2005 Mitsubishi L200 Double Cab

Service brake effieniency only just met it would appear that the braking system requires adjustment or repair

Suspension component mounting prescribed area is corroded but not considered excessive O/S N/S front and rear (5.3.6 (a) (i))

corrosion underneath

oil leak

slight play in steering

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Rear tyres perished

Nearside Brake pipe excessively corroded front to rear marked in yellow (1.1.11 (c))

Nearside Front Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Nearside Front Headlamp aim too high (4.1.2 (a))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis box section ( bump stop ) (5.3.6 (a) (i))

Nearside Rear Brake pipe excessively corroded across back axle , marked in yellow (1.1.11 (c))

Nearside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced inner arch bottom corroded (7.1.1 (a) (i))

Nearside Rear Shock absorbers has an excessively worn bush lower bush (5.3.2 (c))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis box section ( bump stop ) (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail box section under feet (5.3.6 (a) (i))

Offside Rear Shock absorbers has a serious fluid leak (5.3.2 (b))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength chassis rail , front leaf spring mounting point (5.3.6 (a) (i))

Nearside Front Track rod end ball joint worn to the extent there is a serious risk of detachment (2.1.3 (b) (ii)) DANGEROUS

Offside Front Steering linkage likely to become detached steering column bottom U J joint (2.1.3 (a) (ii)) DANGEROUS

Nearside Front Shock absorbers has slight external damage to the casing (5.3.2 (b))

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Shock absorbers has slight external damage to the casing (5.3.2 (b))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

both near side and off side bump stop rubbers missing

both near side and off side front inner sills under car corroded but not in structural zone at test time

both near side and off side front panel to body mountings corroded but not in structural zone and all secure at test time

rear truck body ( loading bay back ) strengthener box sections under car signs of corrosion, all secure at test time and not part of vehicle structural zones

Steering box has slight free play detected at steering wheel (2.3 (a) (i))

Central Rear Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Front Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Suspension arm ball joint has slight play (5.3.4 (a) (i))

Offside Front Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Suspension arm ball joint has slight play (5.3.4 (a) (i))

Offside Front Suspension arm has slight play in a ball joint (2.4.G.2)

Brake performance not tested brake pedal goes to floor - no brakes! (3.7.A.1)

Nearside Front Lower Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Offside Front Braking system leaking leak at osf (3.6.A.1)

Steering system excessively rough (2.2.D.1)

4x4 light flashing

oil leak from rear diff

Nearside Front brake caliper has restricted free movement (3.5.1k)

Nearside Rear Leaf spring fractured (2.4.B.1a)

Nearside Front brake disc worn, pitted or scored, but not seriously weakened INNER EDGE (3.5.1i)

Offside Front brake disc worn, pitted or scored, but not seriously weakened INNER EDGE (3.5.1i)

Rear Direction indicator slightly discoloured BOTH (1.4.A.2f)

Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Front Upper Suspension arm has slight play in a ball joint (2.4.G.2)

Front Lower Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Outer Front Brake pipe slightly corroded (3.6.B.2c)

Rear Direction indicator slightly discoloured (1.4.A.2f)

Rear Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

Nearside Outer Front Brake pipe excessively corroded (3.6.B.2c)

Front Lower Anti-roll bar linkage rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Outer Front Brake pipe slightly corroded (3.6.B.2c)

Rear Direction indicator slightly discoloured (1.4.A.2f)

Rear Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Brake pipe excessively corroded (3.6.B.2c)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Items removed from driver's view prior to test

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Rear Brake pipe slightly corroded (3.6.B.2c)

Under-trays fitted obscuring some underside components

Centre Exhaust system not adequately supported (7.1.1)

Items removed from driver's view prior to test

Offside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Front Front wheel bearing has slight play (2.5.A.3c)

Rear Brake pipe slightly corroded (3.6.B.2c)

Under-trays fitted obscuring some underside components

very little clearance between both front bump stops and chassis