2015 Volvo XC90

Engine undertray fit

Front Brake disc worn, pitted or scored, but not seriously weakened Both sides (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Suspension arm pin or bush worn but not resulting in excessive movement Both sides (5.3.4 (a) (i))

Offside Front Anti-roll bar linkage pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Nearside Front tyre-numerous cuts.

Offside Rear Nail in tyre and cuts. ()

Offside Rear floor undertray loose.

engine oil leak.

Nearside Front brakes binding slightly

Nearside Front Coil spring corroded (5.3.1 (b) (i))

Nearside Front Shock absorbers has light misting of oil (5.3.2 (b))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Rear Vehicle structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Stop lamp(s) non-obligatory stop lamp not working (4.3.1 (a) (ii))

Nearside Front Shock absorbers has light misting of oil (5.3.2 (b))

Nearside Front Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Brake disc worn, pitted or scored, but not seriously weakened both rear (1.1.14 (a) (ii))

Brake hose has slight corrosion to ferrule both side rear (1.1.12 (f) (i))

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Front Sub-frame pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Coil spring corroded (5.3.1 (b) (i))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Shock absorbers light misting of oil or has limited damping effect both side front (5.3.2 (b))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

brake servo and master cylinder fitted behind covers can't inspect fully

engine and under body covers fitted

Central Stop lamp(s) not working (4.3.1 (a) (ii))

Nearside Rear Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Supplementary restraint system warning lamp indicates a fault (7.1.6 (a))

Offside Rear Tyre has a bulge, caused by separation or partial failure of its structure (5.2.3 (d) (ii)) DANGEROUS

Brake disc worn, pitted or scored, but not seriously weakened both rear (1.1.14 (a) (ii))

Brake hose has slight corrosion to ferrule both side rear (1.1.12 (f) (i))

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Front Sub-frame pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Coil spring corroded (5.3.1 (b) (i))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Shock absorbers light misting of oil or has limited damping effect both side front (5.3.2 (b))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

brake servo and master cylinder fitted behind covers can't inspect fully

engine and under body covers fitted

Front Brake disc significantly and obviously worn metal on metal (1.1.14 (a) (i))

Front Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Brake disc worn, pitted or scored, but not seriously weakened both side rear (1.1.14 (a) (ii))

Coil spring corroded both side front (5.3.1 (b) (i))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Offside Headlamp lens slightly defective (4.1.1 (b) (i))

Offside Rear Coil spring corroded (5.3.1 (b) (i))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Rear Subframe mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Shock absorbers light misting of oil or has limited damping effect both side front (5.3.2 (b))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Sub-frame pin or bush worn but not resulting in excessive movement both side front (5.3.4 (a) (i))

Tyre slightly damaged/cracking or perishing both side rear (5.2.3 (d) (ii))

brake servo and master cylinder fitted behind covers can't inspect fully

engine and under body covers fitted

Exhaust emissions exceed manufacturer's specified limit (8.2.2.2 (a))

Power steering malfunctioning (2.1.5 (a))

Brake disc worn, pitted or scored, but not seriously weakened both side rear (1.1.14 (a) (ii))

Coil spring corroded both side front (5.3.1 (b) (i))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Offside Headlamp lens slightly defective (4.1.1 (b) (i))

Offside Rear Coil spring corroded (5.3.1 (b) (i))

Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Rear Subframe mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Shock absorbers light misting of oil or has limited damping effect both side front (5.3.2 (b))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Sub-frame pin or bush worn but not resulting in excessive movement both side front (5.3.4 (a) (i))

Tyre slightly damaged/cracking or perishing both side rear (5.2.3 (d) (ii))

brake servo and master cylinder fitted behind covers can't inspect fully

engine and under body covers fitted

Items removed from driver's view prior to test ()

Nearside Front Tyre has a cut but not deep enough to reach the ply or cords Tyre De-Laminating (5.2.3 (d) (i))

Nearside Rear Child Seat fitted not allowing full inspection of adult belt ()

Offside Rear Child Seat fitted not allowing full inspection of adult belt ()

Brake disc worn, pitted or scored, but not seriously weakened both side rear (1.1.14 (a) (ii))

Coil spring corroded both front (5.3.1 (b) (i))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Offside Rear Coil spring corroded (5.3.1 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Rear Subframe mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Sub-frame pin or bush worn but not resulting in excessive movement both side front (5.3.4 (a) (i))

brake master and servo fitted behind covers can't inspect fully

engine and under body covers fitted

Nearside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Brake disc worn, pitted or scored, but not seriously weakened both side rear (1.1.14 (a) (ii))

Coil spring corroded both front (5.3.1 (b) (i))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Offside Rear Coil spring corroded (5.3.1 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Rear Subframe mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Sub-frame pin or bush worn but not resulting in excessive movement both side front (5.3.4 (a) (i))

brake master and servo fitted behind covers can't inspect fully

engine and under body covers fitted

Front Sub-frame corroded but not seriously weakened (2.4.G.1)

Front Sub-frame rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear Sub-frame corroded but not seriously weakened (2.4.G.1)

Rear Subframe mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Shock absorber has a light misting of oil both side front (2.7.3)

brake disc worn, pitted or scored, but not seriously weakened both side front (3.5.1i)

brake disc worn, pitted or scored, but not seriously weakened both side rear (3.5.1i)

brake servo and master cylinder fitted behind covers can't inspect fully

coil spring corroded both front (2.4.C.1b)

coil spring corroded both rear (2.4.C.1b)

engine and under body covers fitted

Central Stop lamp not working (1.2.1b)

Front Sub-frame corroded but not seriously weakened (2.4.G.1)

Front Sub-frame rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear Sub-frame corroded but not seriously weakened (2.4.G.1)

Rear Subframe mounting prescribed area is corroded but not considered excessive (2.4.A.3)

Shock absorber has a light misting of oil both side front (2.7.3)

brake disc worn, pitted or scored, but not seriously weakened both side front (3.5.1i)

brake disc worn, pitted or scored, but not seriously weakened both side rear (3.5.1i)

brake servo and master cylinder fitted behind covers can't inspect fully

coil spring corroded both front (2.4.C.1b)

coil spring corroded both rear (2.4.C.1b)

engine and under body covers fitted

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Engine covers fitted obscuring some components in the engine bay

Items removed from driver's view prior to test

Under-trays fitted obscuring some underside components

Offside Front Headlamp not working on dipped beam (1.7.5a)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nail in nearside rear tyre

oil weep from turbo unit

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front Brake pad(s) wearing thin (3.5.1g)

Offside Front Headlamp aim not tested (1.8.A.1c)

Offside Front Headlamp not working on dipped beam (1.7.5a)