2004 Vauxhall Vivaro

Anti-roll bar pin or bush worn but not resulting in excessive movement All (5.3.4 (a) (i))

Brake disc worn, pitted or scored, but not seriously weakened All (1.1.14 (a) (ii))

Brake pipe corroded, covered in grease or other material All (1.1.11 (c))

Chassis/subframes corroded

Coil spring corroded All (5.3.1 (b) (i))

Front Play in steering rack inner joint(s) Both ()

Front Track rod end ball joint has slight play Both (2.1.3 (b) (i))

Inner and outer sills corroded

Oil leak, but not excessive (8.4.1 (a) (i))

Suspension arm pin or bush worn but not resulting in excessive movement All (5.3.4 (a) (i))

Underbody corroded

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Front Play in steering rack inner joint(s) o/s n/s ()

Offside Front Drive shaft joint worn, but not excessively (6.1.7 (c) (i))

Front Play in steering rack inner joint(s) o/s n/s ()

Offside Front Drive shaft joint worn, but not excessively (6.1.7 (c) (i))

Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii))

Brake pipe corroded, covered in grease or other material front to rear (1.1.11 (c))

Front Brake disc worn, pitted or scored, but not seriously weakened n/s & o/s (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin n/s & o/s (1.1.13 (a) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake pad(s) wearing thin n/s & o/s (1.1.13 (a) (ii))

Brake pipe corroded, covered in grease or other material front to rear (1.1.11 (c))

Front Brake disc worn, pitted or scored, but not seriously weakened n/s & o/s (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin n/s & o/s (1.1.13 (a) (ii))

Nearside Stop lamp(s) not working (4.3.1 (a) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Brake pad(s) wearing thin n/s & o/s (1.1.13 (a) (ii))

Nearside Rear Stop lamp(s) not working (4.3.1 (a) (ii))

Offside Rear Service brake excessively fluctuating (1.2.1 (e))

Rear Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Front Tyre worn close to legal limit/worn on edge Nearside and offside (5.2.3 (e))

Front Tyre slightly damaged/cracking or perishing offside & nearside (5.2.3 (d) (ii))

Nearside Front inner tie rod has slight play

Offside Front Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

underbody corroded

Nearside Front Position lamp not working (4.2.1 (a) (ii))

Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Supplementary restraint system warning lamp indicates a fault (7.1.6 (a))

Front Tyre slightly damaged/cracking or perishing offside & nearside (5.2.3 (d) (ii))

Nearside Front inner tie rod has slight play

Offside Front Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

underbody corroded

Hazard warning switch inoperative (4.4.2 (a) (ii))

Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii))

Nearside Front Seat belt buckle not functioning as intended (7.1.2 (d))

Nearside Indicator switch inoperative (4.4.2 (a) (ii))

Offside Front Headlamp not working on dipped beam (4.1.1 (a) (ii))

Offside Front Prop shaft joint constant velocity boot no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Offside Front Seat belt retracting mechanism defective driver seat (7.1.2 (e))

Offside Rear Direction indicator not working (4.4.1 (a) (ii))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Service brake efficiency below requirements (1.2.2 (a) (i))

Offside Rear Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Rear Service brake efficiency less than 50% of the required value (1.2.2 (a) (ii)) DANGEROUS

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Front Brake pad(s) wearing thin and rear (1.1.13 (a) (ii))

Offside Front Tyre worn close to legal limit/worn on edge outer shoulder (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

abs lamp illuminated then rectified itself

Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength both sides riggers (5.3.6 (a) (i))

Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Offside Rear Body has an unsafe modification lamp casing (6.2.1 (d) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Supplementary restraint system warning lamp indicates a fault (7.1.6 (a))

Windscreen washer provides insufficient washer liquid (3.5 (a))

Front Brake pad(s) wearing thin and rear (1.1.13 (a) (ii))

Offside Front Tyre worn close to legal limit/worn on edge outer shoulder (5.2.3 (e))

Oil leak, but not excessive (8.4.1 (a) (i))

Offside Front Rear position lamp(s) not working (1.1.A.3b)

Offside Rear Rear fog lamp not working (1.3.2b)

Front Exhaust has a minor leak of exhaust gases (7.1.2)

Offside Front Inner Front constant velocity joint gaiter damaged, but preventing the ingress of dirt (2.5.C.1a)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

both front riggers slightly corroded

nearside front steering inner joints slight movement

Both steering rack ends have slight play

Front Both wipers smearing slightly

Front brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

Nearside Front windscreen washer not working

Oil leak

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Rear Tyre has a bulge, caused by separation or partial failure of its structure also badly cracked on sidewall (4.1.D.1b)

rear parking (secondary) brakes imbalanced (3.7.B.6b)

Both steering rack ends have slight play

Front Both wipers smearing slightly

Front brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

Nearside Front Headlamp aim too high (1.8)

Nearside Front windscreen washer not working

Offside Front Headlamp aim too high (1.8)

Oil leak

Rear brake disc worn, pitted or scored, but not seriously weakened both (3.5.1i)

Recommend full brake check

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Offside Front Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Oil leak

Nearside Front Suspension arm has excessive play in a ball joint (2.4.G.2)

Supplementary Restraint System warning lamp indicates a fault (5.4.2)

Offside Front Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Oil leak

Both rear h/brake cables corroding.

Centre h/brake cable corroded.

Clutch pedal rubber missing.

Hazard lights intermitantly inop.

Nearside Front Shock absorber has a light misting of oil (2.7.3)

Nearside Track rod end ball joint has slight play (2.2.B.1f)

Offside Front Shock absorber has a light misting of oil (2.7.3)

Offside Track rod end ball joint has slight play (2.2.B.1f)

Oil leak

Slight damage to front number plate.

Brakes imbalanced across an axle (3.7.D.2c) DANGEROUS

Both rear h/brake cables corroding.

Centre h/brake cable corroded.

Clutch pedal rubber missing.

Hazard lights intermitantly inop.

Nearside Front Shock absorber has a light misting of oil (2.7.3)

Nearside Track rod end ball joint has slight play (2.2.B.1f)

Offside Front Shock absorber has a light misting of oil (2.7.3)

Offside Track rod end ball joint has slight play (2.2.B.1f)

Oil leak

Slight damage to front number plate.

Nearside Front Front position lamp(s) not working (1.1.A.3b)

Both rear h/brake cables corroding.

Centre h/brake cable corroded.

Clutch pedal rubber missing.

Front number plate damaged.

Nearside Front Shock absorber has a light misting of oil (2.7.3)

Nearside Track rod end ball joint has slight play (2.2.B.1f)

Offside Front Shock absorber has a light misting of oil (2.7.3)

Offside Track rod end ball joint has slight play (2.2.B.1f)

Oil leak

n/s/f tyre cut in s/wall. NO cord showing.

Hazard warning lamps inoperative (1.4.B.1b)

Nearside Front position lamp(s) not working (1.1.A.3b)

Both rear h/brake cables corroding.

Centre h/brake cable corroded.

Clutch pedal rubber missing.

Front number plate damaged.

Nearside Front Shock absorber has a light misting of oil (2.7.3)

Nearside Track rod end ball joint has slight play (2.2.B.1f)

Offside Front Shock absorber has a light misting of oil (2.7.3)

Offside Track rod end ball joint has slight play (2.2.B.1f)

Oil leak

n/s/f tyre cut in s/wall. NO cord showing.

clutch pedal rubber missing

cut on o/s front tyre sida wall

n/s front strut damp

poor washer flow to n/s

rear no plate breaking up

Nearside Front Shock absorber has a light misting of oil (2.7.3)

Offside Front Shock absorber has a light misting of oil (2.7.3)

Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.D.4)

both front wiper blades torn

nearside washer jets poor operation

rear brake discs corroded

Centre Stop lamp not working (1.2.1b)

Offside Front Direction indicator insecure (1.4.A.2b)

Nearside Front Tyre has a lump, caused by separation or partial failure of its structure (4.1.D.1b) DANGEROUS

Nearside Front Shock absorber has a light misting of oil (2.7.3)

Offside Front Shock absorber has a light misting of oil (2.7.3)

engine management light on

clutch pedal rubber missing

high level brake light inop cannot see if wired

slight noise from rack

wear on both inner steering rack arms

Nearside Front Road wheel bead rim badly distorted (4.2.A.1a)

Nearside Front Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Nearside Front Windscreen washer provides insufficient washer liquid (8.2.3)

clutch pedal rubber missing

high level brake light inop cannot see if wired

slight noise from rack

wear on both inner steering rack arms

Brakes imbalanced across an axle (3.7.D.2c)

Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Front Service brake application uneven across the axle (3.7.D.2b)

Rear Brake pad(s) less than 1.5 mm thick (3.5.1g)

Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside Front Track rod end ball joint has excessive play (2.2.B.1f) DANGEROUS

offside front inner steering rack joint slight play

rear brake disc inner surfaces corroded