2004 Volvo S60

Corrosion to vehicle underside & suspension components

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement Both front bushes (5.3.4 (a) (i))

Headlamp lens slightly defective Both lenses (4.1.1 (b) (i))

Rear Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Rear Exhaust mounting defective (6.1.2 (a))

Corrosion to vehicle underside & suspension components

Exhaust rear section & mounts corroded

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement Both front bushes (5.3.4 (a) (i))

Headlamp lens slightly defective Both lenses (4.1.1 (b) (i))

Damage to N/S/R tyre outer sidewall

Exhaust backbox outer skin corroded

Exhaust backbox rear mount corroded

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement Both front bushes (5.3.4 (a) (i))

Headlamp lens slightly defective Both (4.1.1 (b) (i))

Nearside Rear Road wheel slightly distorted (5.2.2 (c) (i))

Offside Front Direction indicator slightly discoloured (4.4.3 (a))

Rear Coil spring corroded Both and rear shocks (5.3.1 (b) (i))

Side repeater slightly discoloured Both (4.4.3 (a))

Offside Front Direction indicator slightly discoloured (4.4.3 (a))

Offside Front Brake hose slightly twisted (1.1.12 (b) (i))

Nearside Front Play in steering rack inner joint(s) ()

Offside Front Brake hose slightly twisted (1.1.12 (b) (i))

Nearside Registration plate lamp does not illuminate simultaneously with the position lamps (4.7.2 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Front Play in steering rack inner joint(s) ()

Offside Front Brake hose slightly twisted (1.1.12 (b) (i))

Nearside Front Suspension arm ball joint has slight play (5.3.4 (a) (i))

adv handbrake adjust

Nearside Registration plate lamp does not illuminate simultaneously with the position lamps (4.7.2 (a))

Front Brake disc in such a condition that it is seriously weakened (1.1.14 (a) (ii)) DANGEROUS

Nearside Front Suspension arm ball joint has slight play (5.3.4 (a) (i))

Offside Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

adv handbrake adjust

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Rear Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement front bush (2.4.G.2)

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement front bush (2.4.G.2)

Offside Headlamp damaged but light output not reduced (1.7.5a)

Front Brakes imbalanced across an axle 56% (3.7.B.5b)

Nearside Rear Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement front bush (2.4.G.2)

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement front bush (2.4.G.2)

Offside Headlamp damaged but light output not reduced (1.7.5a)

Offside Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Nearside Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Nearside Front Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Front Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

nearside fromt tyre wearing on inner edge

offside front tyre wearing on inner edge

sills covered by mouldings preventing full inspection of sills

ADV: o/s/f tyre wearing inner edge

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)