2008 Toyota Aygo

Nearside Rear Brake pipe excessively corroded from brake hose to front (1.1.11 (c))

Nearside Rear Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill , from a previously repaired weld (6.1.1 (c) (i))

Offside Rear Brake pipe excessively corroded from brake hose to front (1.1.11 (c))

Offside Rear Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill , from a previously repaired weld (6.1.1 (c) (i))

Offside Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting inner sill (6.2.2 (d) (i))

Nearside Rear Tyre has a tear, caused by separation or partial failure of its structure 155.65.14 t (5.2.3 (d) (ii)) DANGEROUS

Offside Rear Tyre has a tear, caused by separation or partial failure of its structure 155.65.14 t (5.2.3 (d) (ii)) DANGEROUS

Front Anti-roll bar pin or bush worn but not resulting in excessive movement both sides splitting & perished (5.3.4 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened both sides (1.1.14 (a) (ii))

Nearside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Rear axle corroded

Front Brake hose has slight corrosion to ferrule both sides on the attachment brackets on shock absorbers (1.1.12 (f) (i))

Front Lower Anti-roll bar linkage pin or bush worn but not resulting in excessive movement both sides short links top and bottom rubber bushes are heavily perished (5.3.4 (a) (i))

Front Oil leak, but not excessive (8.4.1 (a) (i))

Front Sub-frame corroded but not seriously weakened both sides of the subframe (5.3.3 (b) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Original test by I.H. Buckland 09.10.2023

Rear Brake hose has slight corrosion to ferrule both rear brake hoses and offside brake hose from hose (1.1.12 (f) (i))

Rear Coil spring corroded both sides offside is heavily corroded (5.3.1 (b) (i))

Rear Outer Tyre slightly damaged/cracking or perishing both rear tyres are heavily cracked on the outer treads (5.2.3 (d) (ii))

Rear Sub-frame corroded but not seriously weakened both sides of the subframe (5.3.3 (b) (i))

Rear Sub-frame pin or bush worn but not resulting in excessive movement both sides are perished (5.3.4 (a) (i))

Suspension component mounting prescribed area is corroded but not considered excessive off side rear (5.3.6 (a) (i))

Front Position lamp not working both sides (4.2.1 (a) (ii))

Front Windscreen wiper does not clear the windscreen effectively long blade rubber is split (3.4 (b) (ii))

Nearside Front Inner Tyre has a cut in excess of the requirements deep enough to reach the ply or cords (5.2.3 (d) (i))

Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced rear sill is holed after previous repair (6.1.1 (c) (i))

Rear Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting both sides above and around rear subframe mountings (6.2.2 (d) (i))

Offside Front Inner Tyre has ply or cords exposed (5.2.3 (d) (ii)) DANGEROUS

Front Brake hose has slight corrosion to ferrule both sides on the attachment brackets on shock absorbers (1.1.12 (f) (i))

Front Lower Anti-roll bar linkage pin or bush worn but not resulting in excessive movement both sides short links top and bottom rubber bushes are heavily perished (5.3.4 (a) (i))

Front Oil leak, but not excessive (8.4.1 (a) (i))

Front Sub-frame corroded but not seriously weakened both sides of the subframe (5.3.3 (b) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Rear Brake hose has slight corrosion to ferrule both rear brake hoses and offside brake hose from hose (1.1.12 (f) (i))

Rear Coil spring corroded both sides offside is heavily corroded (5.3.1 (b) (i))

Rear Outer Tyre slightly damaged/cracking or perishing both rear tyres are heavily cracked on the outer treads (5.2.3 (d) (ii))

Rear Sub-frame corroded but not seriously weakened both sides of the subframe (5.3.3 (b) (i))

Rear Sub-frame pin or bush worn but not resulting in excessive movement both sides are perished (5.3.4 (a) (i))

Offside Front Wheel bearing slightly noisy (5.1.3 (b) (i))

i)Both rear tyres perished (excessively cracked) ii)rear coil springs corroded iii)rear brake pipes corroded iv)engine oil leak v)exhaust support fractured

Headlamp aim too high n/side (4.1.2 (a))

Offside Front Wheel bearing slightly noisy (5.1.3 (b) (i))

Position lamp not working each front (4.2.1 (a) (ii))

Windscreen washer jets misaligned and not providing sufficient fluid to the windscreen (3.5 (a))

i)Both rear tyres perished (excessively cracked) ii)rear coil springs corroded iii)rear brake pipes corroded iv)engine oil leak v)exhaust support fractured

Central Front Exhaust has a minor leak of exhaust gases manifold (6.1.2 (a))

Central Front Exhaust mounting defective (6.1.2 (a))

Nearside Rear Outer Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Rear Outer Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Nearside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i))

Offside Rear Vehicle structure corroded to the extent that the rigidity of the assembly is significantly reduced outer sill (6.1.1 (c) (i))

Offside Front Lower Suspension arm pin or bush likely to become detached lower arm rear bush bonding broke loose (5.3.4 (a) (ii)) DANGEROUS

Central Front Exhaust has a minor leak of exhaust gases manifold (6.1.2 (a))

Central Front Exhaust mounting defective (6.1.2 (a))

Nearside Rear Outer Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Rear Outer Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Nearside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c))

Nearside Rear Service brake excessively binding (1.2.1 (f))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Both rear coil springs corroded

Nearside Rear Coil spring mounting corroded but not seriously weakened (5.3.1 (b) (i))

Original full test by T.G.Button 01.04.2019

Offside Rear Coil spring fractured or broken (5.3.1 (b) (i))

Nearside Rear Coil spring mounting corroded but not seriously weakened (5.3.1 (b) (i))

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Front Front position lamp(s) not working (1.1.A.3b)

Offside Front Road wheel slightly damaged (4.2.A.1a)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside rear brake binding (3.7.B.1)

Nearside Rear Brake pipe slightly corroded (3.6.B.2c)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Brake pipe slightly corroded (3.6.B.2c)

Offside rear brake fluctuating, but not excessively (3.7.B.3)

Brake pipe slightly corroded (3.6.B.2c)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Nearside rear tyre cracking

Nearside rear tyre worn on inner edge

Offside rear brakes lightly binding

Oil level low

Nearside Front Road wheel slightly damaged (4.2.A.1a)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside rear tyre worn on edges

Nearside Front Road wheel slightly damaged (4.2.A.1a)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside rear tyre worn on inner edge

Nearside Front Road wheel slightly damaged (4.2.A.1a)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside rear tyre worn on inner edge

Offside Headlamp aim too low (1.8)