1998 Metrocab Manual

Centre Exhaust has a minor leak of exhaust gases (7.1.2)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Front Steering pivot point has excessive play (2.2.B.1g)

Nearside Front Brake hose excessively deteriorated (3.6.B.4d)

Nearside Front Lower Front suspension locking device missing (2.5.A.4)

Nearside Front Lower Suspension weakened allowing body or other component to foul a road wheel or would do so if laden (2.4.A.1b)

Nearside Front Upper Suspension weakened allowing body or other component to foul a road wheel or would do so if laden (2.4.A.1b)

Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Offside Front Brake hose excessively deteriorated (3.6.B.4d)

Parking brake lever has no reserve travel (3.1.6b)

Nearside Rear Tyre has ply or cords exposed (4.1.D.1b) DANGEROUS

Offside Front Suspension weakened allowing body or other component to foul a road wheel or would do so if laden (2.4.A.1b) DANGEROUS

Centre Exhaust has a minor leak of exhaust gases (7.1.2)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Brake pipe slightly corroded (3.6.B.2c)

Fuel pipe/s corroded

Nearside Front Brake hose slightly deteriorated (3.6.B.4d)

Nearside Front wheel bearing has slight play (2.5.A.3c)

Nearside Rear Anti-roll bar linkage has slight play in a pin bearing (2.4.G.2)

Nearside Rear position lamp(s) slightly affected by the operation of another lamp (1.1.A.3f)

Nearside Rear wheel bearing has slight play (2.6.2)

Offside Front Brake hose slightly deteriorated (3.6.B.4d)

Offside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Offside Front wheel bearing has slight play (2.5.A.3c)

Offside Rear position lamp(s) slightly affected by the operation of another lamp (1.1.A.3f)

Offside Rear wheel bearing has slight play (2.6.2)

both sides rear leaf spring front bushes look worn

front coil springs corroded

front wipers slightly split

pedal rubber

Fuel pipe/s corroded

Nearside Front Steering pivot point has slight play (2.2.B.1g)

Nearside Front wheel bearing has slight play (2.5.A.3c)

Offside Front wheel bearing has slight play (2.5.A.3c)

Rear Brake hose slightly deteriorated (3.6.B.4d)

Rear Exhaust has a minor leak of exhaust gases (7.1.2)

variuos areas of corrosion

Fuel pipe/s corroded

Nearside Front Track rod end ball joint has slight play (2.2.B.1f)

Brakes imbalanced across an axle (3.7.B.5b)

Exhaust emits an excessive level of metered smoke for a non-turbo charged engine (7.4.B.3b)

Nearside Rear Leaf spring has excessive wear in a shackle pin and/or bush (2.4.B.2)

Offside Front Front suspension has excessive movement at a wishbone pin or bush (2.5.A.1c)

Offside Front Lower Ball joint has excessive play (2.2.B.1f)

Offside Front Track rod end ball joint has excessive play (2.2.B.1f)

Parking brake: efficiency below requirements (3.7.B.7)

Rear Exhaust system not adequately supported (7.1.1)

Fuel pipe/s corroded

Nearside Front Track rod end ball joint has slight play (2.2.B.1f)

Nearside Front Front position lamp(s) not working (1.1.A.3b)

Nearside Front Seat belt damaged sufficient to obstruct correct operation of the belt (5.2.2a)

Nearside Front Sub-frame rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Rear Exhaust system not adequately supported (7.1.1)

Nearside Rear Exhaust system not adequately supported (7.1.1)

Nearside Registration plate lamp not working (1.1.5c)

Nearside Stop lamp not working (1.2.1b)

Offside Front Bonded suspension unit bonding failed and part of unit is likely to become displaced (2.4.F.2)

Offside Front Front position lamp(s) not working (1.1.A.3b)

Offside Front Front wheel bearing has excessive play (2.5.A.3c)

Offside Front Sub-frame rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Offside Headlamp not in good working order adversely affecting beam image (1.2.4a)

Offside Rear Brake pipe inadequately clipped (3.6.B.1)

Offside Rear Exhaust system not adequately supported (7.1.1)

Offside Rear Shock absorber has an excessively worn bush (2.7.4)

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Steering column universal joint has slight play (2.1.5)

Horn not working (1.6.2a)

Nearside Front Statutory seat belt missing (5.1.1)

Nearside Front Windscreen washer provides insufficient washer liquid (8.2.3)

Offside Headlamp aim too high and too far to the left. (1.8)

Power steering component(s) leaking from a failed seal (2.3.3b)

Steering column universal joint insecure (2.1.5)

registration plate fitted to the rear does not have black characters on a yellow background (6.3.2b)

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Steering column universal joint has slight play (2.1.5)

Axle king pin has slight play in pin and/or bush (2.5.A.3a)

Rear Leaf spring has slight wear in a shackle pin and/or bush (2.4.B.2)