tyre worn outer edge

Rear fog lamp not working (1.3.2b)

Nearside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Front Seat belt stitching slightly frayed (5.2.2b)

Offside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Oil leak

Rear Brake pad(s) wearing thin (3.5.1g)

general body corrosion

n/s/f tyre worn outer edge

Nearside Front Lower Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Nearside Inner Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Nearside Rear Anti-roll bar attachment bracket/mounting fractured (2.4.G.1)

Nearside Rear Anti-roll bar rubber mounting deteriorated resulting in excessive movement (2.4.G.2)

Nearside Rear Tyre has ply or cords exposed (4.1.D.1b)

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Rear Tyre has a bulge, caused by separation or partial failure of its structure (4.1.D.1b)

Offside Rear Tyre has ply or cords exposed (4.1.D.1b)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Rear fog lamp not working (1.3.2b)

Offside Front Lower Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Lower Front suspension ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Offside Outer Rear Lower Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Oil leak

see previous test for advisories

Offside Rear fog lamp not working (1.3.2b)

Nail in offside front tyre

Nearside Front Lower Suspension arm ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Lower Suspension arm ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Oil leak

coolant leak

damage to N/S/f tyre outer sidewall

damage to O/S and N/S sills

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Oil leak

Exhaust emits an excessive level of metered smoke for a turbo charged engine (7.4.B.3b)

Nearside Headlamp aim too low (1.8)

Nearside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement (2.4.G.2)

Nearside Side repeater insecure (1.4.A.2b)

Offside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement (2.4.G.2)

Offside Rear Rear position lamp(s) incorrect colour (1.1.A.3e)

Offside Registration plate lamp not working (1.1.C.1d)

Power steering component(s) leaking (2.3.3b)

Power steering pump drive system defective (2.3.6)

Rear Anti-roll bar rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Stop lamp not working (1.2.1b)

Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Coolant leak

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Oil leak

battery insecure

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front Front constant velocity joint gaiter split (2.5.C.1a)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)