1999 Volvo S40

Front Brake pipe corroded, covered in grease or other material Offside and nearside pipes corroded (1.1.11 (c))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Front Suspension arm corroded but not seriously weakened Offside and nearside (5.3.3 (b) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Offside and nearside floor heavily corroded. UNABLE TO DETECT FAILABLE HOLES WITH CORROSION ASSESSMENT TOOL AT TIME OF TEST. (5.3.6 (a) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Offside and nearside inner wings/turret tops. Inner wheel arch liners fitted, making full assessment difficult. (5.3.6 (a) (i))

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive Inner wing (5.3.6 (a) (i))

Nearside Rear Road wheel slightly distorted Inner rim (5.2.2 (c) (i))

Rear Lower Suspension arm corroded but not seriously weakened Offside and nearside (5.3.3 (b) (i))

Rear Sub-frame corroded but not seriously weakened Offside and nearside chassis rails (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Offside and nearside trailing arm, front bushes heavily deteriorated/de-bonding.ADVISE REPLACEMENT SOON. (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Offside and nearside inner sills (5.3.6 (a) (i))

Seat belt anchorage prescribed area is corroded but not considered excessive Centre chassis rail corroded full length (7.1.1 (a) (i))

inner wheel arch liners and outer sill covers fitted obscuring some components/prescribed areas

Battery insecure and likely to fall from carrier Battery too large for carrier (4.13 (a) (ii))

Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c))

Nearside Front Brake hose excessively deteriorated (1.1.12 (b) (ii))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill. Outer sill covers fitted making full assessment difficult. (5.3.6 (a) (i))

Offside Front Brake hose excessively deteriorated (1.1.12 (b) (ii))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Rear Brake lever has restricted free movement caliper, handbrake lever (1.1.15 (e))

Offside Rear Service brake excessively fluctuating (1.2.1 (e))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Outer sill.(2 Holes) Outer sill covers fitted making full assessment difficult. (5.3.6 (a) (i))

Offside Seat belt anchorage prescribed area strength or continuity significantly reduced Centre chassis rail, at rear (7.1.1 (a) (i))

Offside Stop lamp(s) not working (4.3.1 (a) (ii))

Other passenger door cannot be opened from outside the vehicle Boot lid (6.2.3 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Nearside Rear Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Front Brake hose has slight corrosion to ferrule Offside and nearside heavily corroded (1.1.12 (f) (i))

Front Brake pipe corroded, covered in grease or other material Offside and nearside pipes corroded (1.1.11 (c))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Front Suspension arm corroded but not seriously weakened Offside and nearside (5.3.3 (b) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Offside and nearside floor heavily corroded. UNABLE TO DETECT FAILABLE HOLES WITH CORROSION ASSESSMENT TOOL AT TIME OF TEST. (5.3.6 (a) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Offside and nearside inner wings/turret tops. Inner wheel arch liners fitted, making full assessment difficult. (5.3.6 (a) (i))

Hazard warning switch faulty (4.4.2 (a) (i))

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive Inner wing (5.3.6 (a) (i))

Nearside Rear Position lamp with a multiple light source up to 1/2 not functioning (4.2.1 (a) (i))

Nearside Rear Road wheel slightly distorted Inner rim (5.2.2 (c) (i))

Offside Rear Position lamp with a multiple light source up to 1/2 not functioning (4.2.1 (a) (i))

Offside Rear Tyre worn close to legal limit/worn on edge ON LIMIT. ADVISE REPLACEMENT NOW (5.2.3 (e))

Rear Lower Suspension arm corroded but not seriously weakened Offside and nearside (5.3.3 (b) (i))

Rear Sub-frame corroded but not seriously weakened Offside and nearside chassis rails (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Offside and nearside trailing arm, front bushes heavily deteriorated/de-bonding.ADVISE REPLACEMENT SOON. (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Offside and nearside inner sills (5.3.6 (a) (i))

Seat belt anchorage prescribed area is corroded but not considered excessive Centre chassis rail corroded full length (7.1.1 (a) (i))

inner wheel arch liners and outer sill covers fitted obscuring some components/prescribed areas

Nearside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Outer Suspension component ball joint has slight play (5.3.4 (a) (i))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Rear Brake hose has slight corrosion to ferrule all (1.1.12 (f) (i))

Rear Coil spring corroded both (5.3.1 (b) (i))

all brake backing plates have slight corrosion

near side daytime running lights not working

Emissions not tested (8.2.1.2 (d))

Offside Front Position lamp light intensity significantly reduced (4.2.3 (a) (ii))

Offside Headlamp aim so that beam "kick up" is not visible on the screen (4.1.2 (a))

Offside Rear Anti-roll bar linkage insecurely attached (5.3.3 (a) (i))

Offside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Rear Exhaust has a major leak of exhaust gases (6.1.2 (a))

Rear Brake disc in such a condition that it is seriously weakened both (1.1.14 (a) (ii)) DANGEROUS

Nearside Rear Anti-roll bar pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Outer Suspension component ball joint has slight play (5.3.4 (a) (i))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Rear Brake hose has slight corrosion to ferrule all (1.1.12 (f) (i))

Rear Coil spring corroded both (5.3.1 (b) (i))

all brake backing plates have slight corrosion

near side daytime running lights not working

Front brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

Nearside Front Suspension arm corroded but not seriously weakened (2.4.G.1)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Side repeater slightly discoloured (1.4.A.2f)

Offside Front Outer Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Front Suspension arm corroded but not seriously weakened (2.4.G.1)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Stop lamp has light sources not illuminating, but not more than 50% (1.2.1b)

Rear Brake hose has slight corrosion to ferrules both (3.6.B.4e)

Rear brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

n/side marker light out

vehicle has age related corrosion to underside

Brake fluid warning lamp illuminated (3.6.G.2)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Offside Registration plate lamp not working (1.1.C.1d)

Offside Track rod end ball joint has excessive play (2.2.B.1f) DANGEROUS

Front brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

Nearside Front Suspension arm corroded but not seriously weakened (2.4.G.1)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Side repeater slightly discoloured (1.4.A.2f)

Offside Front Outer Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Offside Front Suspension arm corroded but not seriously weakened (2.4.G.1)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside Stop lamp has light sources not illuminating, but not more than 50% (1.2.1b)

Rear Brake hose has slight corrosion to ferrules both (3.6.B.4e)

Rear brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

n/side marker light out

vehicle has age related corrosion to underside

Front coil spring corroded both (2.4.C.1b)

Rear Brake hose has slight corrosion to ferrules both (3.6.B.4e)

vehicle is showing signs of age related corrosion to underside

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Brake fluid warning lamp illuminated (3.6.G.2)

Front coil spring corroded both (2.4.C.1b)

Rear Brake hose has slight corrosion to ferrules both (3.6.B.4e)

vehicle is showing signs of age related corrosion to underside

Nearside Side repeater slightly discoloured (1.4.A.2f)

Nearside Side repeater slightly discoloured (1.4.A.2f)

Offside Rear position lamp(s) not working (1.1.A.3b)

Body has slight corrosion (6.1.B.2)

Offside Rear position lamp(s) not working (1.1.A.3b)

Offside Side repeater incorrect colour (1.4.A.2f)

Body has slight corrosion (6.1.B.2)

Direction indicators slightly discoloured (1.4.A.2f)

Offside Front Track rod end ball joint dust cover damaged, but preventing the ingress of dirt (2.2.C.1c)

Offside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Exhaust emissions Lambda reading after 2nd fast idle outside specified limits (7.3.D.3)

Hazard warning lamps inoperative (1.4.B.1b)

Hazard warning switch faulty (1.4.B.1d)

Offside Front Track rod end ball joint dust cover damaged, but preventing the ingress of dirt (2.2.C.1c)

Offside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Rear Direction indicator slightly discoloured (1.4.A.2f)

Offside Rear Direction indicator slightly discoloured (1.4.A.2f)

Nearside Rear Direction indicator slightly discoloured (1.4.A.2f)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Rear Direction indicator slightly discoloured (1.4.A.2f)

Offside Rear position lamp(s) not working (1.1.A.3b)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Rear Brake pad(s) wearing thin (3.5.1g)

Offside Headlamp damaged but light output not reduced (1.7.5a)

limited life front and rear brafes

Nearside Headlamp not in good working order adversely affecting beam image (1.2.4a)

Offside Headlamp damaged but light output not reduced (1.7.5a)

limited life front and rear brafes