2009 Volvo S40

Nearside Front Inner Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Sub-frame corroded but not seriously weakened and all suspension components (5.3.3 (b) (i))

Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Offside Front Anti-roll bar ball joint excessively worn (5.3.4 (a) (i))

Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Offside Front Position lamp not working (4.2.1 (a) (ii))

Fuel system component leaking excessively or a risk of fire at engine (6.1.3 (b) (ii)) DANGEROUS

Nearside Front Anti-roll bar ball joint likely to become detached (5.3.4 (a) (ii)) DANGEROUS

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Sub-frame corroded but not seriously weakened and all suspension components (5.3.3 (b) (i))

Under Vehicle Under Sealed

Offside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement Rear Bush (5.3.4 (a) (i))

Under Vehicle Under Sealed

Central Exhaust has a major leak of exhaust gases Centre box burst (6.1.2 (a))

Headlamp levelling device inoperative (4.1.5 (a))

Nearside Headlamp aim too low (4.1.2 (a))

Offside Front Headlamp light intensity severely reduced (4.1.4 (a))

Offside Front Inner Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Parking (secondary brake) on a single line braking system has inadequate effort at a wheel Both (1.3.1 (a) (i))

Offside Front Inner Tyre has ply or cords exposed (5.2.3 (d) (ii)) DANGEROUS

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Front Undertray not fully secure (8.1.1 (b) (i))

Offside Front Steering rack gator clip insecure

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Rear Brake pipe corroded, covered in grease or other material Both front to rear (1.1.11 (c))

Rear Coil spring corroded Both (5.3.1 (b) (i))

Rear Suspension component corroded but not seriously weakened All (5.3.3 (b) (i))

Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Front Tyre worn close to legal limit/worn on edge o/s/f n/s/f (5.2.3 (e))

Nearside Front Shock absorbers has light misting of oil (5.3.2 (b))

Offside Headlamp lens slightly defective (4.1.1 (b) (i))

Nearside Headlamp aim too low (4.1.2 (a))

Nearside Headlamp levelling device inoperative (4.1.5 (a))

Offside Headlamp aim too high (4.1.2 (a))

Nearside Rear Tyre has a tear, caused by separation or partial failure of its structure 205/50 zr17 (5.2.3 (d) (ii)) DANGEROUS

Offside Rear Tyre has a tear, caused by separation or partial failure of its structure (5.2.3 (d) (ii)) DANGEROUS

Offside Headlamp lens slightly defective (4.1.1 (b) (i))

Rear Tyre slightly damaged/cracking or perishing Both are heavily perished (5.2.3 (d) (ii))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear arm bush (5.3.4 (a) (i))

Nearside Rear Service brake binding but not excessively (1.2.1 (f))

Nearside Rear Suspension arm pin or bush worn but not resulting in excessive movement trailing arm bush (5.3.4 (a) (i))

Nearside Rear Tyre slightly damaged/cracking or perishing badly perished but no cords showing (5.2.3 (d) (ii))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement trailing arm bush (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing badly perished but no cords showing (5.2.3 (d) (ii))

Offside Rear Anti-roll bar ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement rear arm bush (5.3.4 (a) (i))

Nearside Rear Service brake binding but not excessively (1.2.1 (f))

Nearside Rear Suspension arm pin or bush worn but not resulting in excessive movement trailing arm bush (5.3.4 (a) (i))

Nearside Rear Tyre slightly damaged/cracking or perishing badly perished but no cords showing (5.2.3 (d) (ii))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement trailing arm bush (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing badly perished but no cords showing (5.2.3 (d) (ii))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Rear Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Exhaust heat shield insecure

Front tyres wearing on inner edges

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Tyre slightly damaged/cracking or perishing Perishing on inner sidewall/tread (5.2.3 (d) (ii))

Offside Front Inner Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing Perishing on its inner sidewall (5.2.3 (d) (ii))

Nearside Front Coil spring fractured or broken (5.3.1 (b) (i))

Exhaust heat shield insecure

Front tyres wearing on inner edges

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Tyre slightly damaged/cracking or perishing Perishing on inner sidewall/tread (5.2.3 (d) (ii))

Offside Front Inner Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing Perishing on its inner sidewall (5.2.3 (d) (ii))

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Offside Rear Direction indicator slightly discoloured (1.4.A.2f)

Play in steering rack inner joint(s)

Offside Front coil spring broken (2.4.C.1a)

Play in steering rack inner joint(s)

Nearside front side marker light in-op

Play in steering rack inner joint(s)

Items removed from driver's view prior to test