2004 Ford Transit Connect

Headlamp aim projected beam image is obviously incorrect both sides (4.1.2 (c))

Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i))

Upper Stop lamp(s) not working (4.3.1 (a) (ii))

Central Brake pipe leaking on a hydraulic braking system front/rear (1.1.11 (b) (ii)) DANGEROUS

Nearside Rear Anti-roll bar linkage attachment bracket/mounting likely to fail (5.3.3 (b) (ii)) DANGEROUS

Vehicle structure is so weakened by corrosion within 30cm of a towbar mounting, the towbar is likely to become detached (6.1.6 (i) (ii)) DANGEROUS

Front Tyre worn close to legal limit/worn on edge both sides inner edges (5.2.3 (e))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Front Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Front Headlamp aim projected beam image is obviously incorrect both sides (4.1.2 (c))

Front Headlamp aim too low both sides (4.1.2 (a))

Offside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))

Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i))

Rear Service brake excessively fluctuating (1.2.1 (e))

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Front Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Brake pipe corroded, covered in grease or other material all covered in underseal (1.1.11 (c))

Nearside Front Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Driver's seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i))

Brake pipe corroded, covered in grease or other material all covered in underseal (1.1.11 (c))

Nearside Front Tyre worn close to legal limit/worn on edge inner edge (5.2.3 (e))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Nearside Play in steering rack inner joint(s)

Nearside Rear Suspension component mounting prescribed area is corroded but not considered excessive sill (5.3.6 (a) (i))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Emissions not tested due to major exhaust leaks (8.2.2.2 (e))

Front Brakes imbalanced across an axle (1.2.1 (b) (i))

Front Exhaust has a major leak of exhaust gases flexi (6.1.2 (a))

Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i))

Nearside Front Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i))

Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Nearside Headlamp not working on main beam (4.1.1 (a) (ii))

Nearside Rear Service brake excessively binding (1.2.1 (f))

Nearside Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i))

Offside Front Inner Drive shaft bearing excessively worn (6.1.7 (b) (i))

Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Offside Front Wheel bearing rough when rotated (5.1.3 (b) (i))

Offside Inner Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i))

Offside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i))

Offside Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Rear Exhaust has a major leak of exhaust gases (6.1.2 (a))

Nearside Rear Anti-roll bar attachment bracket/mounting fractured (5.3.3 (b) (ii)) DANGEROUS

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Gearbox mounting defective

Nearside Front Anti-lock braking system wiring damaged but not excessively (1.6 (d))

Nearside Front Inner Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Nearside Rear Road wheel slightly distorted (5.2.2 (c) (i))

Rear Anti-lock braking system wiring damaged but not excessively both insecure (1.6 (d))

Windscreen damaged but not adversely affecting driver's view (3.2 (a) (i))

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Front Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Nearside Front Inner sill corroded

Nearside Front Play in steering rack inner joint(s)

Nearside Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Headlamp lens slightly defective (4.1.1 (b) (i))

Nearside Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Offside Headlamp lens slightly defective (4.1.1 (b) (i))

engine covers and under trays fitted

Driver's seat fore and aft adjustment mechanism not functioning as intended. (6.2.5 (b) (i))

Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Service brake excessively binding (1.2.1 (f))

Nearside Outer Seat belt anchorage prescribed area is inadequately repaired sill (7.1.1 (a) (i))

Nearside Outer Seat belt anchorage prescribed area strength or continuity significantly reduced sill (7.1.1 (a) (i))

Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Offside Outer Seat belt anchorage prescribed area is inadequately repaired sill (7.1.1 (a) (i))

Offside Windscreen wiper does not clear the windscreen effectively (3.4 (b) (ii))

Exhaust fumes causing a danger to health of persons on board tail pipe missing (6.1.2 (b) (ii)) DANGEROUS

Battery insecure but not likely to fall from carrier (4.13 (a) (i))

Front Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Nearside Front Inner sill corroded

Nearside Front Play in steering rack inner joint(s)

Nearside Front Service brake fluctuating, but not excessively (1.2.1 (e))

Nearside Headlamp lens slightly defective (4.1.1 (b) (i))

Nearside Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Offside Headlamp lens slightly defective (4.1.1 (b) (i))

engine covers and under trays fitted

Central Brake pipe corroded, covered in grease or other material Front to rear pipes (1.1.11 (c))

N/S/F OUTER /INNER SILL CORRODDED (NOT WITHIN PRESCRIBED AREA)

Offside Front Lower Suspension arm ball joint has slight play (5.3.4 (a) (i))

Offside Track rod end ball joint has slight play (2.1.3 (b) (i))

Play in steering rack inner joint(s) Both sides

UNDERBODY & SUSPENSION COMPONANTS SUBSTANTIALY CORRODDED

Wiper blades deteriorated

Brake performance not tested (1.2.1 (g))

Front Exhaust has a major leak of exhaust gases (6.1.2 (a))

Nearside Front Brake hose ferrule excessively corroded (1.1.12 (f) (i))

Offside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Rear Direction indicator incorrect colour x2 (4.4.3 (a))

Rear Exhaust has a major leak of exhaust gases (6.1.2 (a))

Offside Front Brake hose connection leaking on a hydraulic braking system hOSE FERRULLE (1.1.12 (c) (ii)) DANGEROUS

Offside Rear Hydraulic brake cylinder excessively corroded and likely to crack (1.1.16 (d) (ii)) DANGEROUS

Central Brake pipe corroded, covered in grease or other material Front to rear pipes (1.1.11 (c))

Handbrake cables deteriorated at drums

N/S/F OUTER /INNER SILL CORRODDED (NOT WITHIN PRESCRIBED AREA)

Offside Front Lower Suspension arm ball joint has slight play (5.3.4 (a) (i))

Offside Track rod end ball joint has slight play (2.1.3 (b) (i))

Play in steering rack inner joint(s) Both sides

Rear Service brake binding but not excessively Both sides (1.2.1 (f))

UNDERBODY & SUSPENSION COMPONANTS SUBSTANTIALY CORRODDED

Wiper blades deteriorated

Brake hose has slight corrosion to ferrules All (3.6.B.4e)

Nearside Front wheel bearing has slight play (2.5.A.3c)

Nearside underfloor sill been repaired but covered in silicone therefore can’t access if continuous welded

Offside Inner Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Offside and nearside outer sillpannels been welded but covered in silicone therefore can’t access if been continuous welded

Play in steering rack inner joint(s) Offside and nearside

Nearside Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Nearside Front Brake hose ferrule excessively corroded (3.6.B.4e)

Nearside Front Seat belt anchorage prescribed area is excessively corroded Outer sill holed (5.2.6)

Offside Front Anti-roll bar linkage ball joint dust cover excessively deteriorated so that it no longer prevents the ingress of dirt (2.4.G.2)

Offside Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Offside Front Brake hose ferrule excessively corroded (3.6.B.4e)

Offside Rear Suspension component mounting prescribed area is excessively corroded Outer sill holed (2.4.A.3)

Nearside Front Tyre worn close to the legal limit On limits on inner edge (4.1.E.1)

Nearside Play in steering rack inner joint(s)

Offside Front Tyre worn close to the legal limit On limits on inner edge (4.1.E.1)

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. 27% (3.7.B.5b)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Brake pedal anti-slip provision incomplete (3.3.A.1b)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded outer sill holed (2.4.A.3)

Offside Rear Anti-roll bar attachment bracket/mounting fractured (2.4.G.1)

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. 27% (3.7.B.5b)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Anti-lock braking system warning lamp indicates an ABS fault (3.4.1c)

Centre Stop lamp not working (1.2.1b)

Nearside Front Lower Suspension arm rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Front suspension has excessive play in a lower suspension ball joint (2.5.B.1a)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Nearside rear brake excessively fluctuating (3.7.B.3)

Offside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside rear brake excessively fluctuating (3.7.B.3)

Rear Exhaust system not adequately supported (7.1.1)

Nearside Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside front tyre worn on inner edge

Brake pipe excessively corroded (3.6.B.2c)

Nearside Front Anti-roll bar linkage has excessive play in a ball joint (2.4.G.2)

Nearside Front Brake pipe excessively corroded (3.6.B.2c)

Nearside Front Front constant velocity joint gaiter damaged to the extent that it no longer prevents the ingress of dirt etc (2.5.C.1a)

Nearside Rear Electrical wiring insecure (1.9.2a)

Offside Front Front suspension ball joint dust cover excessively damaged so that it no longer prevents the ingress of dirt (2.4.G.2)

Nearside front tyre worn on inner edge

Engine covers fitted obscuring some components in the engine bay

Nearside Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Brake pipe slightly corroded (3.6.B.2c)

Under-trays fitted obscuring some underside components

Nearside Rear Registration plate lamp not working (1.1.C.1d)

Offside Front Brake pipe excessively corroded (3.6.B.2c)

Offside Rear Registration plate lamp not working (1.1.C.1d)

Engine covers fitted obscuring some components in the engine bay

Nearside Brake pipe slightly corroded (3.6.B.2c)

Nearside Front Anti-roll bar linkage has slight play in a ball joint (2.4.G.2)

Nearside Front Brake pipe slightly corroded (3.6.B.2c)

Offside Brake pipe slightly corroded (3.6.B.2c)

Under-trays fitted obscuring some underside components

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Front brake disc slightly pitted (3.5.1h)

Front brake disc slightly pitted (3.5.1h)