2002 Jeep Wrangler Sahara

Front Oil leak, but not excessive Differential pinion seal (8.4.1 (a) (i))

Handbrake has long travel

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Outer Drive shaft joint worn, but not excessively (6.1.7 (c) (i))

Handbrake has long travel

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Brake lever has insufficient reserve travel parking brake lever (1.1.2 (a))

Nearside Front Lower Suspension component ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Rear Seat belt webbing significantly weakened cut from edge greater than 2mm (7.1.2 (b))

Offside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis hole (5.3.6 (a) (i))

Offside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i))

Offside Rear Seat belt webbing significantly weakened cut from edge greater than 2mm (7.1.2 (b))

Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced chassis hole (6.1.1 (c) (i))

Rear fog lamp not working (4.5.1 (a) (ii))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b))

Offside Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Central Rear Oil leak, but not excessive (8.4.1 (a) (i))

Central Rear Stop lamp(s) non-obligatory stop lamp not working (4.3.1 (a) (ii))

FRONT POSITION LAMPS ONLY WORK WITH IGNITION ON

Front Drive shaft joint worn, but not excessively AXLE PLAY AT PROP SHAFT (6.1.7 (c) (i))

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive TRAILING ARM MOUNT/CHASSIS LEG (5.3.6 (a) (i))

Nearside Rear Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Anti-roll bar pin or bush worn but not resulting in excessive movement D BUSH (5.3.4 (a) (i))

Offside Front Oil leak, but not excessive (8.4.1 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive TRAILING ARM MOUNT/CHASSIS LEG (5.3.6 (a) (i))

Offside Rear Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Rear Upper Suspension spring mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Steering box has slight free play detected at steering wheel (2.3 (a) (i))

Central Rear Oil leak, but not excessive (8.4.1 (a) (i))

Central Rear Stop lamp(s) non-obligatory stop lamp not working (4.3.1 (a) (ii))

FRONT POSITION LAMPS ONLY WORK WITH IGNITION ON

Front Drive shaft joint worn, but not excessively AXLE PLAY AT PROP SHAFT (6.1.7 (c) (i))

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive TRAILING ARM MOUNT/CHASSIS LEG (5.3.6 (a) (i))

Nearside Rear Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Anti-roll bar pin or bush worn but not resulting in excessive movement D BUSH (5.3.4 (a) (i))

Offside Front Oil leak, but not excessive (8.4.1 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive TRAILING ARM MOUNT/CHASSIS LEG (5.3.6 (a) (i))

Offside Rear Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Rear Upper Suspension spring mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Steering box has slight free play detected at steering wheel (2.3 (a) (i))

Nearside Front Fuel pipe leaking excessively or a risk of fire FUEL LINE LOOSE /FUEL PIPE PERISHING RECOMMEND REPLACEMENT AS SOON AS POSSIBLE (6.1.3 (b) (ii))

Nearside Rear Upper Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength CORRODED AWAY FROM CHASSIS LEG (5.3.6 (a) (i))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Offside Rear Rear fog lamp not working (4.5.1 (a) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Offside Front Steering component mounting prescribed area fractured to the extent that control of the vehicle is likely to be adversely affected CHASSIS LEG CORRODED FRACTURED NEXT TO STEERING BOX (2.1.2 (e) (ii)) DANGEROUS

Central Rear Upper Stop lamp(s) non-obligatory stop lamp not working (4.3.1 (a) (ii))

EML ON

Front FRONT AXLE PLAY AT PROP SHAFT

Front FRONT POSITION LIGHTS ONLY WORK WITH IGNITION ON

Front Oil leak, but not excessive AXLE OS (8.4.1 (a) (i))

Nearside Front Anti-roll bar pin or bush worn but not resulting in excessive movement D BUSH (5.3.4 (a) (i))

Nearside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Anti-roll bar pin or bush worn but not resulting in excessive movement D BUSH (5.3.4 (a) (i))

Offside Front Drive shaft joint worn, but not excessively UNIVERSAL JOINT (6.1.7 (c) (i))

Offside Front Headlamp aim too high (4.1.2 (a))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive TRAILING ARM BRACKET TO CHASSIS LEG (5.3.6 (a) (i))

Offside Rear Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside Rear Upper Suspension spring mounting prescribed area is corroded but not considered excessive CORRODED AT CHASSIS LEG (5.3.6 (a) (i))

Passenger seat(s) missing at time of test REAR ()

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Rear Oil leak, but not excessive AXLE (8.4.1 (a) (i))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Steering box has slight free play detected at steering wheel (2.3 (a) (i))

Vehicles internal headlight adjuster altered to recheck lights ()

Front Front differential leaking

Rear Rear differential leaking

Brake pedal anti-slip provision missing (1.1.2 (c))

Nearside Front Brake performance not tested (1.2.1 (g))

Nearside Front Brake pipe excessively corroded (1.1.11 (c))

Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i))

EML on dash

Front Front differential leaking

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Rear Rear differential leaking

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Nearside Front Lower Suspension component ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

trays and covers fitted obscuring some testable items

Brake pipe corroded, covered in grease or other material various (1.1.11 (c))

Nearside Front Service brake binding but not excessively (1.2.1 (f))

Steering box has slight free play detected at steering wheel (2.3 (a) (i))

Brake pipe corroded, covered in grease or other material brakes pipes corroded throughout. (1.1.11 (c))

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Headlamp lens slightly defective (4.1.1 (b) (i))

Rear suspension components corroded throughout.

Slight oil weep from o/s/f drive shaft oil seal.

slight blow from rear exhaust silencer.

Brake pedal anti-slip provision missing (1.1.2 (c))

Engine MIL inoperative or indicates a malfunction (8.2.1.2 (h))

Nearside Front Direction indicator not working (4.4.1 (a) (ii))

Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Upper Suspension component ball joint excessively worn (5.3.4 (a) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength (5.3.6 (a) (i))

Nearside Front Axle swivel joint so worn or insecure in a stub axle that directional stability is impaired U.J. excessively worn - likely to fail. (5.1.2 (b) (ii)) DANGEROUS

Offside Front Brake disc in such a condition that it is seriously weakened (1.1.14 (a) (ii)) DANGEROUS

Offside Front Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) DANGEROUS

Brake pipe corroded, covered in grease or other material brakes pipes corroded throughout. (1.1.11 (c))

Hazard warning switch faulty (4.4.2 (a) (i))

Nearside Front Brake disc worn, but not excessively (1.1.14 (a) (i))

Nearside Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Headlamp lens slightly defective (4.1.1 (b) (i))

Rear suspension components corroded throughout.

Slight oil weep from o/s/f drive shaft oil seal.

slight blow from rear exhaust silencer.

BRAKE TEST NOT PERFORMED DUE TO WORN BRAKE COMPONENTS AND WORN U.J.

Nearside Front wheel bearing has slight play (2.5.A.3c)

Nearside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

engine light on

Nearside Front wheel bearing has slight play (2.5.A.3c)

Nearside Headlamp not working on dipped beam (1.7.5a)

Nearside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Rear Direction indicator not working (1.4.A.2c)

engine light on

Nearside Rear Inner Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Lower Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear differential oil seal leaking

Fuel cap/sealing device mounting flange/sealing method defective (7.2.4c)

Offside Rear Rear fog lamp not working (1.3.2b)

Offside Rear rear parking brake recording little or no effort (3.7.B.6a)

Rear fog lamp tell tale not working (1.3.1b)

Nearside Rear Inner Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Lower Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear differential oil seal leaking

Centre Stop lamp not working (1.2.1b)

Offside Rear fog lamp not working (1.3.2b)

Offside Side repeater damaged, but still visible from a reasonable distance (1.4.A.2e)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

offside front tyre starting to wear on inner tread

Offside Side repeater damaged, but still visible from a reasonable distance (1.4.A.2e)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

offside front tyre starting to wear on inner tread

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Lower Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Nearside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Front Upper Anti-roll bar has excessive play in a ball joint (2.4.G.2)

Nearside Registration plate lamp not working (1.1.C.1d)

Offside Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Offside Front Front wheel bearing has excessive play (2.5.A.3c)

Offside Front Upper Anti-roll bar has excessive play in a ball joint (2.4.G.2)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

Nearside Rear Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Lower Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Parking brake lever has no reserve travel (3.1.6b)

Nearside Front Anti-roll bar linkage missing (2.4.G.1)

Offside Front Anti-roll bar linkage missing (2.4.G.1)

Offside Front constant velocity joint is excessively worn (2.5.C.1b)

Offside Front wheel bearing has excessive play (2.5.A.3c)

Offside Front wheel bearing rough when rotated (2.5.A.2)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

all four tyres badly perished

centre exhaust corroded and starting to blow (temp seal)

exhaust corroded

nearside front tyre wearing low

Offside Front wheel bearing has slight play (2.5.A.3c)

exhaust badly corroded and starting to blow

Nearside Front position lamp(s) not working (1.1.A.3b)

Offside Rear Anti-roll bar linkage rubber mounting deteriorated resulting in excessive movement (2.4.G.2)

Offside Front wheel bearing has slight play (2.5.A.3c)

exhaust badly corroded and starting to blow

handbrake travel high

(Rear seats not fitted)

Advanced wear in nearside front outer anti-rollbar link (Att soon)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Handbrake travel requires attention

Offside Front Front wheel bearing has slight play (2.5.A.3c)

Offside front outer anti-rollbar link slightly worn

Rear inner and outer anti-rollbar bushes and linkages worn and have slight movement

Front brake discs corroded and brake pads 2/3 worn

Handbrake travel requires attention

Movement in both front wheel bearings

Movement in both rear outer anti-rollbar links

Centre Rear fog lamp not working (1.3.2b)

Front brake discs corroded and brake pads 2/3 worn

Handbrake travel requires attention

Movement in both front wheel bearings

Movement in both rear outer anti-rollbar links

Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.C.1b)

Service brake: service brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.C.1a)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Nearside Front wheel bearing has slight play (2.5.A.3c)

Offside Front wheel bearing has slight play (2.5.A.3c)

slight blow from centre exhaust box

Offside Rear Lower Anti-roll bar linkage has excessive play in a pin/bush (2.4.G.2)

Parking brake lever has no reserve travel (3.1.6b)

Exhaust has part of the system slightly deteriorated (7.1.1a)

Nearside Front wheel bearing has slight play (2.5.A.3c)

Offside Front wheel bearing has slight play (2.5.A.3c)

slight blow from centre exhaust box

Nearside Front wheel bearing has slight play (2.5.A.3c)

Brakes imbalanced across an axle (3.7.B.5b)

Nearside Outer Front Anti-roll bar linkage fractured (2.4.G.1)

Offside Outer Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake: efficiency below requirements (3.7.B.7)

front brake application uneven (3.7.B.2)

Nearside Front wheel bearing has slight play (2.5.A.3c)

handbrake travel requires attention

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front Brake pad(s) wearing thin (3.5.1g)

brake fluid level low

Nearside Front Shock absorber has a serious fluid leak (2.7.3)

Nearside Rear Anti-roll bar linkage has excessive play in a pin/bush (2.4.G.2)

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake lever has no reserve travel (3.1.6b)

Parking brake: efficiency below requirements (3.7.B.7)

Power steering component(s) leaking from a failed seal (2.3.3b)

Service brake: efficiency below requirements (3.7.B.7)

Brake master cylinder fluid close to minimum level (3.6.G.1e)

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Front Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Offside Rear Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

child seat fitted not allowing full inspection of adult belt