2003 Volvo S40

Brake pipe corroded, covered in grease or other material front to rear (1.1.11 (c))

Nearside Front Macpherson strut pin or bush worn but not resulting in excessive movement top mount (5.3.4 (a) (i))

Nearside door mirror housing damaged

Offside Front Macpherson strut pin or bush worn but not resulting in excessive movement top mount (5.3.4 (a) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Rear suspersion rusty

Nearside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Brake pipe corroded, covered in grease or other material front to rear (1.1.11 (c))

Nearside Front Macpherson strut pin or bush worn but not resulting in excessive movement top mount (5.3.4 (a) (i))

Nearside door mirror housing damaged

Offside Front Macpherson strut pin or bush worn but not resulting in excessive movement top mount (5.3.4 (a) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Rear suspersion rusty

Most underside components corroded.

Nearside Brake pipe corroded, covered in grease or other material Front to rear pipe before joint. Corroded. (1.1.11 (c))

Nearside Front Coil spring corroded (5.3.1 (b) (i))

Nearside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Nearside Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Rear Nail in tyre ()

Nearside Rear Tyre worn close to legal limit/worn on edge 2-3mm. Low on outer edge. (5.2.3 (e))

Rear Brake disc worn, pitted or scored, but not seriously weakened Braking surfaces corroded. (1.1.14 (a) (ii))

Slight blow at catalyst to centre pipe joint.

Fuel cap/sealing device missing (6.1.3 (b) (i))

Nearside Front Position lamp not working (4.2.1 (a) (ii))

Nearside Windscreen wiper does not clear the windscreen effectively Retro fit aero style wiper. (3.4 (b) (ii))

Offside Obligatory mirror seriously damaged, affecting the rear view (3.3 (b) (ii))

Offside Windscreen wiper does not clear the windscreen effectively Retro fit aero style wiper. (3.4 (b) (ii))

Nearside Front Tyre has a bulge, caused by separation or partial failure of its structure Bulge in outside sidewall. 195/60R15 88H. (5.2.3 (d) (ii)) DANGEROUS

Offside Rear Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Most underside components corroded.

Nearside Brake pipe corroded, covered in grease or other material Front to rear pipe before joint. Corroded. (1.1.11 (c))

Nearside Front Coil spring corroded (5.3.1 (b) (i))

Nearside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Nearside Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Rear Nail in tyre ()

Nearside Rear Tyre worn close to legal limit/worn on edge 2-3mm. Low on outer edge. (5.2.3 (e))

Rear Brake disc worn, pitted or scored, but not seriously weakened Braking surfaces corroded. (1.1.14 (a) (ii))

Slight blow at catalyst to centre pipe joint.

Nearside Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Obligatory mirror slightly damaged Recommend replacement. (3.3 (b) (i))

Offside Rear Tyre worn close to legal limit/worn on edge 1.6-2mm. 195/60R15 88H. (5.2.3 (e))

Rear Brake disc worn, pitted or scored, but not seriously weakened Braking surfaces corroded. (1.1.14 (a) (ii))

Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Nearside Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Obligatory mirror slightly damaged Recommend replacement. (3.3 (b) (i))

Offside Rear Tyre worn close to legal limit/worn on edge 1.6-2mm. 195/60R15 88H. (5.2.3 (e))

Rear Brake disc worn, pitted or scored, but not seriously weakened Braking surfaces corroded. (1.1.14 (a) (ii))

Central Exhaust has a minor leak of exhaust gases Join (6.1.2 (a))

Central Rear Brake pipe corroded, covered in grease or other material By fuel tank (1.1.11 (c))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Rear Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Side repeater slightly discoloured Both (4.4.3 (a))

Offside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Central Exhaust has a minor leak of exhaust gases Join (6.1.2 (a))

Central Rear Brake pipe corroded, covered in grease or other material By fuel tank (1.1.11 (c))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Rear Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Side repeater slightly discoloured Both (4.4.3 (a))

Coil spring corroded all (5.3.1 (b) (i))

Front Sub-frame corroded but not seriously weakened + rear (5.3.3 (b) (i))

Integral body structure is corroded but structural rigidity is not significantly reduced underside (6.1.1 (c) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Obligatory mirror slightly damaged (3.3 (b) (i))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Rear Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Suspension arm corroded but not seriously weakened all (5.3.3 (b) (i))

Suspension arm pin or bush worn but not resulting in excessive movement all (5.3.4 (a) (i))

heavy corrosion to all brake backing plates

heavy corrosion to all shock absorbers

no coolant in resevoir

Brake performance not tested pads / springs / tyres (1.2.1 (g))

Central Exhaust has a major leak of exhaust gases + rear (6.1.2 (a))

Emissions not tested engine knocking / no coolant in tank / excessive exhaust blow (8.2.1.2 (d))

Nearside Body component damaged and likely to cause injury mirror housing (6.2.1 (a) (i))

Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Nearside Rear Inner Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Nearside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Offside Front Inner Tyre has a cut in excess of the requirements deep enough to reach the ply or cords sidewall 195/60/15h (5.2.3 (d) (i))

Offside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Power steering fluid reservoir empty (2.1.5 (b) (ii))

Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Rear Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Coil spring corroded all (5.3.1 (b) (i))

Front Sub-frame corroded but not seriously weakened + rear (5.3.3 (b) (i))

Integral body structure is corroded but structural rigidity is not significantly reduced underside (6.1.1 (c) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Obligatory mirror slightly damaged (3.3 (b) (i))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Rear Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Suspension arm corroded but not seriously weakened all (5.3.3 (b) (i))

Suspension arm pin or bush worn but not resulting in excessive movement all (5.3.4 (a) (i))

heavy corrosion to all brake backing plates

heavy corrosion to all shock absorbers

no coolant in resevoir

Central Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Obligatory mirror slightly damaged (3.3 (b) (i))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Brake pipe inadequately clipped or supported over fuel tank, fouling fuel lines (1.1.11 (d) (i))

underbody corroded

Nearside Body component damaged and likely to cause injury mirror (6.2.1 (a) (i))

Nearside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength front of floor (5.3.6 (a) (i))

Offside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced floor rail (6.1.1 (c) (i))

Central Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Obligatory mirror slightly damaged (3.3 (b) (i))

Offside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Brake pipe inadequately clipped or supported over fuel tank, fouling fuel lines (1.1.11 (d) (i))

underbody corroded

General under body corrosion

Nearside Front Non obligatory mirror damaged ()

Offside Front Obligatory mirror slightly damaged (3.3 (b) (i))

Fuel cap/sealing device ineffective (6.1.3 (b) (i))

Offside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

General under body corrosion

Nearside Front Non obligatory mirror damaged ()

Offside Front Obligatory mirror slightly damaged (3.3 (b) (i))

Central Rear Exhaust box outer casing corroded

Nearside Rear Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Offside Front wing mirror slight damage not affecting view to the rear

Central Rear Exhaust box outer casing corroded

Nearside Front Position lamp not working (4.2.1 (a))

Nearside Rear Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Offside Front wing mirror slight damage not affecting view to the rear

Rear Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Front Brake pipe connection leaking on a hydraulic braking system Under bonnet (1.1.11 (b) (ii))

Nearside Brake pipe excessively corroded front to rear (3.6.B.2c)

Nearside Front Anti-roll bar linkage ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2)

Nearside Front Brake hose excessively chafed (3.6.B.4d)

Nearside Front position lamp(s) not working (1.1.A.3b)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Front Brake hose bulging under pressure (3.6.B.3)

Offside Front Direction indicator incorrect colour (1.4.A.2f)

Offside Inner Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Offside Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Nearside Front position lamp(s) not working (1.1.A.3b)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Offside mirror glass cracked

Nearside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Front Front suspension ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Nearside Front top strut mounting bearing rough when rotated

Offside Front tyre bald on inner edge

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear tyre perished

Offside mirror glass cracked

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Brakes imbalanced across an axle (3.7.B.5b)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Offside rear brake excessively fluctuating (3.7.B.3)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside Front Brake pipe excessively corroded (3.6.B.2c)

Nearside Front position lamp(s) not working (1.1.A.3b)

Offside Brake pipe excessively corroded (3.6.B.2c)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Exhaust emissions Lambda reading after 2nd fast idle outside specified limits (7.3.D.3)

Offside Rear Tyre has a tear, caused by separation or partial failure of its structure (4.1.D.1b)

advise n/s/rear tyre outer sidewall aged & perished/exhaust corroded

Centre Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Child seat fitted not allowing full inspection of adult belt

Centre Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Child seat fitted not allowing full inspection of adult belt

Nearside Headlamp aim too low (1.8)

Offside Headlamp aim too low (1.8)