1996 Metrocab Manual

Nearside Headlamp excessively damaged so that the light output is severely reduced (1.7.5a)

Registration plate lamp not working (1.1.5c)

Stop lamp not working (1.2.1b)

An item not tested (Manual)

Nearside Axle king pin has excessive play in pin and/or bush adversely affecting the steering (2.5.A.3a)

Nearside Direction indicator not working (1.4.A.2c)

Nearside Leaf spring eye defective (anchor) (2.4.B.1b)

Nearside Leaf spring has excessive side play at eye (anchor) (2.4.B.4)

Nearside Stop lamp not working (1.2.1b)

Nearside rear brake grabbing severely (3.7.A.5b)

Offside Axle king pin has excessive play in pin and/or bush adversely affecting the steering (2.5.A.3a)

Offside Front wheel bearing has excessive play (2.5.A.3c)

Offside Headlamp not working on dipped beam (1.7.5a)

Offside Leaf spring eye defective (anchor) (2.4.B.1b)

Offside Leaf spring has excessive side play at eye (anchor) (2.4.B.4)

Offside rear brake grabbing severely (3.7.A.5b)

Power steering pump leaking from a failed seal (2.3.3b)

Parking brake: efficiency below requirements (3.7.C.1b) DANGEROUS

Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside Front Headlamp flickers when tapped lightly by hand (1.2.4c)

Nearside Front Steering locking device missing (2.2.C.1g)

Nearside Front Steering pivot point has excessive play (2.2.B.1g)

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Nearside Rear position lamp(s) adversely affected by the operation of another lamp (1.1.A.3f)

Offside Rear Braking system leaking (3.6.A.1)

Offside Rear Rear fog lamp not working (1.3.2b)

Offside Rear Stop lamp not working (1.2.1b)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Rear position lamp(s) excessively deteriorated so that it is not visible from a reasonable distance (1.1.A.3d)

Offside rear brake recording little or no effort (3.7.B.5a)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Front Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Axle king pin has slight play in pin and/or bush (2.5.A.3a)

Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

offside rear wheel bearing leaking onto brakes

Rear wheel bearing has slight play (2.6.2)

Brake cable has wires broken and is significantly weakened (3.5.1b)

Front front brake application uneven (3.7.B.2)

Nearside Front Headlamp not in good working order adversely affecting beam image (1.2.4a)

Nearside Front Lower Suspension arm has excessive play in a pin/bush (2.4.G.2)

Nearside Front Windscreen washer provides insufficient washer liquid (8.2.3)

Nearside Rear Rear wheel bearing has excessive play (2.6.2)

Nearside Rear Shock absorber has a serious fluid leak (2.7.3)

Nearside Rear front brake application uneven (3.7.B.2)

Offside Front Front wheel bearing rough when rotated (2.5.A.2)

Offside Front Headlamp aim too low when the centre of the headlamp is below 850mm from the ground (1.6.B2)

Offside Rear Rear position lamp(s) excessively deteriorated so that it is not visible from a reasonable distance (1.1.A.3d)

Offside Rear Stop lamp excessively damaged so that it is not visible from a reasonable distance (1.2.1d)

Parking brake: efficiency below requirements (3.7.B.7)

Power steering component(s) leaking (2.3.3b)

Power steering pump leaking from a failed component (2.3.3b)

Nearside Front Tyre has a bulge, caused by separation or partial failure of its structure (4.1.D.1b) DANGEROUS

Nearside Rear Tyre has a lump, caused by separation or partial failure of its structure (4.1.D.1b) DANGEROUS

Offside Vehicle structure has damage which adversely affects braking or steering (6.1.A.1) DANGEROUS