1999 Ford Transit

Brake pipe corroded, covered in grease or other material Front to rear pipe... (1.1.11 (c))

Front Anti-roll bar linkage pin or bush worn but not resulting in excessive movement O/S & N/S (5.3.4 (a) (i))

Power steering pipe/hose has slight seepage Connections to rack (2.1.5 (a))

Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced O/S & N/S - Outer sills (6.1.1 (c) (i))

Offside Front Lower Suspension spring mounting prescribed area excessively corroded significantly reducing structural strength Lower arm (5.3.6 (a) (i))

Offside Front Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced Within wheel arch (6.1.1 (c) (i))

Offside Rear fog lamp not working (4.5.1 (a) (ii))

Offside Side repeater not working (4.4.1 (a) (ii))

Windscreen washer provides insufficient washer liquid O/S & N/S (3.5 (a))

Brake pipe corroded, covered in grease or other material Front to rear pipe/not secure at rear (1.1.11 (c))

Front Anti-roll bar linkage pin or bush worn but not resulting in excessive movement Perished/split (5.3.4 (a) (i))

Front Vehicle structure is corroded but structural rigidity is not significantly reduced O/S & N/S - Inner sills (6.1.1 (c) (i))

Headlamp lens slightly defective O/S & N/S - Pitted/cloudy (4.1.1 (b) (i))

Nearside Front Vehicle structure is corroded but structural rigidity is not significantly reduced Within wheel arch (6.1.1 (c) (i))

Power steering fluid level below minimum (2.1.5 (b) (i))

Power steering pipe/hose has slight seepage Seals into rack (2.1.5 (a))

Passenger seat(s) missing at time of test

Power steering pipe/hose has slight seepage rack area (2.1.5 (a))

Prop shaft joint worn, but not excessively between front and centre (6.1.7 (c) (i))

general corrosion underneath

Offside Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Offside drivers seat cushion deteriorated

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Headlamp aim too low both n/s and o/s (4.1.2 (a))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b) (ii))

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Front Lower Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Offside Front Lower Suspension arm corroded and seriously weakened (5.3.3 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Headlamp lens seriously defective O/S & N/S Cloudy - no pattern (4.1.1 (b) (ii))

Nearside Rear Service brake excessively binding (1.2.1 (f))

Offside Front Service brake excessively binding (1.2.1 (f))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Electrical wiring likely to touch hot or rotating parts Close to exhaust (4.11 (a) (iii)) DANGEROUS

Nearside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced Cross member fixing corroded/holed (6.1.1 (c) (i))

Offside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced corroded/holed above suspension bump stop (6.1.1 (c) (i))

Brake load sensing valve linkage defective and function impaired Load lever corroded/detached (1.1.17 (a))

Exhaust has a major leak of exhaust gases Tail pipe corroded/holed (6.1.2 (a))

Headlamp lens seriously defective O/S & N/S Lenses cloudy - no beam pattern (4.1.1 (b) (ii))

Nearside Rear Direction indicator incorrect colour Lens smashed (4.4.3 (a))

Nearside Rear Parking (secondary brake) on a single line braking system has inadequate effort at a wheel (1.3.1 (a) (i))

Nearside Rear Service brake lagging in operation (1.2.1 (d))

Nearside Rear Stop lamp(s) lens defective such that the emitted light is adversely affected Lens broken - White light (4.3.1 (b) (ii))

Offside Rear Position lamp not working (4.2.1 (a))

Offside Rear Rear fog lamp lens defective such that emitted light is adversely affected Lens Broken - White light (4.5.1 (b) (ii))

Offside Steering rack gaiter missing or no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Offside Windscreen washer provides insufficient washer liquid (3.5 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Windscreen wiper does not clear the windscreen effectively O/S & N/S (3.4 (b) (ii))

Nearside Rear Inner Tyre tread depth below requirements of 1.6mm 185 R15 103/102 (5.2.3 (e)) DANGEROUS

+++ 2.5lts 15/40 engine oil added prior to smoke test +++

Exhaust has a minor leak of exhaust gases Flexi joint (6.1.2 (a))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement O/S & N/S 'D' Bushes (5.3.4 (a) (i))

Nearside Play in steering rack inner joint(s)

Nearside Rear Vehicle structure is corroded but structural rigidity is not significantly reduced Cross member weld (6.1.1 (c) (i))

Nearside Steering rack gaiter damaged or deteriorated, but preventing the ingress of dirt Twisted (2.1.3 (g) (i))

Offside Front Brake disc worn, pitted or scored, but not seriously weakened Inner surface (1.1.14 (a) (ii))

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Rear Vehicle structure is fractured but structural rigidity is not significantly reduced Above suspension bump stop (6.1.1 (a) (i))

Central Rear Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Nearside Front Tyre tread pattern not visible over the whole tread area when minimum depth required is 1.0mm (5.2.3 (e)) DANGEROUS

Offside Front Tyre tread pattern not visible over the whole tread area when minimum depth required is 1.0mm (5.2.3 (e)) DANGEROUS

Nearside Front Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Front Headlamp deteriorated but light output not reduced (1.7.5a)

Both headlights poor focus

Corrosion to chassis various places.

Nearside Front Inner Suspension component mounting prescribed area is excessively corroded wing (2.4.A.3)

Nearside Rear Suspension component mounting prescribed area is excessively corroded chassis (2.4.A.3)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Front Body has a sharp edge caused by corrosion wing (6.1.C.1)

Offside Front Inner Suspension component mounting prescribed area is excessively corroded wing (2.4.A.3)

Offside Headlamp not working on main beam (1.7.5a)

Offside Rear Direction indicator adversely affected by the operation of another lamp with stop lights (1.4.A.2h)

Offside Rear Suspension component mounting prescribed area is excessively corroded chassis x 3 places (2.4.A.3)

Offside Registration plate lamp not working (1.1.C.1d)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Service brake: efficiency below requirements (3.7.D.4)

Both headlights poor focus

Centre Rear Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.A.1)

Nearside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Lower Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Offside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Rear Vehicle structure has excessive corrosion which adversely affects braking or steering (6.1.A.1)

Parking brake: efficiency below requirements (3.7.B.7)

Rear Brakes imbalanced across an axle Axle 2 (3.7.B.5b)

Rear rear parking (secondary) brakes imbalanced (3.7.B.6b)

Service brake: efficiency below requirements (3.7.B.7)

rear brakes release unevenly (3.7.B.4)

rear parking brake recording little or no effort (3.7.B.6a)

Nearside Front Upper Suspension component mounting prescribed area is excessively corroded (2.4.A.3) DANGEROUS

Offside Front Body has a sharp edge caused by damage (6.1.C.1) DANGEROUS

Offside Front Upper Suspension component mounting prescribed area is excessively corroded (2.4.A.3) DANGEROUS

Rear Brake load sensing valve defective and function impaired (3.6.E.3) DANGEROUS

Centre Front Vehicle structure has slight corrosion (6.1.A.1)

Rear Suspension component mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Vehicle structure has slight corrosion (6.1.A.1)

nsr outer tyre slight damage to sidewall

vechicle heavily undersealed

Exhaust has a minor leak of exhaust gases (7.1.2)

corrosion outside perscibed area

Nearside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside Suspension component mounting prescribed area is inadequately repaired (2.4.A.3)

Offside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front position lamp(s) not working (1.1.A.3b)

Offside Headlamp not working on main beam (1.7.5a)

Offside Rear Leaf spring shackle pin locking device insecurely fitted (2.4.B.3b)

Offside Rear Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Exhaust has a minor leak of exhaust gases (7.1.2)

corrosion outside perscibed area

Brakes imbalanced across an axle (3.7.B.5b)

Nearside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2)

Nearside Front Upper Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Inner Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (4.1.D.1a)

Nearside Rear Lower Shock absorber has an excessively worn bush (2.7.4)

Nearside Rear Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2)

Offside Inner Rear Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Rear position lamp(s) adversely affected by the operation of another lamp (1.1.A.3f)

Vehicle structure excessively corroded within 30cm of towbar mounting (6.6.6)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

propshaft mounting rubbers excessive worn

Brakes imbalanced across an axle (3.7.B.5b)

Nearside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Service brake: efficiency below requirements (3.7.B.7)

Windscreen has a sticker or other obstruction encroaching by more than 10mm within zone 'A' (8.3.1b)

Nearside Front Seat belt anchorage prescribed area is corroded but not considered excessive (5.2.6)

Nearside Front suspension has slight play in a lower suspension ball joint (2.5.B.1a)

Brakes imbalanced across an axle (3.7.B.5b)

Offside Vehicle structure has excessive corrosion, seriously affecting its strength within 30cm of the body mountings (6.1.B.2)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Slight bind nearside front brake,both centre prop joints worn,both front inner wings corroded,chassis corroded & plated

Exhaust has a major leak of exhaust gases (7.1.2)

Nearside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Front Suspension component mounting prescribed area is excessively corroded (2.4.A.3)

Offside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Front brake disc in such a condition that it is seriously weakened (3.5.1i)

Nearside Front position lamp(s) not working (1.1.A.3b)

Nearside Headlamp aim too low (1.8)

Nearside Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement (2.4.B.2)

Nearside Outer Rear Tyre has ply or cords exposed (4.1.D.1b)

Nearside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Nearside Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Offside Headlamp aim too low (1.8)

Offside Leaf spring has a deteriorated anchor pin rubber bush resulting in excessive movement (2.4.B.2)

Offside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Offside Seat belt anchorage prescribed area is excessively corroded (5.2.6)

Offside Subframe mounting prescribed area is excessively corroded (2.4.A.3)

Offside Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Suspension spring mounting prescribed area is excessively corroded (2.4.A.3)

Nearside Inner Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Nearside Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

Offside Inner Front Anti-roll bar rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

Nearside Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

Nearside Seat belt anchorage prescribed area is corroded but not considered excessive (5.2.6)

Offside Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Suspension spring mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Brake pedal anti-slip provision incomplete (3.3.A.1b)

Nearside Brake cable has wires broken and is significantly weakened (3.5.1b)

Nearside Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

Nearside Seat belt anchorage prescribed area is corroded but not considered excessive (5.2.6)

Offside Leaf spring has a slightly deteriorated shackle pin rubber bush not resulting in excessive movement (2.4.B.2)

slight corrosion to o/s and n/s chassis rail

N/S/F TYRE WORN ON INNER AND OUTER EDGES

N/S/R OUTER TYRE WORN ON OUTER EDGE

Hazard warning switch faulty (1.4.B.1d)

Nearside Front Brake hose excessively deteriorated (3.6.B.4d)

Offside Front Brake hose excessively deteriorated (3.6.B.4d)

Offside Rear Lower Shock absorber has an excessively worn bush (2.7.4)

N/S/F TYRE WORN ON OUTER EDGE

N/S/R OUTER TYRE WORN ON OUTER EDGE