1997 Volvo V40

Brake hose has slight corrosion to ferrule All ferrules (1.1.12 (f) (i))

general underbody corrosion

Rear Suspension arm pin or bush worn but not resulting in excessive movement Both rear upper arm rear bushes deteriorated and arms starting to corrode (5.3.4 (a) (i))

Various levels of corrosion throughout underside of vehicle

Horn not working (7.7 (a))

Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced Inner arch area (7.1.1 (a) (i))

Offside Front Coil spring fractured or broken (5.3.1 (b) (i))

Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill and rear inner arch area (7.1.1 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis area near front trailing arm bush (5.3.6 (a) (i))

Offside Side repeater not working (4.4.1 (a) (ii))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Both rear upper arm rear bushes deteriorated and arms starting to corrode (5.3.4 (a) (i))

Various levels of corrosion throughout underside of vehicle

Offside Play in steering rack inner joint(s) ()

Offside Rear Inner sill area corroded not deemed excessive at time of test

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Upper Suspension arm pin or bush worn but not resulting in excessive movement Inner bushes deteriorated both sides (5.3.4 (a) (i))

Various amounts of corrosion on underside of vehicle and on steering and suspension components

Vehicle just meets emission levels

Fuel pipes at rear getting rusty

Rear inner near side and off side sills at rear getting very rusty.

Rear of car getting very rusty.

Nearside Front Tyre worn close to legal limit/worn on edge worn on edge (5.2.3 (e))

Offside Front Tyre worn close to legal limit/worn on edge Worn on edge (5.2.3 (e))

Offside Rear Exhaust mounting defective (6.1.2 (a))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement Trailing arm Front bush (5.3.4 (a) (i))

Nearside Rear Direction indicator incorrect colour (4.4.3 (a))

Offside Front Direction indicator incorrect colour (4.4.3 (a))

Offside Front Position lamp not working (4.2.1 (a))

Offside Front Passenger compartment passenger compartment in such a condition that exhaust fumes lead to a danger to health of persons on board (6.2.1 (c) (ii)) DANGEROUS

Nearside Front Tyre worn close to legal limit/worn on edge worn on edge (5.2.3 (e))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Tyre worn close to legal limit/worn on edge Worn on edge (5.2.3 (e))

Offside Rear Exhaust mounting defective (6.1.2 (a))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement Trailing arm Front bush (5.3.4 (a) (i))

Nearside Front Upper Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Rear Suspension arm pin or bush excessively worn trailing arm (5.3.4 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Central Brake pipe corroded, covered in grease or other material central brake pipes corroded (1.1.11 (c))

Exhaust emits blue smoke during acceleration (8.2.1.2 (g))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Nearside Front Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Rear Inner Tyre worn close to legal limit/worn on edge inner shoulder wearing low (5.2.3 (e))

Offside Front Coil spring corroded (5.3.1 (b) (i))

Offside Front Outer Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Seat belt buckle slightly damaged (7.1.2 (d))

Offside Rear Inner Tyre worn close to legal limit/worn on edge inner shoulder wearing low (5.2.3 (e))

Play in steering rack inner joint(s) ()

Rear Direction indicator slightly discoloured (4.4.3 (a))

sill covers fitted

small chip in zone a of windscreen

under side corroded

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Nearside Front Brake hose excessively deteriorated (3.6.B.4d)

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Offside Front Brake hose excessively deteriorated (3.6.B.4d)

Offside Rear Body or chassis has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Fuel Pipe/s corroded near petrol filter ()

Offside Front Seat belt stitching slightly frayed (5.2.2b)

Rear Vehicle structure has slight corrosion chassis areas (6.1.B.2)

Vehicle structure has slight corrosion rear inner sill areas (6.1.B.2)

petrol tank straps showing signs of corrosion

Nearside Front Outer Track rod end ball joint has excessive play (2.2.B.1f)

Offside Front Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Fuel Pipe/s corroded near petrol filter ()

Offside Front Seat belt stitching slightly frayed (5.2.2b)

Rear Vehicle structure has slight corrosion chassis areas (6.1.B.2)

Vehicle structure has slight corrosion rear inner sill areas (6.1.B.2)

petrol tank straps showing signs of corrosion

Both rear tyres perished

Offside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Nearside Rear Direction indicator incorrect colour (1.4.A.2f)

Nearside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Rear position lamp(s) not working (1.1.A.3b)

Offside Front constant velocity joint gaiter deteriorated to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Rear Direction indicator incorrect colour (1.4.A.2f)

Offside Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Body has slight corrosion (6.1.B.2)

Offside Front constant velocity joint gaiter damaged, but preventing the ingress of dirt (2.5.C.1a)

Rear Exhaust has a minor leak of exhaust gases (7.1.2)

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Offside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Body has slight corrosion (6.1.B.2)

Offside Front constant velocity joint gaiter damaged, but preventing the ingress of dirt (2.5.C.1a)

Rear Exhaust has a minor leak of exhaust gases (7.1.2)

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Nearside Front Headlamp aim too low (1.8)

Nearside Rear Brake hose excessively deteriorated (3.6.B.4d)

Offside Front Front position lamp(s) has less than 50% of the light sources illuminating (1.1.A.3b)

Offside Rear Brake pipe excessively corroded (3.6.B.2c)

Exhaust emissions Lambda reading after 2nd fast idle outside specified limits (7.3.D.3)

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Horn not working (1.6.2a)

Nearside Brake pipe excessively corroded (3.6.B.2c)

Nearside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Offside Headlamp aim aimed so that it dazzles other road users (1.8.A.1a)

Offside Headlamp excessively deteriorated so that the light output is severely reduced (1.7.5a)

Exhaust emissions carbon monoxide content after 2nd fast idle excessive (7.3.D.3)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Front Headlamp not working on dipped beam (1.7.5a)

Offside Front Headlamp not working on main beam (1.7.5a)

Offside Rear Stop lamp not working (1.2.1b)