2005 Mercedes-benz Vito

Central Front NEEDS FIXING BETTER

NEEDS LOOKING AT

Parking brake efficiency below requirements (1.4.2 (a) (i))

Central Front NEEDS FIXING BETTER

NEEDS LOOKING AT

Rear Oil leak, but not excessive DIFFERENTIAL (8.4.1 (a) (i))

Rear Sub-frame is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

UNDERSEAL NEEDED

Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Exhaust emissions exceed level of metered smoke for a turbo charged engine (8.2.2.2 (b))

Nearside Front Inner Track rod end ball joint has excessive play (2.1.3 (b) (i))

Nearside Front Wheel bearing rough when rotated (5.1.3 (b) (i))

Offside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i))

Rear Oil leak, but not excessive DIFFERENTIAL (8.4.1 (a) (i))

Rear Sub-frame is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

UNDERSEAL NEEDED

Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Brake pipe corroded, covered in grease or other material FRONT PARTS OF MAIN (1.1.11 (c))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Nearside Front Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Nearside Rear Coil spring corroded (5.3.1 (b) (i))

Nearside Rear Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Offside Front Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Offside Front Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Rear Coil spring corroded (5.3.1 (b) (i))

Offside Rear Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Rear Registration plate deteriorated but not likely to be misread (0.1 (b))

UNABLE TO CHECK UNDERSIDE FULLY DUE TO THICK UNDERSEAL BEEN PAINTED

Exhaust emissions exceed manufacturer's specified limit 2.15 (8.2.2.2 (a))

Nearside Front Fuel hose leaking (6.1.3 (b) (i))

Nearside Front Headlamp aim too low (4.1.2 (a))

Nearside Rear Parking brake inoperative on one side (1.4.1 (a))

Offside Rear Brake pipe excessively corroded main to connector (1.1.11 (c))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Brake pipe corroded, covered in grease or other material FRONT PARTS OF MAIN (1.1.11 (c))

Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Nearside Front Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Nearside Rear Coil spring corroded (5.3.1 (b) (i))

Nearside Rear Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Front Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Offside Front Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Offside Front Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Rear Coil spring corroded (5.3.1 (b) (i))

Offside Rear Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

UNABLE TO CHECK UNDERSIDE FULLY DUE TO THICK UNDERSEAL BEEN PAINTED

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Nearside Front Brake pipe corroded, covered in grease or other material main brake pipes greased (1.1.11 (c))

Nearside Front Brake pipe corroded, covered in grease or other material undersealed (1.1.11 (c))

Nearside Front Play in steering rack inner joint(s)

Nearside Front Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Nearside Front Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Nearside Rear Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Front Brake pipe corroded, covered in grease or other material undersealed (1.1.11 (c))

Offside Front Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Offside Front Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Rear Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

extensive welding to underside

unable to check underside of van/any underside brake pipes due to thickly undersealed

Anti-lock braking system warning lamp does not illuminate (1.6 (a))

Nearside Front Headlamp aim too low (4.1.2 (a))

Nearside Rear Direction indicator incorrect colour (4.4.3 (a))

Nearside Rear Parking brake inoperative on one side (1.4.1 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Nearside Front Brake pipe corroded, covered in grease or other material main brake pipes greased (1.1.11 (c))

Nearside Front Brake pipe corroded, covered in grease or other material undersealed (1.1.11 (c))

Nearside Front Play in steering rack inner joint(s)

Nearside Front Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Nearside Front Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Inner Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Nearside Rear Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Front Brake pipe corroded, covered in grease or other material undersealed (1.1.11 (c))

Offside Front Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Offside Front Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Suspension arm corroded but not seriously weakened (5.3.3 (b) (i))

extensive welding to underside

unable to check underside of van/any underside brake pipes due to thickly undersealed

Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Service brake efficiency below requirements (1.2.2 (a) (i))

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Nearside Front Play in steering rack inner joint(s)

Offside Front Play in steering rack inner joint(s)

Power steering pipe/hose has slight seepage (2.1.5 (a))

underside coated in underseal

Front Anti-roll bar linkage ball joint has slight play (5.3.4 (a) (i))

Light out warning light on, no lights out

Nearside Obligatory mirror slightly damaged (3.3 (b) (i))

glow plug warning light on

Offside Front Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Exhaust has a minor leak of exhaust gases centre and tail sections (7.1.2)

Nearside Front Steering component damaged but serviceable has slight play at inner tie rod end (2.2.C.1d)

Rear brake disc worn, pitted or scored, but not seriously weakened both sides (3.5.1i)

Offside Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

brake pipes greased in places but appear to be ok

rear exhaust clamp corroded and insecure

slight bind at offside front brake

slight imballance at front brakes

towbar socket incomplete

tyres are wrong ply rating for van

Offside rear parking brake recording little or no effort (3.7.B.6a)

Parking brake lever has no reserve travel (3.1.6b)

Parking brake: efficiency below requirements (3.7.B.7) DANGEROUS

Front Lower Steering column universal joint has slight play (2.1.5)

Nearside Rear rear brake fluctuating, but not excessively (3.7.B.3)

Offside Headlamp has a product on the lens but not seriously reducing light output (1.7.5a)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

slight bind at offside front brake

wheels are incorrect for this vehicle tyres are wrong ply rating for a van

Front front brake binding (3.7.B.1)

Nearside Rear Brake pipe excessively corroded (3.6.B.2c)

Nearside Rear Shock absorber has a serious fluid leak (2.7.3)

Rear coil spring fractured (2.4.C.1a)

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Front Brake pad(s) wearing thin (3.5.1g)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Obligatory mirror damaged, but not seriously affecting the rear view (8.1.2a)

Offside Front Upper Anti-roll bar linkage ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

management light stays on

offside steering rack gaitor a bit mangled but still complete

slight bind at rear brakes

Nearside Steering system has slight free play detected at steering wheel (2.2.A.1b)

Parking brake lever has little reserve travel (3.1.6b)

all brake discs slightly worn

passengers mirror damaged but acceptable

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Offside front brake binding (3.7.B.1)

front brake application uneven (3.7.B.2)

Exhaust has a minor leak of exhaust gases (7.1.2)

Nearside Steering system has slight free play detected at steering wheel (2.2.A.1b)

Parking brake lever has little reserve travel (3.1.6b)

all brake discs slightly worn

passengers mirror damaged but acceptable

Side repeater slightly discoloured (1.4.A.2f)

engine management light stays on

nearside mirror glass cracked

offside steering rack gaitor twisted

slight bind at offside front brake

Exhaust has a part missing (7.1.1a)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside Rear coil spring incomplete (2.4.C.1a) DANGEROUS

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear coil spring fractured (2.4.C.1a)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)